Owner's Manual
Page 151
... when the engine is running, immediate service is first turned on and remain on when the ignition is required and you of a problem with the transmission in NEUTRAL until the brakes have the system checked by an authorized dealer. 21. The light will come on briefly as a bulb check. The system... the system to deactivate and turn off . 20. If a problem is detected the light will automatically reactivate and turn on while the engine is excessive transmission fluid temperature that there is running your vehicle will remain disabled for service as soon as trailer towing. If the...
... when the engine is running, immediate service is first turned on and remain on when the ignition is required and you of a problem with the transmission in NEUTRAL until the brakes have the system checked by an authorized dealer. 21. The light will come on briefly as a bulb check. The system... the system to deactivate and turn off . 20. If a problem is detected the light will automatically reactivate and turn on while the engine is excessive transmission fluid temperature that there is running your vehicle will remain disabled for service as soon as trailer towing. If the...
Owner's Manual
Page 152
...the parking brake is applied, the light will usually be an indication that the parking brake has not been released, or there is a low brake fluid level. Although your dealer for service as soon as a bulb check, until the vehicle is started . TOW/HAUL The TOW/HAUL button is ...for emissions testing the light will come on when the ignition is first turned on and remain on for 15 seconds, then blink for automatic transmissions. Malfunction Indicator Light This light is necessary. If brake failure is indicated, immediate repair is part of an onboard diagnostic system which monitors ...
...the parking brake is applied, the light will usually be an indication that the parking brake has not been released, or there is a low brake fluid level. Although your dealer for service as soon as a bulb check, until the vehicle is started . TOW/HAUL The TOW/HAUL button is ...for emissions testing the light will come on when the ignition is first turned on and remain on for 15 seconds, then blink for automatic transmissions. Malfunction Indicator Light This light is necessary. If brake failure is indicated, immediate repair is part of an onboard diagnostic system which monitors ...
Owner's Manual
Page 206
...above approximately 35 mph (56 km/h). This will resume normal operation. If the transmission temperature becomes hot enough the TRANS TEMP light may illuminate and the transmission may not shift into Overdrive and will automatically select the most desirable gear for operation...When To Use "TOW/HAUL" Mode When driving in extremely cold temperatures, the transmission may downshift out of Overdrive until the transmission cools down. The transmission will resume when the transmission fluid temperature has risen to a suitable level. Normal operation will downshift from Overdrive to ...
...above approximately 35 mph (56 km/h). This will resume normal operation. If the transmission temperature becomes hot enough the TRANS TEMP light may illuminate and the transmission may not shift into Overdrive and will automatically select the most desirable gear for operation...When To Use "TOW/HAUL" Mode When driving in extremely cold temperatures, the transmission may downshift out of Overdrive until the transmission cools down. The transmission will resume when the transmission fluid temperature has risen to a suitable level. Normal operation will downshift from Overdrive to ...
Owner's Manual
Page 207
... AND OPERATING 207 performance and reduce the potential for improved braking) will demonstrate that the transmission is able to excessive shifting. The "TOW/HAUL" light will not engage until the transmission fluid and engine coolant are warm [usually after shifting the 5 If the "TOW/HAUL" ... drops below a calibrated speed, or during steady cruise (for improved fuel economy) and automatic closed-throttle downshifts to 3rd gear (for transmission overheating or failure due to shift into Overdrive (4th gear) are modified. NOTE: The torque converter clutch will illuminate in "TOW/HAUL...
... AND OPERATING 207 performance and reduce the potential for improved braking) will demonstrate that the transmission is able to excessive shifting. The "TOW/HAUL" light will not engage until the transmission fluid and engine coolant are warm [usually after shifting the 5 If the "TOW/HAUL" ... drops below a calibrated speed, or during steady cruise (for improved fuel economy) and automatic closed-throttle downshifts to 3rd gear (for transmission overheating or failure due to shift into Overdrive (4th gear) are modified. NOTE: The torque converter clutch will illuminate in "TOW/HAUL...
Owner's Manual
Page 208
...driveline components. The NV 144 transfer case is normal and will refill within five seconds of shifting from the torque converter into the transmission. This is All-Wheel Drive (AWD). Transfer Case Position Indicator Lights Transfer case position indicator lights are no indicator lights on the...engine start up 208 STARTING AND OPERATING transmission into any other gear position. This is required, the transfer case 4LOCK position can be driven in the 4LOCK position on the instrument panel. When additional traction is due to the fluid partially draining from Park into gear ...
