Owners Manual
Page 6
... installing panels ...7-8 Checking the spark plugs ...7-11 Canister ...7-12 Engine oil and oil filter cartridge ...7-12 Chain drive oil ...7-15 Coolant ...7-17 Replacing the air filter element ...7-18 Checking the engine idling speed ...7-19 Checking the throttle cable free play ...7-19 Valve clearance ...7-19 Tires ...7-20 Cast wheels ...7-21 Front and rear brake lever free play ...7-22 Adjusting the rear brake lock lever cable ...7-22 Checking the front and rear brake pads ...7-23 Checking the brake fluid level ...7-24 Changing the brake fluid ...7-25...
... installing panels ...7-8 Checking the spark plugs ...7-11 Canister ...7-12 Engine oil and oil filter cartridge ...7-12 Chain drive oil ...7-15 Coolant ...7-17 Replacing the air filter element ...7-18 Checking the engine idling speed ...7-19 Checking the throttle cable free play ...7-19 Valve clearance ...7-19 Tires ...7-20 Cast wheels ...7-21 Front and rear brake lever free play ...7-22 Adjusting the rear brake lock lever cable ...7-22 Checking the front and rear brake pads ...7-23 Checking the brake fluid level ...7-24 Changing the brake fluid ...7-25...
Owners Manual
Page 14
... with the information about accessories below, are some aftermarket accessories or modifications are not suitable because of accessories not sold by Yamaha or modifications not specifically recommended by Yamaha, even if sold and installed by Yamaha for your load (suspension-adjustable models only), and check the condition and pressure of your tires. To avoid the possibility of an overloaded vehicle could cause an accident...
... with the information about accessories below, are some aftermarket accessories or modifications are not suitable because of accessories not sold by Yamaha or modifications not specifically recommended by Yamaha, even if sold and installed by Yamaha for your load (suspension-adjustable models only), and check the condition and pressure of your tires. To avoid the possibility of an overloaded vehicle could cause an accident...
Owners Manual
Page 15
... carry cargo that would impair the performance of your vehicle that change any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. These accessories may limit control ability, therefore, such accessories are not recommended. G Aftermarket Tires and Rims The tires and rims that it to aerodynamic effects. SAFETY INFORMATION or others at greater risk of serious...
... carry cargo that would impair the performance of your vehicle that change any way reduce ground clearance or cornering clearance, limit suspension travel, steering travel or control operation, or obscure lights or reflectors. These accessories may limit control ability, therefore, such accessories are not recommended. G Aftermarket Tires and Rims The tires and rims that it to aerodynamic effects. SAFETY INFORMATION or others at greater risk of serious...
Owners Manual
Page 20
... light and position lights come on automatically when the engine is moved down. Otherwise the electrical systems will be removed. EAU10681 7 8 9 LOCK The steering is used to "LOCK" while still pushing it . To lock the steering 1. The key can be removed. EWA10061 The main switch/steering lock controls the ignition and lighting systems, and is locked, and all the way to "OFF" while still pushing it . 3. TIP The headlights...
... light and position lights come on automatically when the engine is moved down. Otherwise the electrical systems will be removed. EAU10681 7 8 9 LOCK The steering is used to "LOCK" while still pushing it . To lock the steering 1. The key can be removed. EWA10061 The main switch/steering lock controls the ignition and lighting systems, and is locked, and all the way to "OFF" while still pushing it . 3. TIP The headlights...
Owners Manual
Page 26
... electrical circuit. After changing the V-belt, reset the V-belt replacement indicator. INSTRUMENT AND CONTROL FUNCTIONS oil change indicator does not come on, have a Yamaha dealer check the electrical circuit. The electrical circuit of the indicator can be checked according to " ". 2. If the oil change indicator "OIL" flashes (i.e. Turn the key to "ON" and make sure that the oil change indicator comes on for the next periodic V-belt change to be replaced. V-belt replacement indicator "V-BELT...
... electrical circuit. After changing the V-belt, reset the V-belt replacement indicator. INSTRUMENT AND CONTROL FUNCTIONS oil change indicator does not come on, have a Yamaha dealer check the electrical circuit. The electrical circuit of the indicator can be checked according to " ". 2. If the oil change indicator "OIL" flashes (i.e. Turn the key to "ON" and make sure that the oil change indicator comes on for the next periodic V-belt change to be replaced. V-belt replacement indicator "V-BELT...
