2005 Yamaha Motorsports SXVenom ER Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2005 Yamaha Motorsports SXVenom ER manuals!
Problems with 2005 Yamaha Motorsports SXVenom ER?
Ask a Question
Other Models
Free 2005 Yamaha Motorsports SXVenom ER manuals!
Problems with 2005 Yamaha Motorsports SXVenom ER?
Ask a Question
Other Models
Popular 2005 Yamaha Motorsports SXVenom ER Manual Pages
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
...performance of this snowmobile, it is important that have any questions concerning the operation or maintenance of a Yamaha snowmobile.
If you have made Yamaha a leader in the production of this manual. It represents the high degree of craftsmanship and reliability... ESU00011
2- SXV60K SXV60ERK VT60K OWNER'S MANUAL ©2004 by Yamaha Motor Corporation, U.S.A. 1st Edition, ...
Owners Manual - Page 5
... ALERT! CAUTION:
@
A CAUTION indicates special precautions that must be taken to avoid damage to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile. Therefore, while this manual contains the most current product information available at the time of printing, there may be considered a permanent part of this snowmobile and should...
Owners Manual - Page 6
... WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-5 Fuel meter and grip/thumb warmer level indicator...5-5 Fuel...
Owners Manual - Page 7
... the engine...7-11 Transporting ...7-12 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-6 Throttle cable adjustment ...8-6 Oil pump cable ...replacement...8-29 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3
WIRING DIAGRAM ...12-1
Owners Manual - Page 14
... perform the pre-operation checks on public streets, roads, or highways. Check the throttle, brake, and steering for use is released. 6. This may result if you could collide with another vehicle. 3. ESU00090
3- Never drive the snowmobile with all labels before starting the engine.
Become familiar with the parking brake applied. Read the Owner's Manual...
Owners Manual - Page 15
... after refueling. it is running into your eyes, see your exposure to cool for operation of established trails. Allow the engine to hazards. Never fill the fuel tank indoors.
G Fill the fuel tank outdoors with care; Ride slowly and cautiously when you ride. Wipe up any gasoline spills on established trails to minimize...
Owners Manual - Page 21
will not work properly. Otherwise, the T.O.R.S. will operate
CA-01E
B
Item Throttle switch Carburetor switch Engine È É Ê 1 2 3 4 a b Idling/starting Running Trouble Carburetor switch Throttle switch Throttle ... the T.O.R.S. is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the...
Owners Manual - Page 24
... segments of the above problems by the self-diagnosis device of the grip/thumb warmer level indicator flashes once if the grip/thumb warmer adjustment switch is continually pressed at the maximum level. When the engine is displayed for warning indicator, warning light and fuel meter segment flash pattern.) When this pattern.
: On...
Owners Manual - Page 25
...and warning light flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead, or... above problems by the self-diagnosis device of the snowmobile. If the oil level warning indicator and the warning light come on, add engine oil...
Owners Manual - Page 26
... self-diagnosis warning indicator and warning light flash continuously during operation, there may be some problem with the electrical circuit, lead couplers, etc. (See page 5-9 for warning indicator and warning light flash pattern numbers 1-5.) Stop the engine and allow it to cool off. If the self-diagnosis warning indicator and warning light...
Owners Manual - Page 35
... oil
ESU00086
Coolant
Check the coolant level in the coolant reservoir when the engine is not recommended.
G G G
@
age. Gasohol containing methanol is cold. NOTE:
@
Since the fuel tank cap and oil tank cap look similar, be careful not to the engine parts. Make sure that there is sufficient oil in an emergency.
6-2
ESU00299...
Owners Manual - Page 43
... when the starter lever (choke) is returned to the closed position.
@
Manual starting ) Half-open position. Turn the main switch to check the "SAFETY INFORMATION" section carefully before starting )
NOTE:
@
The starter lever (choke) is not required when the engine is in the on the recoil starter until it briskly. Warm up...
Owners Manual - Page 44
... the emergency starter rope on any one attempt.
@
ESU00248
Emergency engine starting
Manual starting model For SXV60 If the recoil starter system should be as short as follows. Electric starting model".
2. After the engine starts, put the starter lever (choke) in the tool kit at the factory.
@
1. NOTE:
@
The emergency starter rope and a screwdriver...
Owners Manual - Page 45
...pull briskly. Install the drive guard and shroud.
Warm up the engine until it does not run roughly or begin to stall when the...primary sheave assembly. 1 Rope stopper 2 Primary sheave assembly edge
4. After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 Mesh the rope stopper with the moving primary sheave ...
Owners Manual - Page 47
... snow require much longer stopping distances.
To start the engine. Before operating the snowmobile, read this Owner's Manual completely and understand the operation of time. totally familiar ... learn the basic techniques well before attempting more reliable snowmobile. Once the engine has warmed up, you ride, always perform the preoperation checks listed on pages 8-1-8-3. Improper...
Owners Manual - Page 58
... wrench available during a service operation requiring one, take the snowmobile to a different type of the engine. A
ESU01430
Tool kit
The owner's tool kit has the tools which ...engine component and is being ridden normally. If a spark plug shows a distinctly different color, there could indicate an intake track air leak or carburetion problem for most periodic maintenance and minor repair...
Owners Manual - Page 64
...performance of a gasoline engine to about 3% for every 305 m (1,000 ft) of 900 m (3,000 ft). This is because there is available at higher altitudes. Proper carburetion adjustments will correct the air/fuel...@
8-10 Common problems are the most of the problems found in high ...horsepower available, even with less power at high altitudes, your snowmobile at high altitude makes the air/fuel...
Owners Manual - Page 85
... filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the ignition off to inspect. 3. Ask a Yamaha dealer to expel excess fuel. Incorrect V-belt clutch settings for altitude or conditions ...Ask a Yamaha dealer to lack of lubrication. 3. above . 4. Problem with the correct V-belt...
Owners Manual - Page 89
SPECIFICATIONS
SXV60/SXV60ER/VT60 2,780 mm (...Engine oil type Carburetor type Fuel
SXV60/SXV60ER/VT60 Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV60 Electric and manual with recoil starter: SXV60ER/VT60 Pump...
2005 Yamaha Motorsports SXVenom ER Reviews
We have not received any reviews for the 2005 Yamaha Motorsports SXVenom ER yet.