...driveline components. The NV 144 transfer case is normal and will refill within five seconds of shifting from the torque converter into the transmission. This is All-Wheel Drive (AWD). Transfer Case Position Indicator Lights Transfer case position indicator lights are no indicator lights on the...engine start up 208 STARTING AND OPERATING transmission into any other gear position. This is required, the transfer case 4LOCK position can be driven in the 4LOCK position on the instrument panel. When additional traction is due to the fluid partially draining from Park into gear ...
Owner's Manual
Page 280
... any other . If a light or bright colored dot is a corrosive acid solution; Don't lean over battery when attaching clamps or allow battery fluid to touch each other booster source with large quantities of water. • A battery generates hydrogen gas which might make an unintended electrical contact.... 2. Park the booster vehicle within cable reach but without letting the vehicles touch. Set the parking brake, place the automatic transmission in PARK and turn the ignition OFF on skin, flush the contaminated area immediately with an output that exceeds 12 volts. Wear eye...
... any other . If a light or bright colored dot is a corrosive acid solution; Don't lean over battery when attaching clamps or allow battery fluid to touch each other booster source with large quantities of water. • A battery generates hydrogen gas which might make an unintended electrical contact.... 2. Park the booster vehicle within cable reach but without letting the vehicles touch. Set the parking brake, place the automatic transmission in PARK and turn the ignition OFF on skin, flush the contaminated area immediately with an output that exceeds 12 volts. Wear eye...
Owner's Manual
Page 284
... Steering - Fluid Check ...303 ▫ Front Suspension Ball Joints ...304 ▫ Drive Shaft Constant Velocity Joints ...304 ▫ Body Lubrication ...304 ▫ Windshield Wiper Blades ...305 ▫ Windshield Washers ...305 ▫ Exhaust System ...306 ▫ Cooling System ...306 ▫ Emission Related Components ...311 ▫ Brake System ...313 ▫ Automatic Transmission ...315 ▫...
... Steering - Fluid Check ...303 ▫ Front Suspension Ball Joints ...304 ▫ Drive Shaft Constant Velocity Joints ...304 ▫ Body Lubrication ...304 ▫ Windshield Wiper Blades ...305 ▫ Windshield Washers ...305 ▫ Exhaust System ...306 ▫ Cooling System ...306 ▫ Emission Related Components ...311 ▫ Brake System ...313 ▫ Automatic Transmission ...315 ▫...
Owner's Manual
Page 315
... properly, the following procedure must be on a vehicle used : 1. Place the gear selector briefly in the fluid may be noted. Automatic Transmission Fluid Level Check - 3.7L Engine This fluid level should be changed. A physical change in each gear position ending with a non-factory installed air-conditioning unit. Worn brake hoses can burst and cause...
... properly, the following procedure must be on a vehicle used : 1. Place the gear selector briefly in the fluid may be noted. Automatic Transmission Fluid Level Check - 3.7L Engine This fluid level should be changed. A physical change in each gear position ending with a non-factory installed air-conditioning unit. Worn brake hoses can burst and cause...
Owner's Manual
Page 316
... normal operating temperature 180°F (82°C). The fluid cannot be in the crosshatched area marked "OK". a. If the fluid level is properly reseated. Fluid Level Check - 4.7L/5.7L Engine Check the fluid level while the transmission is hot, the reading should be held between the two...and feel if the fluid is between the fingertips. Warm is when fluid is hot or warm. b. Fluid is warm, the reading should be comfortably held comfortably between 85° and 125°F (29° and 52°C). 6. To check the automatic transmission fluid level properly, the ...
... normal operating temperature 180°F (82°C). The fluid cannot be in the crosshatched area marked "OK". a. If the fluid level is properly reseated. Fluid Level Check - 4.7L/5.7L Engine Check the fluid level while the transmission is hot, the reading should be held between the two...and feel if the fluid is between the fingertips. Warm is when fluid is hot or warm. b. Fluid is warm, the reading should be comfortably held comfortably between 85° and 125°F (29° and 52°C). 6. To check the automatic transmission fluid level properly, the ...
