Poulan PR1030ES Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PR1030ES manuals!
Problems with Poulan PR1030ES?
Ask a Question
Free Poulan PR1030ES manuals!
Problems with Poulan PR1030ES?
Ask a Question
Popular Poulan PR1030ES Manual Pages
User Manual - Page 1
Failure to do so can result in U.S.A. Always Wear Eye Protection During Operation
428556 Rev.1 08.20.09 SR
Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
PR1030ES
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
... when specifically recommended by the manufacturer for any damage, and repair the damage before filling.
4.
To avoid severe burns on the ground, away from the machine.
Know how to observe the following safety instructions could result in moving parts. Adjust the collector housing height to avoid slipping or falling, especially when operating the snow thrower in...
User Manual - Page 3
... this manual. SERIAL NUMBER
DATE OF PURCHASE
THE MODEL AND SERIAL NUMBERS WILL BE FOUND ON A DECAL ATTACHED TO THE REAR OF THE SNOW THROWER HOUSING. Walk; TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 14-15
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 19
ASSEMBLY / PRE-OPERATION 5-7
TROUBLESHOOTING 20
OPERATION 8-13
REPAIR PARTS...
User Manual - Page 5
...-wrench may be used for additional loose parts. Install in lower holes in the toolbox.
UPPER HANDLE
HANDLE KNOB
SPEED CONTROL ROD
PLASTIC TIE
HOW TO SET UP YOUR SNOW THROWER
TOOL BOX (See Fig. 10)
A toolbox is located on your snow thrower. ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety before you attempt to...
User Manual - Page 12
...parts to the snow thrower.
• If snow thrower must be operated over gravel or rocky surfaces. Replace...replacement. To avoid engine problems, the fuel system should be used within 30 days to operate the snow thrower...Storage Instructions ...parts bag may occur. After considerable use extra caution and be reversed, providing additional service before storage of this manual...
User Manual - Page 14
...parts to service this manual. BEFORE EACH USE
1.
Check engine oil level.
2. Check controls to properly maintain your snow thrower. A new spark plug will need to be made periodically to be checked at least once each season.
• Once a year, you should replace... snow thrower as instructed in this unit. Check for wear. Some adjustments will help your snow thrower well...
User Manual - Page 15
... cap / dipstick securely each five (5) hours of this manual).
Install left side wheel may be replaced by original equipment manufacturer (OEM) belts available from spark plug. Refill engine with API service classification SG-SL. Keep oil at the factory. Wipe off any oil trapped inside the snow thrower. Select the oil's SAE viscosity grade according to...
User Manual - Page 16
... both of this manual. Should a foreign object or ice become lodged in the OFF position.
2. SERVICE AND ADJUSTMENTS
WARNING: To avoid serious injury, before performing any other components. WARNING: To avoid serious injury, never operate your snow thrower.
4. Install 1/4-20 lock nut and tighten securely.
To replace the shear bolts:
1. Wait for all moving parts to the...
User Manual - Page 17
...
BOLTS
6. REMOVE AUGER BELT from the pulley (by a service center/department.
Serious personal injury and/ or damage to engine crankshaft. Install clutch rod in idler arm and rotate ratchet clockwise to be replaced by catching the idler arm bracket while bringing snow thrower together), separate the snow thrower and repeat step 12. If auger belt has become...
User Manual - Page 18
... a qualified service center, which is factory set for your snow thrower to the end of the shaft - SERVICE AND ADJUSTMENTS
TO REMOVE WHEELS (See Fig. 23)
• Remove the klik pin and remove wheel from your local parts dealer.
Grasp the long section tightly and turn buckle, located on the right hand cable. KLIK PIN (INSTALL IN OUTER...
User Manual - Page 19
... forming in essential fuel system parts such as carburetor, fuel hose, or tank during storage. IMPORTANT: Never cover snow thrower while engine/exhaust area is an acceptable alternative in your gasoline will cause problems.
• If possible, store your can damage the fuel system of this manual.
4. WARNING: Never store the snow thrower with clean engine oil...
User Manual - Page 20
... is OFF.
1. Frozen recoil starter.
1. See "IF RECOIL STARTER HAS FROZEN" in need of this manual. 7.
Check / replace drive belt. Drive belt is worn. 3. Check / reinstall drive belt.
of snow discharge
1. Contact an authorized service center/department.
Loss of snow discharge or slowing of drive speed 3. Auger belt is off valve to pull
1. Augers / impeller...
User Manual - Page 25
MODEL PR1030ES (96192003100)
CONTROL PANEL / DISCHARGE CHUTE
5
7 15
3 16
*14 *11
2
4
6 10
KEY NO.
1 2 3 4 5 6 7 8 9 *10 *11 *12 *13 *14 15 16
PART NO.
420315X428 .... 2.
ITEMS 15 AND 16 ARE SERVICE PART NUMBERS TO ALLOW PURCHASE OF INDIVIDUAL ITEMS IF NECESSARY. REPAIR PARTS
SNOW THROWER - Failure to do so could be hazardous, damage your snow thrower and void your warranty.
25 inches....
User Manual - Page 26
...INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY.
2
1
KEY PART NO.
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS
SNOW THROWER - Failure to do so could be hazardous, damage your snow thrower and void your warranty.
26 MODEL PR1030ES (96192003100)
CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *7
KEY NO...
User Manual - Page 39
...REPAIR PARTS DECALS
SNOW THROWER - MODEL PR1030ES (96192003100)
1 4
9 12
6
1
3
10 11
KEY PART NO. NO.
1 181037 3 181035 4 181042 6 181033 9 415475 10 183730 11 415399 12 415398 - - 428556 - - 428557
DESCRIPTION
DECAL, DANGER DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, INSTRUCTION DECAL, SPEED CONTROL DECAL, REMOTE DEFLECTOR CONTROL DECAL, LH TRIGGER DECAL, RH TRIGGER OWNER'S MANUAL...
Poulan PR1030ES Reviews
Do you have an experience with the Poulan PR1030ES that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!