Hayward NorthStar Support Question
Hayward NorthStar Support Question
Find answers below for this question about Hayward NorthStar.Need a Hayward NorthStar manual? We have 1 online manual for this item!
Question posted by Rosibls on June 19th, 2014
What Pump Is A Direct Fit For A Hayward Northstar 2 Hp
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward NorthStar Manual Pages
All NorthStar models - Page 1
... performance while reducing maintenance requirements.
The NorthStar is a self-priming pump that includes an improved seal and impeller design that will provide many years of today's in-ground swimming pool/spa that is specifically engineered for the demanding requirements of efficient, dependable, corrosion-free service. The Hayward NorthStar Pump is equipped with large capacity filters...
All NorthStar models - Page 2
...CAUTION -
It requires free circulation of air for outdoor use on the equipment. Pool and spa components have a finite life. Basic safety precautions should always be installed and ...spas if so marked. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS This is strongly advised to prevent overheating of the motor. This pump is designed for cooling. NorthStar™ Pump...
All NorthStar models - Page 3
... Electric Shock. Dual suction fittings shall be installed. Replace ...pump installed in the "Pipe Sizing Chart" found at the bottom of page 5 of swimming pool, spa...HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Evisceration...applied directly to two or more suction outlets per pump ...NorthStar™ Pump Series
Page 3 of electric shock replace damaged wiring immediately.
All NorthStar models - Page 4
Failure to do so could result in a position to allow the motor to accommodate even the most demanding installations, including pool/spa combinations and in violent separation of the Hayward NorthStar Pump Series. WARNING - Strainer cover must be set in severe personal injury and/or property damage.
Tri-Lock design makes strainer cover removal easy. No...
All NorthStar models - Page 5
...
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Allow use , it rains. Suction lines should be tight (but not over-tightened). It is strongly advised to place pump and filter in a damp or non-ventilated location. Joints must : Allow pump inlet height to be as close to pool as practical and run suction lines as direct as...
All NorthStar models - Page 6
... and bond pump motor can cause serious or fatal electrical shock hazard.
All electrical wiring MUST be in conformance with a continuous wire. Insure that the electrical supply available agrees with one to motor nameplate voltage.
Hazardous Pressure. do NOT over-tighten fitting or you face the open end of swimming pool, spa, or hot...
All NorthStar models - Page 7
...in conformance with all pump and system components are
intact and functioning properly.
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Full Rate (FR)
HP
KW
3/4
0.55...
Max Rate (MR)
HP
KW
1
0.75
1-1/2
1.10
2
1.55
2-1/2
1.87
3
2.20
-
-
WARNING - Run pressure test for this test. 2. NorthStar™ Pump Series
Page 7 of ...
All NorthStar models - Page 8
... genuine Hayward seal assembly kit.
Failure to pool/spa system directly in severe personal injury. Be sure all suction and discharge valves are open when pump is higher than the pump, unscrew... 3. NorthStar™ Pump Series
Page 8 of water (not air or air
and water) is discharged from pump and piping system using filter manual air relief valve. ATTENTION - NEVER run pump dry....
All NorthStar models - Page 9
... Disconnect pump from strainer housing. (See Parts Diagram on the motor shaft. Exercise extreme care in a dry
area.
NorthStar™ Pump Series
Page 9 of the pump/strainer ...pump/strainer housing. Storing Pump For Winterization
WARNING - Remove drain plugs and strainer cover from mounting pad, wiring (after power has been turned OFF), and piping. 4. Contact your pool/spa...
All NorthStar models - Page 10
... plate (item #16).
7. NorthStar™ Pump Series
Page 10 of the ceramic... seal (item #13) with a soft cotton cloth. Lubricate the rubber cup on the top of the plate and the mating groove on the ceramic seat and press it . WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD...direction. Rotate the impeller (item #12) counterclockwise and remove.
All NorthStar models - Page 11
Qty. 1 1 1 1 10 10 10 10 10 1 1
10 (5 for 2-3 HP)
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS No. NorthStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Parts Listing
Ref. Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX4020TP 4 SPX4000M 5 SPX4000S
6 & 7 SPX4000CLO SPX4000CLOB
8 SPX4000T 9 SPX4000Z1 10 SPX4000B ...
All NorthStar models - Page 12
... HP FR 1 HP FR 1 ½ HP FR 2 HP FR 3 HP FR 1 HP MR
1 ½ HP MR 2 HP MR 2 ½ HP MR 3 HP MR 1 ½ HP MR 2 SP 2 HP MR 2 SP 2 ½ HP MR 2 SP
Note: FR: Full Rate Pump MR: Max Rate Pump 2 SP: Dual Speed Pump
...SPX1625Z1MNS SPX1610Z2MNS SPX1615Z2MNS SPX1620Z2MNS
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump Series
Page 12 of 2)
Ctn.
All NorthStar models - Page 13
... professional. 2.
NorthStar™ Pump Series
Page 13 of obstruction. Improper or loose wiring connections; tripped circuit breakers, or blown fuses. If you have 5" - 6" of overheating. NOTE: Your Hayward pump motor is clean...ensure that the wiring gauge is rotating at the strainer cover (Only your pool dealer can build up causing windings to check that the motor is heavy...
All NorthStar models - Page 14
... hand over return fitting will
allow chlorinated water to seep into bearings wiping out the grease causing bearing to whine. NorthStar™ Pump Series
Page 14 ...Hayward Pool Products, 2007 All rights reserved. Motor bearings noisy from return fittings).
PRODUCT REGISTRATION
(Retain For Your Records)
DATE OF INSTALLATION INITIAL PRESSURE GAUGE READING (CLEAN FILTER PUMP...
All NorthStar models - Page 15
... by the respective manufacturer will apply. This warranty gives you specific legal rights, and you .
NorthStar™ Pump Series
Page 15 of 15
HAYWARD® LIMITED WARRANTY
This pump was inspected before shipment from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater □ Heat...
Similar Questions
Hayward Northstar Pool Pump .where Is The Capacitor?
(Posted by omidmsirro 9 years ago)
Where Is The Capacitor On My Hayward Matrix 1 1/2 Hp Pool Pump
(Posted by VERjhonri 10 years ago)
How To Wire Hayward Northstar Dual Speed Pool Pump
(Posted by AtheTina 10 years ago)
How To Install The Electric For Northstar Pool Pump
(Posted by ismaesa 10 years ago)
Hayward Power-flo Matrix 1.5 Hp Pool Pump Wont Start
(Posted by tbblai 10 years ago)