Owners Manual
Page 31
... of ignition such as the pilot lights of the filler tube. Wipe up , heat from the engine or the sun can cause injury or death. Fuel level WARNING Gasoline and gasoline vapors are extremely flammable. Never refuel while smoking, or while in the tank. Stop filling when the fuel reaches the bottom of water heaters and clothes dryers. 2. INSTRUMENT AND CONTROL FUNCTIONS...
... of ignition such as the pilot lights of the filler tube. Wipe up , heat from the engine or the sun can cause injury or death. Fuel level WARNING Gasoline and gasoline vapors are extremely flammable. Never refuel while smoking, or while in the tank. Stop filling when the fuel reaches the bottom of water heaters and clothes dryers. 2. INSTRUMENT AND CONTROL FUNCTIONS...
Owners Manual
Page 32
... Yamaha engine has been designed to the fuel system or vehicle performance problems. EAU13432 Catalytic converter This model is equipped with a pump octane number [(R+M)/2] of 91 or higher, or a research octane number of heat. ECA10701 NOTICE Use only unleaded gasoline. EAU46100 1 2 3 4 5 6 7 8 9 Recommended fuel: PREMIUM UNLEADED GASOLINE ONLY Fuel tank capacity: 15.0 L (3.96 US gal, 3.30 Imp.gal) ECA11400 leaded fuel will cause severe damage to the exhaust...
... Yamaha engine has been designed to the fuel system or vehicle performance problems. EAU13432 Catalytic converter This model is equipped with a pump octane number [(R+M)/2] of 91 or higher, or a research octane number of heat. ECA10701 NOTICE Use only unleaded gasoline. EAU46100 1 2 3 4 5 6 7 8 9 Recommended fuel: PREMIUM UNLEADED GASOLINE ONLY Fuel tank capacity: 15.0 L (3.96 US gal, 3.30 Imp.gal) ECA11400 leaded fuel will cause severe damage to the exhaust...
Owners Manual
Page 36
...the seat open for an extended period of time, otherwise the light may get wet while the scooter is not a storage compartment. Rear storage compartment 2. Do not exceed the maximum load of their size or shape. Do not keep anything susceptible to heat inside it. Do not leave the seat ...storage 2 1 1. INSTRUMENT AND CONTROL FUNCTIONS compartment may cause the battery to discharge.[ECA16081] NOTICE: The shaded area is being washed, wrap any items in this area.[ECA16091] G cause of 193 kg (425 lb) for the rear storage compartment. To prevent damaging the seat hinges, do not store...
...the seat open for an extended period of time, otherwise the light may get wet while the scooter is not a storage compartment. Rear storage compartment 2. Do not exceed the maximum load of their size or shape. Do not keep anything susceptible to heat inside it. Do not leave the seat ...storage 2 1 1. INSTRUMENT AND CONTROL FUNCTIONS compartment may cause the battery to discharge.[ECA16081] NOTICE: The shaded area is being washed, wrap any items in this area.[ECA16091] G cause of 193 kg (425 lb) for the rear storage compartment. To prevent damaging the seat hinges, do not store...
Owners Manual
Page 38
Periodically check the operation of the ignition circuit cut -off system according to the following functions. G It prevents starting when either brake is applied, but neither brake is still down . G It prevents starting when the sidestand is up, but the sidestand is applied. G It cuts the running engine when the sidestand is moved down . INSTRUMENT AND CONTROL FUNCTIONS EAU45051 Ignition circuit cut-off system 1 2 3 4 5 6 7 8 9 The ignition circuit cut -off system (comprising the sidestand switch and brake light switches) has the following procedure. 4-19
Periodically check the operation of the ignition circuit cut -off system according to the following functions. G It prevents starting when either brake is applied, but neither brake is still down . G It prevents starting when the sidestand is up, but the sidestand is applied. G It cuts the running engine when the sidestand is moved down . INSTRUMENT AND CONTROL FUNCTIONS EAU45051 Ignition circuit cut-off system 1 2 3 4 5 6 7 8 9 The ignition circuit cut -off system (comprising the sidestand switch and brake light switches) has the following procedure. 4-19
Owners Manual
Page 47
... perform these particular services. 2 3 4 5 6 7 8 9 WARNING Turn off the engine when performing maintenance unless otherwise specified. Maintenance, replacement, or repair of the emission control devices and systems may be cleaned or replaced more information about carbon monoxide. Yamaha dealers are not familiar with vehicle service, have a Yamaha dealer perform service. These services require specialized data, knowledge, and equipment. Running the engine while servicing can lead to death. possibly leading to eye injury, burns, fire...
