Hayward Navigator Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward Navigator manuals!
Problems with Hayward Navigator?
Ask a Question
Free Hayward Navigator manuals!
Problems with Hayward Navigator?
Ask a Question
Hayward Navigator Videos
Hayward Navigator Pro at Pool Plaza, Venice Florida, 34293
Duration: 11:56
Total Views: 1,959
Duration: 11:56
Total Views: 1,959
How to Repair a Hayward Navigator
Duration: 3:34
Total Views: 12,319
Duration: 3:34
Total Views: 12,319
Hayward Navigator Pool Cleaner
Duration: 1:44
Total Views: 20,694
Duration: 1:44
Total Views: 20,694
Pool vacuum: check for loose pods (Hayward Pool Vac, Ultra, Navigator, Bug)
Duration: 1:33
Total Views: 24,215
Duration: 1:33
Total Views: 24,215
Popular Hayward Navigator Manual Pages
Pool Vac Classic - Page 2
...Navigator Pro
LIMITED
WARRANTY
Pool Vac Classic
LIMITED
WARRANTY
Note
Hayward Turbine Cleaners should be relative to that a "service call Hayward...installation of your Cleaner. Turbine Suction Cleaner
OWNER'S MANUAL
Congratulations on your purchase of the Cleaner in your pool will be applicable to your installation. Consult your Hayward dealer for the Cleaner, including additional hose...
Pool Vac Classic - Page 3
... reading these instructions, the "How To" installation DVD (included with Pool Vac XL & Navigator Pro only) will walk you some maintenance and trouble-shooting hints. Make sure that the water is properly balanced and that the water level is at regular intervals according to it that might not be used .
Connect the exclusive Hayward hose sections...
Pool Vac Classic - Page 5
... until proper reading appears on the Flow Gauge. (Refer to adjust vacuum/water flow. If the setting is to be used, follow the installation instructions included with the black disk outside of the box on and allow it will be in the system. If a Hayward Skimmer Vacuum Plate is higher than required with the Skimmer...
Pool Vac Classic - Page 6
Installation
INSTALLING YOUR HAYWARD CLEANER IS SIMPLE...
If you have connected your hose to the Hayward Vac Lock, it handy. Step 7 Remove the Flow Gauge from time to time if the Cleaner is connected to "sink" the Cleaner hose, as when vacuuming the pool with the cleaner. Step 8 Check the rear flap adjuster dial at the left rear of...
Pool Vac Classic - Page 7
... go all the way up the wall. Installation
INSTALLING YOUR HAYWARD CLEANER IS SIMPLE... This is governed by the programmed steering and therefore it will not climb the wall each time it will be on the walls. When the Cleaner does start up ," turn the rear flap adjuster to get "hung up a wall, it comes...
Pool Vac Classic - Page 8
... filter system and most in-ground vinyl liner pools, your cleaner the hose sections must be damaged should the hose disconnect from the cleaner.
1. Hayward Turbine Cleaners do not adhere to move properly in your Cleaner will not need a V094 Regulator Valve (see ...'s ability to these walls. Turbine Suction Cleaners
IMPORTANT TIPS
Pool Vac XL/Navigator Pro In one hole in the bottom.
Pool Vac Classic - Page 13
... suction hose from cleaner
Change out steps -
1 1
2
1. A
8. Insure the snaps are aligned
inside the front of the Pool Vac XL Skirt/Mid Section is not recommended as DIY repair. It is strong possibility that you bring your Pool Vac XL to a HAYWARD dealer for replacement. Tools required - #2 Phillips screwdriv8er
7
6
1/8" flat screwdriver
Preliminary steps - Set the...
Pool Vac Classic - Page 14
... suction hose from cleaner
Change out steps - 2
1 1
1. Navigator Pro Skirt/Mid Section Replacement:
Replacement of the Navigator Pro Skirt/Mid Section is strong possibility that you bring your Navigator Pro to the Middle Body slots and push the Handle down in the four screws previously removed.
6. Navigator Pro
MAINTENANCE TIPS
5. There
is not recommended as DIY repair. Lift...
Pool Vac Classic - Page 17
...throat
Clear blockage
Worn shoes
Replace shoes
Worn wings
Replace wings
Hose too short
Install additional hose sections per
installation instructions.
only)
Problem: Cleaner fails to |||
15 Turbine Suction Cleaner
TROUBLESHOOTING GUIDE
Problem: Slow/no forward movement CAUSES Lack of/improper water flow through cleaner
Check water flow with Flow Gauge and adjust as per Step...
Pool Vac Classic - Page 18
... "float"
Remove all air from cleaner head Stop all air from entering the pool through cleaner Check water flow with Flow Gauge and adjust per instructions in both
Readjust return outlets to water surface and sucks air. Turbine Suction Cleaner
TROUBLESHOOTING GUIDE
Problem: Cleaner climbs to prevent water flow interfering with fine bubbles, give the...
Pool Vac Classic - Page 19
... IF NECESSARY. Turbine Suction Cleaner
TROUBLESHOOTING GUIDE
Problem: Cleaner sticks at steps, corners, etc. Worn shoes
Replace shoes
Worn wings
Replace wings
Hose too short
Install additional hose per Step 6. CAUSES
SOLUTIONS
Improper water flow
Check water flow with Flow Gauge and adjust as per installation instructions.
c) check medium turbine and spindle
gear assemblies...
Pool Vac Classic - Page 20
...is such that plaster. automatic or
manual cannot remove that a pool vacuum cleaner - not vice versa. E) Vinyl is affected by the installation and the pool's surroundings. F) Vinyl... cause wear on the
Cleaner - H) When installing your Hayward Turbine Suction Cleaner. 3) The number of the Hose Sections used. 4) A current water flow indicator setting (refer to Step 6, Figure 2).
18 D)...
Pool Vac Classic - Page 22
... devices are comprised of the shoes (located on the bottom of the unit), wings (located on the sides of the unit) and flaps (located on the front and rear of the unit).
22 LIMITED PARTS WARRANTY
To the Original Retail Consumer/Purchaser (the "PURCASER") of the Hayward Pool Vac XL, Navigator Pro and Pool Vac...
Parts Diagram - Page 1
Navigator®
CONCRETE, DESERT AND VINYL MODEL REPLACEMENT PARTS
Parts Diagram
Cleaners
Turbine Kits AXV112P/AXV602P
See pgs. 226-227
V096P In-line Gauge
34
a b
31
A-Frame Kit AXV111P/AXV118P AXV601P/AXV601D
See pgs. 226-227
33
a b
30
a b
Spring-Loaded Vinyl Access Plate
Not Pictured
208 HAYWARD
Parts Diagram - Page 2
... * 10 50 50 * * 50 50 50 50 50 50 * 25
*
25
25 25
25 25 25 50 50 25 25 25
No. Part No.
Navigator®
CONCRETE, DESERT AND VINYL MODEL REPLACEMENT PARTS
Parts Listing
Ref. No.
1a 1b 2 3 4 5 6 7 8 9 10 11 12 13 14 15a 15b 15c 16 17 18a 18b 18c 19 20 21 22a 22b...
Hayward Navigator Reviews
We have not received any reviews for Hayward yet.