Owner's Manual
Page 317
...oil is seen on both sides. NOTE: If it should be between the "HOT" (upper) reference holes when the transmission reaches 180°F ( 82°C). If the fluid level is correctly established at room temperature, it is necessary to produce an accurate reading. 7. Remember it may not register... should be between the "HOT" (upper) reference holes on the dipstick. It is low, add as required into the transmission before rechecking the fluid level. If the fluid is normal for leaks. Do not overfill. Check for the 7 Remove the dipstick, wipe it clean and reinsert it until ...
...oil is seen on both sides. NOTE: If it should be between the "HOT" (upper) reference holes when the transmission reaches 180°F ( 82°C). If the fluid level is correctly established at room temperature, it is necessary to produce an accurate reading. 7. Remember it may not register... should be between the "HOT" (upper) reference holes on the dipstick. It is low, add as required into the transmission before rechecking the fluid level. If the fluid is normal for leaks. Do not overfill. Check for the 7 Remove the dipstick, wipe it clean and reinsert it until ...
Owner's Manual
Page 318
... service by an Authorized Dodge Dealer or Service Center. Refer to Recommended Fluids, Lubricants and Genuine Parts for your type of special dyes to aid in the dipstick tube. It is important that they be avoided, since they may cause deterioration in the transmission. Using a transmission fluid other than the manufacturers recommended fluid may adversely affect...
... service by an Authorized Dodge Dealer or Service Center. Refer to Recommended Fluids, Lubricants and Genuine Parts for your type of special dyes to aid in the dipstick tube. It is important that they be avoided, since they may cause deterioration in the transmission. Using a transmission fluid other than the manufacturers recommended fluid may adversely affect...
Owner's Manual
Page 338
SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant. Use only recommended brake fluids. Mopar DOT 3 and SAE J1703 should be used. SAE 75W-140 Synthetic Gear Lubricant. 338 MAINTAINING YOUR VEHICLE Chassis Component Automatic Transmission Transfer Case Front Axle Rear Axle Brake Master Cylinder Power Steering Reservoir Fluids, Lubricants and Genuine Parts. Mopar ATF+4, Automatic Transmission Fluid. Mopar ATF+4, Automatic Transmission Fluid. If DOT 3 brake fluid is not available, then DOT 4 is acceptable. Mopar ATF+4, Automatic Transmission Fluid.
SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant. Use only recommended brake fluids. Mopar DOT 3 and SAE J1703 should be used. SAE 75W-140 Synthetic Gear Lubricant. 338 MAINTAINING YOUR VEHICLE Chassis Component Automatic Transmission Transfer Case Front Axle Rear Axle Brake Master Cylinder Power Steering Reservoir Fluids, Lubricants and Genuine Parts. Mopar ATF+4, Automatic Transmission Fluid. Mopar ATF+4, Automatic Transmission Fluid. If DOT 3 brake fluid is not available, then DOT 4 is acceptable. Mopar ATF+4, Automatic Transmission Fluid.
Owner's Manual
Page 342
Checking the oil level while the vehicle is on level ground will improve the accuracy of coolant reservoir, brake master cylinder, and transmission and add as needed. • Check all lights and all other electrical items for unusual wear or damage. 8 Once a Month ... the exhaust system. • Inspect the brake hoses. • Inspect the CV joints (if equipped) and front suspension components. • Check the automatic transmission fluid level. • Check the coolant level, hoses, and clamps. • Check the engine oil level about 5 minutes after a fully warmed engine is at...
Checking the oil level while the vehicle is on level ground will improve the accuracy of coolant reservoir, brake master cylinder, and transmission and add as needed. • Check all lights and all other electrical items for unusual wear or damage. 8 Once a Month ... the exhaust system. • Inspect the brake hoses. • Inspect the CV joints (if equipped) and front suspension components. • Check the automatic transmission fluid level. • Check the coolant level, hoses, and clamps. • Check the engine oil level about 5 minutes after a fully warmed engine is at...
Owner's Manual
Page 345
Check transfer case fluid level (4X4). Inspect PCV valve, replace as necessary.* Drain and refill automatic transmission fluid and change main sump filter (4.7L/5.7L only). 18,000 (29 000) X X 21,000 (34 000) X 24,000 (38 000) X X 27,000 (43 000) X 30,000 (48 000) X X X X X X X X X A I N T E N A N C E S C H E D U L E S X 8 Rotate tires. Inspect brake linings. Replace spark plugs. Change rear axle fluid. Change front axle fluid (4X4). SCHEDULE "B" 345 M Miles (Kilometers) Change engine oil and engine oil filter. Inspect engine air cleaner filter, replace if necessary.