... perform these particular services. 2 3 4 5 6 7 8 9 WARNING Turn off the engine when performing maintenance unless otherwise specified. Maintenance, replacement, or repair of the emission control devices and systems may be cleaned or replaced more information about carbon monoxide. Yamaha dealers are not familiar with vehicle service, have a Yamaha dealer perform service. These services require specialized data, knowledge, and equipment. Running the engine while servicing can lead to death. possibly leading to eye injury, burns, fire...
Owners Manual
Page 62
... clean, insert it into the oil filler hole, and then tighten the oil filler cap. Check the chain drive case for the cause. 7-16 Install the panel. 1 2 3 4 5 6 7 8 9 6. Minimum level mark 7. G Make sure that no oil gets on the tire or wheel. 10. Tightening torque: Chain drive oil drain bolt: 20 Nm (2.0 m·kgf, 14.5 ft·lbf) 11. PERIODIC MAINTENANCE AND ADJUSTMENT torque. Insert...
... clean, insert it into the oil filler hole, and then tighten the oil filler cap. Check the chain drive case for the cause. 7-16 Install the panel. 1 2 3 4 5 6 7 8 9 6. Minimum level mark 7. G Make sure that no oil gets on the tire or wheel. 10. Tightening torque: Chain drive oil drain bolt: 20 Nm (2.0 m·kgf, 14.5 ft·lbf) 11. PERIODIC MAINTENANCE AND ADJUSTMENT torque. Insert...
Owners Manual
Page 63
... cover 2. If the coolant is positioned straight up the right floorboard mat as possible, other- Do not use distilled water or soft tap water instead. Minimum level mark 3. PERIODIC MAINTENANCE AND ADJUSTMENT EAU20070 Coolant The coolant level should be between the minimum and maximum level marks. 1. Place the vehicle on a cold engine since it with engine temperature. Maximum level mark 2. Coolant level check window...
... cover 2. If the coolant is positioned straight up the right floorboard mat as possible, other- Do not use distilled water or soft tap water instead. Minimum level mark 3. PERIODIC MAINTENANCE AND ADJUSTMENT EAU20070 Coolant The coolant level should be between the minimum and maximum level marks. 1. Place the vehicle on a cold engine since it with engine temperature. Maximum level mark 2. Coolant level check window...
Owners Manual
Page 67
... ride. PERIODIC MAINTENANCE AND ADJUSTMENT with a worn-out tire. Brakes, tires, and related wheel parts replacement should be "broken in poor performance, adverse handling characteristics, and a shortened tire life. Do not attempt even the smallest repair to show crosswise lines, have a Yamaha dealer replace the tire immediately. Front tire: Size: 120/70R15 M/C 56H Manufacturer/model: DUNLOP/GPR-100F BRIDGESTONE/BT011F Rear tire: Size: 160/60R15 M/C 67H Manufacturer/model: DUNLOP/GPR...
... ride. PERIODIC MAINTENANCE AND ADJUSTMENT with a worn-out tire. Brakes, tires, and related wheel parts replacement should be "broken in poor performance, adverse handling characteristics, and a shortened tire life. Do not attempt even the smallest repair to show crosswise lines, have a Yamaha dealer replace the tire immediately. Front tire: Size: 120/70R15 M/C 56H Manufacturer/model: DUNLOP/GPR-100F BRIDGESTONE/BT011F Rear tire: Size: 160/60R15 M/C 67H Manufacturer/model: DUNLOP/GPR...
