User Manual
Page 6
... in doubt as material for grounding. Use electrical devices with 3-prong grounded plugs. 2. TABLE OF CONTENTS Introduction...2 Important Safety Instructions...3-4 Specific Safety Rules...4 Symbols...5-7 Electrical...8-9 Features ...10 Assembly...11 Operation...12-14 Maintenance...15-16 Troubleshooting...17 Warranty...18-20 Parts Ordering / Service...Back Page introduction This product has...
... in doubt as material for grounding. Use electrical devices with 3-prong grounded plugs. 2. TABLE OF CONTENTS Introduction...2 Important Safety Instructions...3-4 Specific Safety Rules...4 Symbols...5-7 Electrical...8-9 Features ...10 Assembly...11 Operation...12-14 Maintenance...15-16 Troubleshooting...17 Warranty...18-20 Parts Ordering / Service...Back Page introduction This product has...
User Manual
Page 8
... is running in . See a doctor. Do not cover the fuel tank cap when the engine is used to instruct others who may use for fuel expansion. English Use of unauthorized parts or failure to a transfer switch as a separately derived system in accordance with NFPA 70, National Electrical Code. The generator shall be installed by a qualified electrician and connected to follow instructions in the Maintenance section of this manual. Replace damaged parts...
... is running in . See a doctor. Do not cover the fuel tank cap when the engine is used to instruct others who may use for fuel expansion. English Use of unauthorized parts or failure to a transfer switch as a separately derived system in accordance with NFPA 70, National Electrical Code. The generator shall be installed by a qualified electrician and connected to follow instructions in the Maintenance section of this manual. Replace damaged parts...
User Manual
Page 14
... SPECIFICATIONS Engine Engine Type Single Overhead Cam (SOHC) Spark Plug NHSP LD A7RTC Engine Lubricant Volume 13.52 oz. The safe use of this operator's manual as well as a knowledge of the project you are used with two carry handles for operating appropriate appliances, electrical lighting, tools, and motor loads. Auto idle switch The auto idle switch is equipped with a parallel kit (sold separately) that will allow generators to start the generator's engine. BATTERY...
... SPECIFICATIONS Engine Engine Type Single Overhead Cam (SOHC) Spark Plug NHSP LD A7RTC Engine Lubricant Volume 13.52 oz. The safe use of this operator's manual as well as a knowledge of the project you are used with two carry handles for operating appropriate appliances, electrical lighting, tools, and motor loads. Auto idle switch The auto idle switch is equipped with a parallel kit (sold separately) that will allow generators to start the generator's engine. BATTERY...
User Manual
Page 17
... marks on the dipstick. Fuel system damage or performance problems resulting from ignition sources, handle outdoors only, do not re-thread. n Pull the engine recoil five (5) times to the CHOKE position. tions. n Wipe dipstick clean and re-seat in . Lubricant level should not be used. n Replace and secure the fuel tank cap. Keep away from the use an oil/gas mixture. below are not covered under warranty. Never use old, stale, or contaminated...
... marks on the dipstick. Fuel system damage or performance problems resulting from ignition sources, handle outdoors only, do not re-thread. n Pull the engine recoil five (5) times to the CHOKE position. tions. n Wipe dipstick clean and re-seat in . Lubricant level should not be used. n Replace and secure the fuel tank cap. Keep away from the use an oil/gas mixture. below are not covered under warranty. Never use old, stale, or contaminated...
User Manual
Page 20
... n Place the engine/choke lever in the fuel system, drain the fuel from the unit before storing. n Make sure engine and exhaust of operation Check Engine Lubricant Change Engine Lubricant2 Check Air Filter Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank and Filter1,2 Check Fuel Hose Fuel Filter Inspect Replace Check All Hose ...
... n Place the engine/choke lever in the fuel system, drain the fuel from the unit before storing. n Make sure engine and exhaust of operation Check Engine Lubricant Change Engine Lubricant2 Check Air Filter Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank and Filter1,2 Check Fuel Hose Fuel Filter Inspect Replace Check All Hose ...
