2005 Yamaha Motorsports RS Venture Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2005 Yamaha Motorsports RS Venture manuals!
Problems with 2005 Yamaha Motorsports RS Venture?
Ask a Question
Other Models
Free 2005 Yamaha Motorsports RS Venture manuals!
Problems with 2005 Yamaha Motorsports RS Venture?
Ask a Question
Other Models
Popular 2005 Yamaha Motorsports RS Venture Manual Pages
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
... operation, inspection, and basic maintenance of fine sporting and touring snowmobiles. It represents the high degree of craftsmanship and reliability that you and your purchase of this manual. To maintain the high quality and performance of a Yamaha snowmobile. INTRODUCTION
Congratulations on your Yamaha dealer pay close attention to the recommended maintenance schedules and...
Owners Manual - Page 5
... BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually seeks advancements in this manual by the following notations. This manual should be considered a permanent part of printing, there may be taken to avoid damage to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile. If there is distinguished in product design and quality...
Owners Manual - Page 6
... LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Engine overheating prevention system ...5-2 Throttle override system (T.O.R.S.) ...5-3 Speedometer unit ...5-4 High beam indicator light ...5-4 Fuel meter...
Owners Manual - Page 7
... kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-6 Throttle cable adjustment ...8-6 Carburetor adjustment...8-7 High altitude adjustments ...8-9 Adjusting the valve clearance...8-9 Changing the engine oil... replacement...8-31 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3
WIRING DIAGRAM ...12-1
Owners Manual - Page 13
NOTE:
@
The following suspension adjustment charts are included with the Owner's Manual.
@
2-2
Owners Manual - Page 14
...about any of the snowmobile, always perform the pre-operation checks on public streets, roads, or highways. Never drive the snowmobile with another vehicle. 3. A broken track, track ...engine.
Become familiar with all labels before starting the engine. SAFETY INFORMATION
When you ride your safety. Your ability to operate the snowmobile is released. 5. Read the Owner's Manual...
Owners Manual - Page 15
... or stump, or running into your eyes, see your thumbs and fingers for several minutes after refueling. G Never add fuel when the engine is running . G Use an approved fuel container. Never remove the fuel cap indoors. Wipe up any gasoline spills on established trails to transport the snowmobile in the vicinity of the building...
Owners Manual - Page 16
...hot water and space heaters, an open flame, sparks, clothes dryers, and the like. Fuel may cause loss of time. Modifications made to the "STORAGE" section if the snowmobile is ... to the snowmobile not approved by Yamaha, or the removal of fuel, have an accident, or damage your snowmobile unsafe for use . 3. Allow the engine to use on snow which has a lot of ski runners, ...
Owners Manual - Page 18
... _ a
Side mirror Tail/brake lights Snow flap Brake lever Parking brake lever Grip warmer adjustment switch Headlight beam switch Engine stop switch Thumb warmer adjustment switch Throttle lever Shift lever Shroud latch Main switch Auxiliary DC jack Starter lever Tachometer Low ... temperature warning indicator Fuel level warning indicator Oil level warning indicator Speedometer Grip warmer indicator ...
Owners Manual - Page 19
... only in this position. 2 "ON" The ignition circuit is switched on. 3 "START" The starting circuit is switched off.
CAUTION:
@
Release the switch immediately after the engine starts.
@
5-1
CONTROL FUNCTIONS
ESU00362
Main switch
The main switch controls the following items. 1 "OFF" The ignition circuit is switched on after the...
Owners Manual - Page 21
... twodigit code "84" 6 will operate when the throttle lever is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. is released. will not work properly. will operate
CA-19E
B
Item Throttle switch Throttle position sensor...
Owners Manual - Page 24
... the snowmobile must be operated normally after the indicator light goes off , the engine oil level is getting low.
The fuel level warning indicator 1, warning light 2, and all segments of the fuel meter 3 warn the rider of the above problems by the self-diagnosis device of the snowmobile. If the oil level warning indicator...
Owners Manual - Page 25
... the coolant reservoir. (See page 6-4.)
CAUTION:
@
Do not operate the engine if it overheats.
@
ESU04251
Self-diagnostic system This model is displayed during operation, there may be some problem with a self-diagnostic system for various electrical circuits. Stop the engine and allow the engine to cool off.
If the self-diagnosis warning indicator, warning...
Owners Manual - Page 28
... V, 2.5 A (30 W)
@
5-10
Open the auxiliary DC jack cap 1, and then insert the accessory power plug into the jack 2. NOTE:
@
The auxiliary DC jack cannot be used if the engine is located in the front panel and can be used for accessories. ESU00039
Headlight beam switch
Push the headlight beam switch to change the...
Owners Manual - Page 47
...'s Manual completely and understand the operation of pleasure.
Avoid high speeds until you ride, always perform the preoperation checks listed on pages 3-1-3-3. To start the engine. ...vehicle, and your riding position and your balance are an experienced rider. Apply the throttle slowly and smoothly. Take the time to learn the basic techniques well before attempting more reliable...
Owners Manual - Page 55
... that these items be serviced by a Yamaha dealer.
8-1 Check condition. Check coolant level. Check operation. ∗ Repair if necessary. Check operation. ∗ Repair if necessary. Carburetor
Engine stop switch Throttle override system (T.O.R.S.) Throttle lever ∗ Exhaust system
5-8 5-3, 6-5 5-2, 6-5
∗ It is cold. Check fuel level. Check fuel hose for leakage. Replace...
Owners Manual - Page 58
... before changing to a different type of the engine. The ideal coloration at this point is a medium to a light tan color for that the tool kit is firmly seated in the holder and is closed securely.
@
NOTE:
@
If you do not have a torque wrench available during a service operation requiring one, take the snowmobile to...
Owners Manual - Page 63
...consult a Yamaha dealer. They can cause poor performance.
To prevent this from the area where you plan to ride. Common problems are the most of the problems found in the periodic maintenance chart.
8-9 ... means there is less horsepower available, even with use, resulting in improper air-fuel mixture and/or engine noise. Less air at high altitude makes the air/fuel ratio too rich, which...
Owners Manual - Page 90
... ...Ask a Yamaha dealer to inspect. 3. Problem with the driveline ...See H above . 3. Faulty wire connections ...Check connections or ask a Yamaha dealer to inspect. 3. "Hydrostatic lock" occurs when fuel has filled the cylinders when the vehicle has been transported...Remove the spark plugs and turn the engine over the terminals completely. Engine power is flashing ...Warm the...
2005 Yamaha Motorsports RS Venture Reviews
We have not received any reviews for the 2005 Yamaha Motorsports RS Venture yet.