Poulan PR240 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan PR240 manuals!
Problems with Poulan PR240?
Ask a Question
Free Poulan PR240 manuals!
Problems with Poulan PR240?
Ask a Question
Popular Poulan PR240 Manual Pages
Owner Manual - Page 2
...manual(s) before starting when setting up spilled fuel.
(h) If fuel is running engine or hot engine.
(c) Fill fuel tank outdoors with a plastic liner. It means CAUTION!!! BECOME ALERT!!!
WARNING: Always disconnect spark plug... instruction.
3. Avoid loose fitting clothing that may be used and remove all instructions on the ground. it is to a running (except when specifically ...
Owner Manual - Page 3
... TROUBLESHOOTING 19 REPAIR PARTS 20-39 ENGINE BREAKDOWN 40-41
3 When cleaning, repairing or inspecting the snow thrower, stop the engine and make certain the collector/ impeller and all moving parts have competent, well-trained technicians and the proper tools to 50°F) SAE 5W-30 (below 32°F)
Oil Capacity:
16 Ounces (0,47 Liters)
Spark Plug...
Owner Manual - Page 7
...INSTRUCTIONS BEFORE USE OF THIS PRODUCT. KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE.
PULL OUT TO STOP
DANGER
DO NOT PLACE HANDS NEAR BLADES
DANGER, KEEP FEET AWAY
REMOVE SPARK PLUG WIRE BEFORE PERFORMING MAINTENANCE
DANGER READ OPERATORS MANUAL...SNOW THROWER
READ THIS OWNER'S MANUAL AND ALL SAFETY RULES BEFORE OPERATING... DANGER READ OPERATORS MANUAL DO NOT OPERATE ON STEEP SLOPES...
Owner Manual - Page 13
...Service and Adjustments section of white lithium grease to the operator. To receive full value from the warranty, operator must maintain snow thrower as instructed in this snow thrower does not cover items that have been subjected to be sure they are functioning properly. NOTE: Use only Original Equipment Manufacturer (OEM) parts...this manual should replace the spark plug and check belts for...
Owner Manual - Page 14
... securely for 25 hours in the Service and Adjustments section of each use. SPARK PLUG
Replace spark plug at "FULL" line on level surface.
• Oil will result in the "PRODUCT SPECIFICATIONS" section of operation, whichever occurs first.
Change the oil after every 100 hours of this manual).
7. Using other than OEM belts can result in a suitable container. All...
Owner Manual - Page 15
... engaged, check to see if the shear bolts have completely stopped.
4. Wait for all moving parts to stop .
2.
CAUTION: Do not substitute. Insert safety ignition key and reconnect spark plug wire to frame.
2. Remove belt cover.
• Replace belt cover by installing cover and tightening screws.
Place wire where it cannot come in the OFF position.
2. Use...
Owner Manual - Page 16
... tighten securely. (4-6 Ft. Lbs. / 5-8 Nm).
5. Continue with "AFTER REPLACING BELTS" instructions. BEFORE REPLACING BELTS 1. REMOVE DISCHARGE CHUTE - TO INSTALL AUGER BELT
1. See "TO REMOVE BELT COVER" in the tipped position as you bring the unit back together.
2. SERVICE AND ADJUSTMENTS
TO REPLACE BELTS
The auger and traction drive belts are damaged or begin to the snow thrower...
Owner Manual - Page 17
...thrower to suspected carburetor problems, take your local parts dealer. Tighten securely (30-35 Ft. Tighten securely.
6. Operate all controls to drive belt tensioner arm.
3. TO INSTALL DRIVE BELT
1. Pivot and hold the swing plate away from snow thrower and remove drive belt from drive pulley. Tighten securely.
3. Lbs. / 41-47 Nm).
5.
Remove auger belt. Place drive belt into engine...
Owner Manual - Page 18
... your can starts to rust. Pull recoil starter handle slowly a few times to distribute oil.
4. Do not use engine or carburetor cleaner products in the Maintenance section of this manual).
2.
Inspect and replace belts, if necessary (See "TO REPLACE BELTS" in the Maintenance section of this manual).
3.
Add stabilizer to gasoline in your gasoline will cause problems.
• If...
Owner Manual - Page 19
...an authorized service center/department. Primer not depressed. 7. Empty fuel tank & carburetor, refill with fresh, clean gasoline. 4. Water in STOP position
(or ON/OFF switch is off valve (if so equipped) in manual unless directed to OPEN position.
2. Replace damaged parts. drive / slowing 2. Bad spark plug. 10. Turn fuel shut-off of pulley. 2. Prime as instructed in need...
Owner Manual - Page 20
... IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
20 MODEL PR240 (96192006703)
AUGER HOUSING / IMPELLER ASSEMBLY
3 14
14 15 14
10
14
11 13
13 12 13
9 8 6
9
4 8
5
13 2
1
7
7
6 7
05.09.009-J
6
NOTE: All component dimensions given in U.S. REPAIR PARTS
SNOW THROWER -
Owner Manual - Page 21
... (O.E.M.) replacement parts. REPAIR PARTS
SNOW THROWER - MODEL PR240 (96192006703)
AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
PART NO....AUGER IMPELLER STEEL PULLEY IMPELLER - BLK BOLT CARRIAGE WAFER HEAD 5/16-18 X 5/8 BLK BRACKET BELT KEEPER LOWER BRACKET INTERFACE BEARING BALL SCREW HEX HEAD 5/16-18 X 5/8 NUT FLANGE NYLOCK 5/16-18 LOWER AUGER BELT GUIDE...
Owner Manual - Page 23
....4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
23 BLK
1
3
585 80 29-01 BOLT CARRIAGE
5/16-18 X 1.25 - MODEL PR240 (96192006703)
AUGER HOUSING / IMPELLER ASSEMBLY
1
05.09.039-A
2 3
KEY NO.
1 2 3
PART NO.
532 19 21-99 532 40...
Owner Manual - Page 40
... 17 64-01 CARBURETOR (L10-1) (GEN
II SNOW 179CC- REPAIR PARTS
SNOW THROWER - MCR (179CC) 8 532 42 92-36 FLYWHEEL -
NO. DESCRIPTION
13 532 43 65-63 MUFFLER KIT (179CC PW7
SNOW - VALVE COVER GSKT)
3 532 42 05-80 VALVE COVER (179/208CC) (INCL.
MODEL PR240 (96192006703)
COMPLETE ENGINE-585742603
KEY PART NO. MANUAL START
(208CC) 9 532 42...
Owner Manual - Page 41
...69-67 RECOIL STARTER - INCH CRANKSHAFT)
34 532 43 69-66 SPARK PLUG BOOT - NO.
GASKET) (SN >1265H0519257)
32 532 42 95-...PART NO. RED)
62 N/A
N/A
65 581 37 28-01 TAPPET KIT (208/254CC)
(SET OF 2)
69 532 42 49-51 CARBURETOR STUDS &
COUPLLNG KIT-SNOW
70 580 35 36-01 CARBURETOR REPAIR...MODEL PR240 (96192006703)
COMPLETE ENGINE-585742603
KEY PART NO. DESCRIPTION
23 532 43 21-44 FUEL HOSE KIT ...
Poulan PR240 Reviews
We have not received any reviews for Poulan yet.