Owners Manual
Page 76
...Rubber cover If a fuse is blown, replace it as follows. 1. Turn the key to the electrical system and possibly a fire.[EWA15131] 7 8 7 7 2 1 1 2 3 4 5 6 1 4 5 1 2 6 7 8 9 1. Remove the blown fuse, and then install a new fuse of a higher amperage 1. Radiator fan fuse 5. Signaling system fuse 7. Fuse box 7-30 Ignition fuse 3. Fuel injection system fuse 6. Quick fastener 2. WARNING! Remove panel B. (See page 7-8.) 2. Backup fuse (for the individual circuits, are located under panel B. (See page 7-8.) 1. Spare fuse 8. Taillight fuse 1 1. Headlight fuse 2. Remove...
...Rubber cover If a fuse is blown, replace it as follows. 1. Turn the key to the electrical system and possibly a fire.[EWA15131] 7 8 7 7 2 1 1 2 3 4 5 6 1 4 5 1 2 6 7 8 9 1. Remove the blown fuse, and then install a new fuse of a higher amperage 1. Radiator fan fuse 5. Signaling system fuse 7. Fuse box 7-30 Ignition fuse 3. Fuel injection system fuse 6. Quick fastener 2. WARNING! Remove panel B. (See page 7-8.) 2. Backup fuse (for the individual circuits, are located under panel B. (See page 7-8.) 1. Spare fuse 8. Taillight fuse 1 1. Headlight fuse 2. Remove...
Owners Manual
Page 77
...Bulb cover 2 3 4 5 6 7 2. If the fuse immediately blows again, have a Yamaha dealer check the electrical system. Headlight coupler 2. PERIODIC MAINTENANCE AND ADJUSTMENT EAU23761 Specified fuses: Main fuse: 30.0 A Headlight fuse: 20.0 A Signaling system fuse: 15.0 A Ignition fuse: 10.0 A Taillight fuse: 10.0 A Radiator fan fuse: 15.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A Replacing the headlight bulb This model is equipped with alcohol or thinner. 2 1 1. Disconnect the headlight coupler, 7-31 1. If the headlight bulb burns out, replace it free from oil...
...Bulb cover 2 3 4 5 6 7 2. If the fuse immediately blows again, have a Yamaha dealer check the electrical system. Headlight coupler 2. PERIODIC MAINTENANCE AND ADJUSTMENT EAU23761 Specified fuses: Main fuse: 30.0 A Headlight fuse: 20.0 A Signaling system fuse: 15.0 A Ignition fuse: 10.0 A Taillight fuse: 10.0 A Radiator fan fuse: 15.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A Replacing the headlight bulb This model is equipped with alcohol or thinner. 2 1 1. Disconnect the headlight coupler, 7-31 1. If the headlight bulb burns out, replace it free from oil...
Owners Manual
Page 87
...: Throttle body: Manufacturer: MIKUNI Type/quantity: ACW31-3/1 Engine oil quantity: Without oil filter cartridge replacement: 2.80 L (2.96 US qt, 2.46 Imp.qt) With oil filter cartridge replacement: 2.90 L (3.07 US qt, 2.55 Imp.qt) Spark plug (s): Manufacturer/model: NGK/CR7E Spark plug gap: 0.7-0.8 mm (0.028-0.031 in) 2 3 4 5 6 7 8 9 Chain drive oil: Type: SAE 80 API GL-4 Hypoid gear oil Quantity: 0.70 L (0.74 US qt, 0.62 Imp.qt) Clutch: Clutch type: Wet, multiple-disc automatic Weight...
...: Throttle body: Manufacturer: MIKUNI Type/quantity: ACW31-3/1 Engine oil quantity: Without oil filter cartridge replacement: 2.80 L (2.96 US qt, 2.46 Imp.qt) With oil filter cartridge replacement: 2.90 L (3.07 US qt, 2.55 Imp.qt) Spark plug (s): Manufacturer/model: NGK/CR7E Spark plug gap: 0.7-0.8 mm (0.028-0.031 in) 2 3 4 5 6 7 8 9 Chain drive oil: Type: SAE 80 API GL-4 Hypoid gear oil Quantity: 0.70 L (0.74 US qt, 0.62 Imp.qt) Clutch: Clutch type: Wet, multiple-disc automatic Weight...
