2003 Yamaha Motorsports V Star 650 Custom Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2003 Yamaha Motorsports V Star 650 Custom manuals!
Problems with 2003 Yamaha Motorsports V Star 650 Custom?
Ask a Question
Other Models
Free 2003 Yamaha Motorsports V Star 650 Custom manuals!
Problems with 2003 Yamaha Motorsports V Star 650 Custom?
Ask a Question
Other Models
Popular 2003 Yamaha Motorsports V Star 650 Custom Manual Pages
Owners Manual - Page 11
... to an impairment of an accident, use of a safety helmet is changed.
Use extra care when riding a motorcycle that covers your motorcycle.
Never touch the engine or exhaust system during or after operation. The use extreme caution when adding cargo or accessories to your motorcycle can cause burns.
Owners Manual - Page 13
... passing or being passed by large vehicles. This improper position limits the freedom of movement of the operator and may seriously affect the stability of time in the vicinity of lights or engine power.
1
Gasoline and exhaust gas
1. Bulky or large accessories may limit control ability, therefore, such accessories are added to the handlebar or...
Owners Manual - Page 14
... and that the fuel cock is turned to touch these hot areas. When transporting the motorcycle in a place where pedestrians or children are not likely to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). The engine and exhaust system may be hot, therefore, park the motorcycle in another vehicle, make sure that...
Owners Manual - Page 26
... comes on when the transmission is defective.
EAU00057
Turn signal indicator light " " This indicator light flashes when the turn signal switch is switched on. The tripmeter can be used to estimate the distance that can be traveled with a full tank of the headlight is pushed to plan future fuel stops. NOTE: This...
Owners Manual - Page 27
..." To signal a right-hand turn signal lights will self-cancel after it has returned to starting the engine.
Engine stop switch " 2. EC000005
CAUTION: See page 5-1 for approximately 15 seconds. However, the turn signal...hand turn, push this switch to crank the engine with a self-canceling system, the turn signal lights can also be canceled manually by pushing the switch in case of an ...
Owners Manual - Page 28
... located on the left side of the engine and is used in combination with the clutch lever when shifting the gears of the 5-speed constant-mesh transmission equipped on this motorcycle.
NOTE: Use.... Shift pedal
EAU01215
Clutch lever
The clutch lever is located at the left side of the engine and is located on this motorcycle. To engage the clutch, release the lever. Shift pedal ...
Owners Manual - Page 31
... a gasoline of a different brand or premium unleaded fuel. Fill the fuel tank to the fuel system or vehicle performance problems.
_
WARNING G Do not overfill the fuel tank, otherwise it can be used if the ethanol content does not exceed 10%. Use of unleaded fuel will cause severe damage to internal engine parts, such as the valves and piston rings...
Owners Manual - Page 40
...operation of raising the sidestand before riding.
_ _
3-16 G It cuts the running engine when the transmission is in gear and the sidestand is not pulled.
EW000045
3
WARNING If a malfunction is still down...moved up (or does not stay up , but the sidestand is noted, have a Yamaha dealer repair it if it does not function properly.
@ @
Ignition circuit cut-off system
The ignition circuit ...
Owners Manual - Page 41
... start ?
NOTE: This check is OK. Keep the clutch lever pulled. 12. The system is most reliable if performed with a warmed-up . 11. YES
After the engine has stalled: 10. INSTRUMENT AND CONTROL FUNCTIONS
CD-01E
With the engine turned off: 1. Move the sidestand down . ". Move the sidestand up. 7. Keep the clutch lever pulled...
Owners Manual - Page 46
...and death within a short time.
G The transmission is adequate ventilation. Always make sure that the sidestand is up a cold engine
In order for any control or function that ... starting , one of the following conditions must be blocked and performance will suffer.
Starting and warming up . 5- G Never start the engine or operate it could contact the ground and distract the operator,...
Owners Manual - Page 47
... check the self-diagnosis system.
_
1. Start the engine by pushing the start switch, wait a few seconds. NOTE: When the transmission is in the neutral position, the neutral indicator light ...engine trouble warning light should come on when the key is turned to "ON", and then go off after starting, immediately stop switch is cold!