User Manual
Page 21
.... No fuel. gapped. Engine stored without treating or Drain fuel and carburetor. DC receptacle does not work . The following symptoms may indicate problems that will not start position. TROUBLESHOOTING PROBLEM Engine will affect the emissions level of these symptoms, have the unit inspected and repaired by the nearest authorized service c enter. 17 - Check engine lubricant level and fill, if necessary. Spark plug faulty, fouled, or improperly Replace spark plug. gasoline. Engine lacks power...
.... No fuel. gapped. Engine stored without treating or Drain fuel and carburetor. DC receptacle does not work . The following symptoms may indicate problems that will not start position. TROUBLESHOOTING PROBLEM Engine will affect the emissions level of these symptoms, have the unit inspected and repaired by the nearest authorized service c enter. 17 - Check engine lubricant level and fill, if necessary. Spark plug faulty, fouled, or improperly Replace spark plug. gasoline. Engine lacks power...
User Manual
Page 22
... SORE owner, you should be used in Above Systems including: (a) Switches (b) Hoses, belts, connectors, and assemblies. (8) Air injection system (a) Pulse valve 18 - MANUFACTURER'S WARRANTY COVERAGE: The emissions control system is covered. (1) Fuel Metering System: (a) Gasoline carburetor assembly and its internal components (b) Carburetor gaskets (c) Fuel tank (d) Fuel Line (e) Fuel Line Fittings (f) Clamps (2) Air Induction System including: (a) Intake pipe/manifold (b) Air cleaner (3) Ignition System including: (a) Spark plug (b) Ignition coil (4) Catalytic Muffler Assembly (if...
... SORE owner, you should be used in Above Systems including: (a) Switches (b) Hoses, belts, connectors, and assemblies. (8) Air injection system (a) Pulse valve 18 - MANUFACTURER'S WARRANTY COVERAGE: The emissions control system is covered. (1) Fuel Metering System: (a) Gasoline carburetor assembly and its internal components (b) Carburetor gaskets (c) Fuel tank (d) Fuel Line (e) Fuel Line Fittings (f) Clamps (2) Air Induction System including: (a) Intake pipe/manifold (b) Air cleaner (3) Ignition System including: (a) Spark plug (b) Ignition coil (4) Catalytic Muffler Assembly (if...
User Manual
Page 23
... engine involved, receive prompt notice of service items, fuel, and lubricating oil, etc. 6. Instances when normal use and service, from the date of sale to the repair and replacement, at Techtronic Industries option, of any part or parts which in the fuel tank, fuel lines, or carburetor, sticky valves or corrosion and rust of the engine warranty beyond the original term as set forth above. All repairs qualifying under normal use...
... engine involved, receive prompt notice of service items, fuel, and lubricating oil, etc. 6. Instances when normal use and service, from the date of sale to the repair and replacement, at Techtronic Industries option, of any part or parts which in the fuel tank, fuel lines, or carburetor, sticky valves or corrosion and rust of the engine warranty beyond the original term as set forth above. All repairs qualifying under normal use...
User Manual
Page 24
... for parts and labor by the owner. Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - The Company will be required by an authorized service center. This warranty gives you specific legal rights, and you may also have other purpose, such as specified in this operator's manual. English This warranty is limited to ninety (90) days from state to the owner after repair or replacement will be repaired or replaced...
... for parts and labor by the owner. Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - The Company will be required by an authorized service center. This warranty gives you specific legal rights, and you may also have other purpose, such as specified in this operator's manual. English This warranty is limited to ninety (90) days from state to the owner after repair or replacement will be repaired or replaced...
User Manual 3
Page 17
... adding gas. n Replace and secure the fuel cap. Do not allow stabilizer to start subsequent times: NOTE: Subsequent starting should not be used. n Replace and secure the fuel tank cap. n Pull the engine recoil five (5) times to the RUN position. n Move the CHOKE LEVER to prime the fuel system. Ethanol. n Replace and secure the oil cap/dipstick. To prevent serious personal injury and property damage, handle gasoline with the machine turned off , check the lubricant level before...
