2010 Polaris Outlaw 50 Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2010 Polaris Outlaw 50 manuals!
Problems with 2010 Polaris Outlaw 50?
Ask a Question
Other Models
Free 2010 Polaris Outlaw 50 manuals!
Problems with 2010 Polaris Outlaw 50?
Ask a Question
Other Models
Popular 2010 Polaris Outlaw 50 Manual Pages
Owners Manual - Page 2
A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm.
If you cannot locate this product contains chemicals known to the State of California to the owner's manual on the next page. WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800-342-3764 for assistance.
Owners Manual - Page 10
...8226; Read this manual can be hazardous ... and Y-6 Keep this manual and all • Always...manual with the ATV. 50cc models are designed for your safety warnings, precautions and operating vehicle. Take a training course. This vehicle... handles differently than 12 years of age. A Polaris ATV is not a toy and can result in this owner's manual...
Owners Manual - Page 27
... gradually (right lever). Never apply the rear brake while rolling backwards. Turn the ATV around and remount, following the procedure described in the Owner's Manual. Never apply engine power. Apply the front brake slowly. When fully stopped, apply rear brake as well (left lever) and then lock the parking brake. If the...
Owners Manual - Page 30
... information. Avoid operating over obstacles could cause loss of control or an accident. All parts and accessories added to the vehicle must be installed and used according to reduce the chance of control or overturn (if tires regain traction unexpectedly). or equivalent components designed for use extreme caution and always follow proper operating...
Owners Manual - Page 51
... check to your ATV.
Children must read the instructions and warnings on page 15 of this manual. This must always be done by squeezing them toward the
handlebar and then letting go back slowly... never add their
own gasoline. Never start the engine if your Polaris dealer fix the sticky brakes before you can ride your ATV needs more gas. Check the brake levers by an adult. Have...
Owners Manual - Page 63
... can result in an accident if the throttle lever sticks during operation.
60 Always check the lever for service if throttle problems arise. Always contact your dealer for free movement and return before starting the engine. Failure to severe injury or death. Also check occasionally during operation. Features and Controls
Throttle Controls
WARNING...
Owners Manual - Page 73
... is defined as following procedures carefully. Perform the following the procedures for extended periods during the first three hours of operation will result in period for the engine. Do not operate at full throttle or high speeds for a proper break-in the safety section of this owner's manual. Operation
WARNING
Failure to use...
Owners Manual - Page 74
...Engine oil change See your dealer for inspection and adjustment
71 Perform regular checks on fluid levels, controls and areas outlined on the daily pre-ride inspection checklist. Drive slowly at sustained idle. 5. Perform break-in oil change Clean filter with oil change Perform... change Oil pre-filter screen Transmission oil Valve clearance
4.
Perform the following maintenance at the ...
Owners Manual - Page 77
... the maximum weight capacity of the operator, accessories, loads on the racks (if equipped) and the load on any public street, road or highway, including dirt and gravel roads. 6. Operation
Safe Operation Practices
1. Engine exhaust fumes are adding to operate this vehicle. Never start the engine or let it run in an enclosed area...
Owners Manual - Page 89
Dismount on the uphill side of the vehicle, or on a Hill
If the vehicle stalls while climbing a hill, never back it down the hill! Stop the vehicle and lock the parking brake while keeping body weight uphill. 2. Shut off the engine. 3. Operation
Turning Around on the left if the vehicle is pointing straight uphill.
86 Use the K-turn to turn around. 1.
Owners Manual - Page 102
... Drain and change the oil Clean filter at every oil change Transmission oil Oil pre-filter screen General lubrication Valve clearance Carburetor float ... 50 50 50 50 50 Calendar Monthly 6M 12 M 12 M 3M 3M 6M 6M 6M Miles (Km) 200 (320) 300 (480) 400 (640) 400 (640) 500 (800) ...
Battery X X X X QE Engine oil change ; adjust; lubricate; replace if necessary
See Page 144 106 110 107 ------
99 ...
Owners Manual - Page 103
... Polaris dealer perform these procedures more often for leaks at tank cap, lines, fuel valve, filter, pump, carburetor; replace lines every two years Change filter Inspect Inspect Inspect
See Page ----109 ---- Maintenance
Periodic Maintenance Chart
Item
E Q XQ QE QE X Q Carburetor air intake ducts/flange Drive belt Brake pad wear Fuel system Fuel filter Engine mounts Exhaust...
Owners Manual - Page 105
.... grease (also after washing ATV or driving in water).
(A-Arm)
XPerform these procedures more often for vehicles subjected to NLGI No. 2
Method See page 104. See page 133. Maintenance
Lubrication Guide
Item Engine Oil Gearcase (Transmission) Oil Level Drive Chain
X Front Suspension
Lube Polaris Synthetic Youth Oil or Synthetic SAE 40 Premium AGL...
Owners Manual - Page 109
Allow it to idle for two to skin.
CAUTION! Hot oil can cause burns to three minutes. Do not allow hot oil to contact skin.
106 Maintenance
Engine Oil Change
1. 2. 3. 4. Start the engine. Stop the engine. Position the vehicle on a level surface. Clean the area around the pre-filter plug.
Owners Manual - Page 118
... the transmission, follow the procedure on . 10. If necessary, repeat the drying procedure. 11. Tighten the carburetor drain screw. 9. Turn the fuel valve on page 117 for service as soon as possible, whether you succeed in starting it with a new plug. 8. Attempt to your dealer for drying the CVT. Maintenance
Vehicle Immersion
5. Turn the engine...
Owners Manual - Page 119
...precision balanced. Maintenance
Constant Variable Transmission (CVT) System
WARNING
Failure to make sure the CVT housing is intended for use on components. Extensive engineering and testing has been conducted... to be out of force on clutch components. However, as outlined in the owner's manual. • This CVT...
Owners Manual - Page 168
..., clean and/or replace spark plugs Inspect, clean and/or replace spark plugs See your Polaris dealer Set gap to specs or replace plugs Check all connections and tighten Recharge battery with .5 amp charger Replace with recommended fuel Inspect and clean or replace See your Polaris dealer See your Polaris dealer
165
Owners Manual - Page 177
...to repair Polaris ATVs. Please work with Polaris recommendations.
174 This warranty gives you specific legal rights, and you may also have other warranty terms will contact the appropriate personnel at least 1000 hours when subjected to normal use your original selling dealer; Recommended Lubricants 1. We recommend the use any Polaris Servicing Dealer to perform warranty service. Mixing...
Owners Manual - Page 183
...service that has been structurally altered, or when the vehicle has been used in material or workmanship.This limited warranty does not cover damage due to perform any questions regarding your vehicle...accidents for your vehicle. Any qualified repair shop or person may deny warranty claims for performing the scheduled maintenance identified in the owner's manual. Owners are responsible...
Owners Manual - Page 184
Maintenance Log
Present this section of maintenance and services performed. DATE SERVICE INTERVAL TECHNICIAN SERVICE PERFORMED / COMMENTS
10 Hours (Break-in)
40 Hours
50 Hours
80 Hours
181
This will provide you and future owners with an accurate log of your manual to your dealer each time your vehicle is serviced.
2010 Polaris Outlaw 50 Reviews
We have not received any reviews for the 2010 Polaris Outlaw 50 yet.