Owners Manual
Page 89
SPECIFICATIONS Tail/brake light: 12 V, 5.0 W/21.0 W × 1 Front turn signal/position light: 12 V, 21 W/5.0 W × 2 Rear turn signal light: 12 V, 21.0 W × 2 License plate light: 12 V, 5.0 W × 1 Meter lighting: LED High beam indicator light: LED Turn signal indicator light: LED x 2 Engine trouble warning light: LED Immobilizer system indicator light: LED Backup fuse: 10.0 A 2 3 4 5 6 7 8 9 Fuses: Main fuse: 30.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 15.0 A Ignition fuse: 10.0 A Radiator fan fuse: 15.0 A Fuel injection system fuse: 10.0 A 9-3
SPECIFICATIONS Tail/brake light: 12 V, 5.0 W/21.0 W × 1 Front turn signal/position light: 12 V, 21 W/5.0 W × 2 Rear turn signal light: 12 V, 21.0 W × 2 License plate light: 12 V, 5.0 W × 1 Meter lighting: LED High beam indicator light: LED Turn signal indicator light: LED x 2 Engine trouble warning light: LED Immobilizer system indicator light: LED Backup fuse: 10.0 A 2 3 4 5 6 7 8 9 Fuses: Main fuse: 30.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 15.0 A Ignition fuse: 10.0 A Radiator fan fuse: 15.0 A Fuel injection system fuse: 10.0 A 9-3
Owners Manual
Page 95
... specified in effect, this warranty with headlight, stoplight, and turn signals shall be warranted for warranty by : a) Competition or racing use. b) Installation of parts or accessories that the machine be to conform at the time of purchase, with all apparent defects within the period listed immediately below. d) Lack of each Yamaha motorcycle covered by Yamaha due to meet these standards...
... specified in effect, this warranty with headlight, stoplight, and turn signals shall be warranted for warranty by : a) Competition or racing use. b) Installation of parts or accessories that the machine be to conform at the time of purchase, with all apparent defects within the period listed immediately below. d) Lack of each Yamaha motorcycle covered by Yamaha due to meet these standards...
Owners Manual
Page 96
... handled at the time of your warranty registration card or other in the Owner's Manual instead of a motor vehicle to maintain a complete, up every new machine before sale. 2. Q. Be sure to your request at any or all costs of a safetyrelated defect and recall. Since all first purchasers against the possibility of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake...
... handled at the time of your warranty registration card or other in the Owner's Manual instead of a motor vehicle to maintain a complete, up every new machine before sale. 2. Q. Be sure to your request at any or all costs of a safetyrelated defect and recall. Since all first purchasers against the possibility of normal maintenance services, non-warranty repairs, accident and collision damages, and oil, oil filters, air filters, spark plugs, and brake...
Owners Manual
Page 99
... tank cap...4-11 Fuses, replacing ...7-30 R Rear brake lock lever ...4-10 Rear brake lock lever cable, adjusting ...7-22 Rear view mirrors ...4-18 Rider backrest, adjusting...4-15 H Handlebar switches ...4-8 Headlight bulb, replacing...7-31 Helmet holder ...4-15 High beam indicator light...4-2 Horn switch...4-9 B Battery ...7-28 Brake fluid, changing ...7-25 Brake fluid level, checking ...7-24 Brake lever, front ...4-9 Brake lever, rear ...4-10 Brake levers, lubricating ...7-26 Braking ...6-3 S Safe-riding points ...2-5 Safety information ...2-1 Seat...4-14 Sidestand ...4-18 Spark plugs...
... tank cap...4-11 Fuses, replacing ...7-30 R Rear brake lock lever ...4-10 Rear brake lock lever cable, adjusting ...7-22 Rear view mirrors ...4-18 Rider backrest, adjusting...4-15 H Handlebar switches ...4-8 Headlight bulb, replacing...7-31 Helmet holder ...4-15 High beam indicator light...4-2 Horn switch...4-9 B Battery ...7-28 Brake fluid, changing ...7-25 Brake fluid level, checking ...7-24 Brake lever, front ...4-9 Brake lever, rear ...4-10 Brake levers, lubricating ...7-26 Braking ...6-3 S Safe-riding points ...2-5 Safety information ...2-1 Seat...4-14 Sidestand ...4-18 Spark plugs...