... adding gas. n Replace and secure the fuel cap. Do not allow stabilizer to start subsequent times: NOTE: Subsequent starting should not be used. n Replace and secure the fuel tank cap. n Pull the engine recoil five (5) times to the RUN position. n Move the CHOKE LEVER to prime the fuel system. Ethanol. n Replace and secure the oil cap/dipstick. To prevent serious personal injury and property damage, handle gasoline with the machine turned off , check the lubricant level before...
User Manual 3
Page 19
...: Do not change engine lubricant while it is still warm but not hot. Replace the screw and tighten securely. SPARK PLUG REPLACEMENT See Figure 13. n Inspect spark plug for all moving parts to stop, and disconnect spark plug wire and move it away from the oil fill hole into an approved container. If spark plug is cracked or chipped, spark plug should be properly gapped and free of operation. CHECKING/CLEANING AIR FILTER See Figures...
...: Do not change engine lubricant while it is still warm but not hot. Replace the screw and tighten securely. SPARK PLUG REPLACEMENT See Figure 13. n Inspect spark plug for all moving parts to stop, and disconnect spark plug wire and move it away from the oil fill hole into an approved container. If spark plug is cracked or chipped, spark plug should be properly gapped and free of operation. CHECKING/CLEANING AIR FILTER See Figures...
User Manual 3
Page 20
... Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank and Filter1,2 Check Fuel Hose Fuel Filter Inspect Replace Check All Hose Connections Inspect Fuel Tank Vapor Vent (If Equipped) Inspect Carbon C anister (CARB Models Only) 1. Remove cover and set aside. n Place the engine/choke lever in a vehicle, drain the fuel tank...
... Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank and Filter1,2 Check Fuel Hose Fuel Filter Inspect Replace Check All Hose Connections Inspect Fuel Tank Vapor Vent (If Equipped) Inspect Carbon C anister (CARB Models Only) 1. Remove cover and set aside. n Place the engine/choke lever in a vehicle, drain the fuel tank...
User Manual 3
Page 21
... fuel tank. Spark plug faulty, fouled, or improperly Replace spark plug. Dirty fuel filter. Engine stored without treating or Drain fuel and carburetor. Turn the auto idle switch to start . AC receptacle does not work . Item plugged in gasoline. The following symptoms may indicate problems that will not start position. TROUBLESHOOTING PROBLEM Engine will affect the emissions level of these symptoms, have the unit inspected and repaired by the nearest authorized service c enter. 17 - Check engine lubricant level and...
... fuel tank. Spark plug faulty, fouled, or improperly Replace spark plug. Dirty fuel filter. Engine stored without treating or Drain fuel and carburetor. Turn the auto idle switch to start . AC receptacle does not work . Item plugged in gasoline. The following symptoms may indicate problems that will not start position. TROUBLESHOOTING PROBLEM Engine will affect the emissions level of these symptoms, have the unit inspected and repaired by the nearest authorized service c enter. 17 - Check engine lubricant level and...
User Manual 3
Page 22
... warranty is the result of parts or accessories which vary from the date of the original retail purchase. The Company will be returned to the owner after repair or replacement will not pay for repairs or adjustments to the operating instructions as commercial or rental. This warranty does not cover any product that is limited to any RYOBI® brand outdoor product. Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change...
... warranty is the result of parts or accessories which vary from the date of the original retail purchase. The Company will be returned to the owner after repair or replacement will not pay for repairs or adjustments to the operating instructions as commercial or rental. This warranty does not cover any product that is limited to any RYOBI® brand outdoor product. Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change...
User Manual 3
Page 23
... obligation under this Limited Warranty shall be promptly delivered, transportation prepaid, to the repair and replacement, at Techtronic Industries option, of service items, fuel, and lubricating oil, etc. 6. Engine tune-ups and normal maintenance service including, but not limited to, valve adjustment, normal replacement of any warranty claim and that Techtronic Industries, directly or through one of any part or parts which has been subject...
... obligation under this Limited Warranty shall be promptly delivered, transportation prepaid, to the repair and replacement, at Techtronic Industries option, of service items, fuel, and lubricating oil, etc. 6. Engine tune-ups and normal maintenance service including, but not limited to, valve adjustment, normal replacement of any warranty claim and that Techtronic Industries, directly or through one of any part or parts which has been subject...
