2006 Polaris Sportsman 700 EFI Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2006 Polaris Sportsman 700 EFI manuals!
Problems with 2006 Polaris Sportsman 700 EFI?
Ask a Question
Other Models
Free 2006 Polaris Sportsman 700 EFI manuals!
Problems with 2006 Polaris Sportsman 700 EFI?
Ask a Question
Other Models
Popular 2006 Polaris Sportsman 700 EFI Manual Pages
Owners Manual - Page 3
If you cannot locate this product contains chemicals known to the owner's manual on the next page. WARNING
The engine exhaust from this card, or if it has been removed, please call 1-800-342-3764 for assistance. A card containing important ATV safety information should be attached to cause cancer, birth defects or other reproductive harm.
Owners Manual - Page 4
... into the engineering, design, and development of Polaris owners. We also take great pride in your vehicle, be performed only by a Factory Certified Master Service Dealer (MSD) Technician. Be sure to return to your service needs during, and after, the warranty period. Your Polaris dealer knows your vehicle best and is outlined in the Polaris Service Manual and should...
Owners Manual - Page 10
... Owner's Manual for braking when carrying cargo. Be careful if load extends over the side of control resulting in dusty conditions. Reduce speed and allow greater distance for more frequent cleaning required in SEVERE INJURY OR DEATH. TIRE PRESSURE IN PSI (KPa): FRONT 5 (34,5) REAR 5 (34,5) MAXIMUM WEIGHT CAPACITY (Gross Vehicle Weight) INCLUDING...
Owners Manual - Page 14
... of vehicle safety. We strongly advise you are thoroughly inspected at specific intervals.
11
Safety Training
When you can request this manual can be hazardous to operate. This vehicle handles ... vehicles, such as motorcycles and cars. A Polaris ATV is designed to ensure that all warnings before operating a Polaris ATV. You should review this vehicle in your owner's manual ...
Owners Manual - Page 18
... at sharp angles. The warranty on your Polaris ATV is terminated if any equipment has been added to the vehicle, or if any other ...manual for your ATV, and always maintain proper tire pressure. S Never exceed the stated load capacity for carrying cargo or towing. Therefore, we strongly recommend that consumers do not install on the vehicle.
15 Use only Polaris-approved accessories...
Owners Manual - Page 29
WHAT CAN HAPPEN The vehicle could overturn. Never apply the rear brake while rolling backwards. HOW TO AVOID THE HAZARD Maintain steady speed when climbing a hill. If all forward speed is pointed straight uphill. Never apply engine power. When fully stopped, apply the rear ... Keep your weight uphill. Turn the ATV around and remount, following the procedure described in the owner's manual.
Owners Manual - Page 32
... with improper or uneven tire pressure, could lead to the vehicle must be installed and used according to approved instructions.
WHAT CAN HAPPEN Use of improper tires, or operation of control or accident. WHAT CAN HAPPEN Improper installation of accessories or modification of the ATV may cause changes in the owner's manual and on this...
Owners Manual - Page 36
... service if throttle problems arise...perform as designed, which is 1 released. Never start or operate an ATV with Polaris Electronic Throttle Control (ETC), which could cause an accident and lead to severe injury or death. Always contact your dealer for free movement and return before starting the engine.... Do not attempt to the ETC.
33 Throttle Lever
Engine speed and vehicle...
Owners Manual - Page 41
... the parking brake. FEATURES AND CONTROLS
Automatic Transmission Gear Selector
The transmission gear selector (1) is left unattended, always place the transmission in heavy pulling situations and when operating at less than seven miles per hour for extended periods of the vehicle. To change gears, stop the vehicle, and with the engine speed above idle or while the...
Owners Manual - Page 44
.... 8. This indicator serves two purposes. Odometer/Tachometer/Tripmeter/ Hour Meter 7. All segments will flash, FUEL will display in the instrument cluster. Check Engine Warning Indicator - Serious engine damage could result. 9. Service Interval/Diagnostic Mode Indicator 5. AWD Indicator - NOTE: If the instrument cluster fails to illuminate, a battery over-voltage may have occurred...
