2004 Yamaha Motorsports Mountain Max 700 Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2004 Yamaha Motorsports Mountain Max 700 manuals!
Problems with 2004 Yamaha Motorsports Mountain Max 700?
Ask a Question
Other Models
Free 2004 Yamaha Motorsports Mountain Max 700 manuals!
Problems with 2004 Yamaha Motorsports Mountain Max 700?
Ask a Question
Other Models
Popular 2004 Yamaha Motorsports Mountain Max 700 Manual Pages
Owners Manual - Page 1
SNOWMOBILE
OWNER'S MANUAL
SXV70ERJ SXV70MJ SXV70SJ VT70J
LIT-12628-02-31
8EK-28199-12
Owners Manual - Page 3
... ordering spare parts from a Yamaha dealer. 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record and keep the ID numbers in a separate...
Owners Manual - Page 4
To maintain the high quality and performance of this snowmobile, it is expressly prohibited. is important that have any questions concerning the operation or maintenance of this manual. Any reprinting or unauthorized use without the written permission of craftsmanship and reliability that you and your Yamaha dealer pay close attention to the recommended maintenance...
Owners Manual - Page 5
... ATTENTION! YOUR SAFETY IS INVOLVED!
WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually ...information to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile.
Therefore, while this manual contains the most current product information available at the time of this snowmobile ...
Owners Manual - Page 6
... WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-5 Fuel meter and grip/thumb warmer heat level indicator...5-5 Fuel...
Owners Manual - Page 14
...Manual and all of the operating controls and their function. Such use is released. 6. Apply the parking brake before operating this snowmobile. Severe injury or death may overheat the brake disc and reduce braking ability.
3-1 Become familiar with all labels before starting the engine...snowmobile, always perform the pre...drive the snowmobile with another vehicle. 3. Check the throttle,...
Owners Manual - Page 21
... the T.O.R.S. will operate
CA-01E
Mode A Idle or Switch starting Throttle switch Off Carburetor switch On B Engine È É Ê 1 2 3 4 a b Idle or starting Run Trouble Carburetor switch ... sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. B Run On Off Run C Trouble Off Off T.O.R.S. Be sure to...
Owners Manual - Page 22
...miles, select the odometer mode "ODO", and then push the select/reset button 5 for 5 seconds, then switches to zero) G warning indicators (which show self-diagnosis, coolant temperature, fuel... 3 turn on and off if there are no problems. The grip warmer heat level is initially displayed for...the grip warmer or the thumb warmer) After the engine is started, the tachometer 1 makes one second while ...
Owners Manual - Page 24
...maximum level. The fuel level warning indicator 1, warning light 2, and all segments of the fuel meter 3 warn the rider of the above problems by the self-diagnosis device of the fuel meter flash pattern
...the display switches to the levels saved when the engine was stopped.
@
ESU00287
Fuel level warning indicator
The fuel level warning indicator indicates a malfunctioning sensor, disconnected ...
Owners Manual - Page 25
... light flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead..., or short circuit when detected by the self-diagnosis device of the above problems by flashing continuously. (See the table below the minimum level, the oil...
Owners Manual - Page 26
... sensor, disconnected coupler, broken lead, etc., when detected by the self-diagnosis device of the above problems by flashing continuously. If necessary, ask a Yamaha dealer for further details. (See page 5-9 for ... may be some problem with the electrical circuit, lead couplers, etc. (See page 5-9 for warning indicator and warning light flash pattern numbers 1-8.) Stop the engine and allow it ...
Owners Manual - Page 37
... oil tank cap look similar, be used temporarily in an emergency.
6-2 Make sure that there is not available. ESU00299
Engine oil
Make sure that snow or ice does not enter the fuel tank when refueling. Do not use boiled or distilled water, if soft water is sufficient oil in the coolant reservoir...
Owners Manual - Page 45
...position.
@
1. ESU00112
7- Put the starter lever (choke) in the half-open (warm engine up the engine until it is engaged, then pull it does not run roughly or begin to stall when...(cold engine starting the engine. NOTE:
@
Make sure that the parking brake is returned to the closed position.
@
Manual starting )
NOTE:
@
The starter lever (choke) is not required when the engine is ...
Owners Manual - Page 46
... system should be as short as follows.
Proceed with the "Starting the engine" section items 1 and 2 for the "Manual starting model For SXV70ER/VT70 2. Each attempt should fail, take the emergency starter rope and the screwdriver handle out of the tool kit and proceed as possible to start, release the switch, wait a few...
Owners Manual - Page 47
.... 7. WARNING
@
Do not wind the emergency starter rope around your hand.
@
6. Install the drive guard and shroud.
After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model For SXV70ER/VT70 Follow the procedures in the half-open position. WARNING
@
Avoid contact with the edge of...
Owners Manual - Page 49
... snowmobile is a rider active vehicle, and your riding position and ...the drive track to learn the basic techniques well before attempting more reliable snowmobile. Take the time to lose traction, reduce control, and.... To start the engine. Never put your snowmobile
Before you ride, always perform the preoperation checks listed on your snowmobile at maximum performance until you are
@...
Owners Manual - Page 61
... could indicate an intake track air leak or carburetion problem for most periodic maintenance and minor repair. For example, a very white center electrode porcelain color could be something wrong with the holding band.
@
NOTE:
@
If you do not have a torque wrench available during a service operation requiring one, take the snowmobile to a different type...
Owners Manual - Page 67
...dealer. Consult a Yamaha dealer.
@
8-10 Common problems are any changes necessary for the altitude where you ...horsepower available, even with less power at high altitude reduces the performance of a gasoline engine to about 3% for combustion. Less air means less oxygen available for every 305 m (1,000 ft) of elevation. Proper carburetion adjustments will correct the air/fuel...
Owners Manual - Page 91
"Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the correct V-belt. 2. Engine power is caught in cooling system ...Bleed air or ask a Yamaha dealer to expel excess fuel. Drive track does not move 1. Problem with the driveline ...See H above...
Owners Manual - Page 95
ESU00228
1-
SPECIFICATIONS
SXV70ER/SXV70M/SXV70S/VT70 2,780 mm (109.4 in): SXV70ER/SXV70S 3,090 mm (121.7 in): SXV70M ...Engine oil type Carburetor type Fuel
SXV70ER/SXV70M/SXV70S/VT70 Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 696 cm3 69.0 × 62.0 mm (2.72 × 2.44 in) 1,800 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM33 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual...
2004 Yamaha Motorsports Mountain Max 700 Reviews
We have not received any reviews for the 2004 Yamaha Motorsports Mountain Max 700 yet.