User Manual 5
Page 8
.... Replace damaged parts. Covering the fuel tank cap during or immediately after use may use a battery-powered carbon monoxide detector when running . Damage may contain a dangerous amount of carbon monoxide. English If running . Pay close attention to all electronic equipment should be checked prior to plugging them into this product, loan them to instruct others who may cause engine failure and/or damage to the tool...
.... Replace damaged parts. Covering the fuel tank cap during or immediately after use may use a battery-powered carbon monoxide detector when running . Damage may contain a dangerous amount of carbon monoxide. English If running . Pay close attention to all electronic equipment should be checked prior to plugging them into this product, loan them to instruct others who may cause engine failure and/or damage to the tool...
User Manual 5
Page 20
...Remove the fuel cap. n Keep unit level to dispose of the maintenance information listed below. When generator has exceeded the maximum figures specified in the fuel system, drain the fuel from the fuel tank into container. n Allow fuel to the intervals of operation Check Engine Lubricant Change Engine Lubricant2 Check Air Filter Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank...
...Remove the fuel cap. n Keep unit level to dispose of the maintenance information listed below. When generator has exceeded the maximum figures specified in the fuel system, drain the fuel from the fuel tank into container. n Allow fuel to the intervals of operation Check Engine Lubricant Change Engine Lubricant2 Check Air Filter Clean Air Filter Change Air Filter2 Check/Adjust Spark Plug Replace Spark Plug2 Check/Adjust Idle Speed Check/Adjust Valve Clearance1,2 Clean Fuel Tank...
User Manual 5
Page 23
... to service the particular engine involved, receive prompt notice of engine parts. 2. Any engine which in worn piston, piston rings, cylinders, valves, valve guides, carburetor, or other warranty or to assume any additional obligation on Techtronic Industries' behalf unless made in the fuel tank, fuel lines, or carburetor, sticky valves or corrosion and rust of any part or parts under this Limited Warranty shall be limited to the repair and replacement...
... to service the particular engine involved, receive prompt notice of engine parts. 2. Any engine which in worn piston, piston rings, cylinders, valves, valve guides, carburetor, or other warranty or to assume any additional obligation on Techtronic Industries' behalf unless made in the fuel tank, fuel lines, or carburetor, sticky valves or corrosion and rust of any part or parts under this Limited Warranty shall be limited to the repair and replacement...
User Manual 5
Page 24
..., negligence, accident, the effects of corrosion or erosion, or that has been operated in any way contrary to the operating instructions as commercial or rental. To locate your nearest Authorized Ryobi Service Center, dial 1-800-860-4050. 20 - Any part of this warranty does not cover: Tune-ups - Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - Techtronic Industries North America, Inc., reserves the right to...
..., negligence, accident, the effects of corrosion or erosion, or that has been operated in any way contrary to the operating instructions as commercial or rental. To locate your nearest Authorized Ryobi Service Center, dial 1-800-860-4050. 20 - Any part of this warranty does not cover: Tune-ups - Spark Plugs, Carburetor, Carburetor Adjustments, Ignition, Filters, Oil Change Wear items - Techtronic Industries North America, Inc., reserves the right to...
User Manual 6
Page 1
... injury or death, user must read and understand operator's manual before unit will start. If engine lubricant level is equipped with fresh fuel. Spark plug faulty, fouled, or improperly Replace spark plug. gapped. Choke lever is in is low. Engine stored without treating or draining Drain fuel and carburetor. Dirty fuel filter. Water in and turn on /off . Drain entire system and refill with Low Oil Shutoff. Dirty air filter. Clean or replace as needed . • Start the generator with...
... injury or death, user must read and understand operator's manual before unit will start. If engine lubricant level is equipped with fresh fuel. Spark plug faulty, fouled, or improperly Replace spark plug. gapped. Choke lever is in is low. Engine stored without treating or draining Drain fuel and carburetor. Dirty fuel filter. Water in and turn on /off . Drain entire system and refill with Low Oil Shutoff. Dirty air filter. Clean or replace as needed . • Start the generator with...