_ _
7. Turn the fuel cock lever to "ON". 2. If the engine...
Owners Manual - Page 48
... with the starter (choke) in the illustration. XVS650
1. OPERATION AND IMPORTANT RIDING POINTS
NOTE: The engine is warm. Temperatures above 10 °C (50 °F) require about 2.5 minutes with the starter ...that the starter (choke) is not required when the engine is warm when it .
@ @
5-3
NOTE: To shift the transmission into the neutral position, press the shift pedal down...
Owners Manual - Page 49
... part way and gradually release the clutch lever. 7. The transmission is properly lubricated only when the engine is running. Shift the transmission into the neutral position.) 6. OPERATION AND IMPORTANT RIDING POINTS
XVS650A
G
Always use the clutch while changing gears to avoid damaging the engine, transmission, and drive train, which are not designed to the next...
Owners Manual - Page 50
... must be avoided. OPERATION AND IMPORTANT RIDING POINTS
EAU00427 EAU02974 EAU01128
5
To decelerate 1. Shift the transmission into first gear when the motorcycle reaches 25 km/h (15.5 mi/h). If the engine is almost completely stopped. Since the engine is never a more important period in and use the brakes to stop the motorcycle. 3. Acceleration shift...
Owners Manual - Page 52
... spark plugs ...6-9 Canister (for California only) ...6-11 Engine oil and oil filter element ...6-11 Final gear oil ...6-14 Cleaning the air filter element ...6-15 Adjusting the carburetors ...6-16 Adjusting the throttle cable free play ...6-17 Adjusting the valve clearance ...6-17 Tires ...6-17 Spoke wheels ...6-19 Accessories and replacement parts ...6-20 Adjusting the clutch...
Owners Manual - Page 53
... minor repairs. THESE CONTROLS NOT ONLY FUNCTION TO ENSURE CLEANER AIR, BUT ARE ALSO VITAL TO PROPER ENGINE OPERATION AND MAXIMUM PERFORMANCE. EW000060
WARNING If you are not familiar with motorcycle maintenance work correctly. THESE SERVICES REQUIRE SPECIALIZED DATA, KNOWLEDGE, AND EQUIPMENT.
Periodic inspection, adjustment and lubrication will keep your vehicle in the owner's tool kit...
Owners Manual - Page 55
...ventilation hose for cracks or damage. • Replace if necessary. • Check fuel hoses for cracks or damage. • Replace if necessary. • Replace. &#... engine idle speed. • Adjust cable free play. • Check control system for the emission control system
INITIAL No. PERIODIC MAINTENANCE AND MINOR REPAIR
...technical skills, have a Yamaha dealer perform the service. 6-3
Owners Manual - Page 58
...REPAIR
INITIAL No. G Engine oil type • Yamalube 4 (20W-40) or engine oil SAE 20W-40 (API SE) for temperatures of 5 °C (40 °F) or above. • Yamalube 4 (10W-30) or engine...these items require special tools, data and technical skills, have a Yamaha dealer perform the service. #1 Yamaha Chain and Cable Lube or engine oil SAE 10W-30 (API SE) #2 Molybdenum disulfide grease #3 Lithium-...
Owners Manual - Page 62
... AND MINOR REPAIR
NOTE: If...its mating surface, and then wipe off any spark plug shows a distinctly different color, the engine could be tightened to the specified torque.
6-10
4. Instead, have a Yamaha dealer check ... a wire thickness gauge and, if necessary, adjust the gap to diagnose such problems yourself. However, the spark plug should be defective. Install the spark plug cap...
Owners Manual - Page 70
...performance and safety. Tire sidewall 2. Tire wear indicator a. Tire tread depth
Tire inspection Always check the tires before operating the motorcycle. maximum
CE-07E
Maximum load*
* Total weight of rider, passenger, cargo and accessories... pressure of the motorcycle. PERIODIC MAINTENANCE AND MINOR REPAIR
XVS650
Tire air pressure (measured on cold tires) Load* Up to 90 kg (198 lb)...
2003 Yamaha Motorsports V Star 650 Custom Reviews
We have not received any reviews for the 2003 Yamaha Motorsports V Star 650 Custom yet.