Owners Manual - Page 48
... off and turn the engine off and on . The number "61" and the word "END" will display, one at a time, in less than five seconds, then leave the switch on three times in the alphanumeric display. To download blink codes (failure codes) from the EFI module: 1. Place the transmission in PARK, turn...
Owners Manual - Page 61
... brake and proceed slowly, controlling speed with the transmission still in forward and shut off the engine. 3. Restart the engine with the service brake, until it down the hill! Leave the transmission in forward. 8. Use the K-turn around.
8' (2.4 m)
1. OPERATION
Driving Safely
Turning Around on a Hill
If the vehicle stalls while climbing a hill, never back it 's pointing...
Owners Manual - Page 62
... following areas need special attention: engine oil, transmission oil, front and rear gearcases, and all grease fittings. If your vehicle becomes immersed, and it's impossible to take it serviced as outlined in water. Determine water depths and current before starting it, follow the steps described on page 90. Perform the services outlined in water that exceeds...
Owners Manual - Page 69
... Maintenance Chart
Item
Perform all services at whichever maintenance interval is reached first.
(whichever comes first) Hours Calendar Miles (Km) 10 ...yearly Inspect level; Tires
" Brake fluid level " Brake lever travel
Brake system Wheels/fasteners Frame fasteners
" Engine oil level " ...Transmission oil " Engine breather
E filter (if equipped)
66 change coolant every 2 years Check operation; ...
Owners Manual - Page 85
... LUBRICATION WARNING
Operating your ATV with worn tires, improperly inflated tires, non-standard tires or improperly installed tires will affect vehicle handling and could cause an accident resulting in the owner's manual. Tire Tread Depth
Always replace tires when tread depth is worn to 1/8″ (.3 cm) or less. All service must be performed by placing a suitable stand under the footrest...
Owners Manual - Page 93
..., follow the procedure on page 93 for service as soon as possible, whether you succeed in starting it or not. Take the vehicle to your dealer for drying out the PVT.
90 Turn the engine over several times using the electric start the engine. MAINTENANCE AND LUBRICATION
Vehicle Immersion
CAUTION
If your ATV to a dealer...
Owners Manual - Page 96
... force on components. Replace the drain plug. 2. Apply varying throttle for service as soon as outlined in severe injury or death. Test for more than...manual. Doing so may reduce its strength so that a failure may be out of this system remains safe: Always follow all recommended maintenance procedures. Allow the engine RPM to settle to idle speed, then shift the transmission...
Owners Manual - Page 106
...the transmission to engage clutch. Check for one mile (5 miles ...vehicle overturn. Always break in gas tank or fuel lines. Use low range only. Always use low range or dismount the ATV (after first applying the park brake) and perform...service if you're unable to about 1/8 throttle in mud or snow Use the throttle quickly and effectively. TROUBLESHOOTING
Drive Belt and Cover Problems...
Owners Manual - Page 109
... Electronic throttle control malfunction Other mechanical failure Overheated engine
Solution
Refuel, cycle key to ON position three times for 5 seconds each, then start Inspect and replace Replace with new fuel Inspect, clean and/or replace spark plugs See your Polaris dealer Set gap to specs or replace plugs Check all connections and tighten...
Owners Manual - Page 117
... repair Polaris ATVs. We recommend the use your ATV. 2. SPARK ARRESTOR
Polaris warrants that you may not be covered by warranty. Some states do not allow limitations on how long an implied warranty lasts, so the above terms are in this vehicle will contact the appropriate person at least 1000 hours when subjected to perform warranty service...
2006 Polaris Sportsman 700 EFI Reviews
We have not received any reviews for the 2006 Polaris Sportsman 700 EFI yet.