Check transfer case fluid level (4X4). Inspect PCV valve, replace as necessary.* Drain and refill automatic transmission fluid and change main sump filter (4.7L/5.7L only). 18,000 (29 000) X X 21,000 (34 000) X 24,000 (38 000) X X 27,000 (43 000) X 30,000 (48 000) X X X X X X X X X A I N T E N A N C E S C H E D U L E S X 8 Rotate tires. Inspect brake linings. Replace spark plugs. Change rear axle fluid. Change front axle fluid (4X4). SCHEDULE "B" 345 M Miles (Kilometers) Change engine oil and engine oil filter. Inspect engine air cleaner filter, replace if necessary.
Owner's Manual
Page 347
...). Replace spark plugs. Inspect brake linings. Inspect auto tension drive belt and replace if required. Change rear axle fluid. Drain and refill automatic transmission fluid, change main sump filter (4.7L/5.7L only). Inspect transfer case fluid (4X4). 48,000 (77 000) X X 51,000 (82 000) X 54,000 (86 000) X X 57,..., taxi, fleet, or trailer towing. Rotate tires. Inspect engine air cleaner filter, replace if necessary. Drain and refill automatic transmission fluid and change filter (3.7L). SCHEDULE "B" 347 M Miles (Kilometers) Change engine oil and engine oil filter.
...). Replace spark plugs. Inspect brake linings. Inspect auto tension drive belt and replace if required. Change rear axle fluid. Drain and refill automatic transmission fluid, change main sump filter (4.7L/5.7L only). Inspect transfer case fluid (4X4). 48,000 (77 000) X X 51,000 (82 000) X 54,000 (86 000) X X 57,..., taxi, fleet, or trailer towing. Rotate tires. Inspect engine air cleaner filter, replace if necessary. Drain and refill automatic transmission fluid and change filter (3.7L). SCHEDULE "B" 347 M Miles (Kilometers) Change engine oil and engine oil filter.
Owner's Manual
Page 349
..., replace if necessary. Rotate tires. Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required. Change rear axle fluid. Drain and refill automatic transmission fluid and change main sump and cooler return filter (if equipped) (4.7L/5.7L only). 78,000 (125 000) X X 81,000 (130 000) X 84,000...
..., replace if necessary. Rotate tires. Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required. Change rear axle fluid. Drain and refill automatic transmission fluid and change main sump and cooler return filter (if equipped) (4.7L/5.7L only). 78,000 (125 000) X X 81,000 (130 000) X 84,000...
Owner's Manual
Page 352
... and service should also be performed anytime a malfunction is used for police, taxi, fleet, or trailer C towing. M 352 SCHEDULE "B" A I N Miles T (Kilometers) E N Drain and refill automatic transmission fluid, A change main sump filter (4.7L/5.7L only). This applies only if your N vehicle is observed or suspected. Retain all receipts. * This maintenance is recommended by... 000) 108,000 (173 000) 111,000 114,000 117,000 120,000 (178 000) (182 000) (187 000) (192 000) X Drain and refill automatic transmission fluid and change filter (3.7L).
... and service should also be performed anytime a malfunction is used for police, taxi, fleet, or trailer C towing. M 352 SCHEDULE "B" A I N Miles T (Kilometers) E N Drain and refill automatic transmission fluid, A change main sump filter (4.7L/5.7L only). This applies only if your N vehicle is observed or suspected. Retain all receipts. * This maintenance is recommended by... 000) 108,000 (173 000) 111,000 114,000 117,000 120,000 (178 000) (182 000) (187 000) (192 000) X Drain and refill automatic transmission fluid and change filter (3.7L).
Owner's Manual
Page 355
Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required.‡ Drain and refill automatic transmission fluid and change sump and cooler return filter (if equipped) (4.7L/5.7L only). 72,000 (115 000) [72] X X X 78,000 (125 000)...[96] X X X X X X X X X X X X 100,000 (160 000) X A I N T E N A N C E S C H E D U L E S X 8 Rotate tires. Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs. Check transfer case fluid level (4X4). SCHEDULE "A" 355 M Miles (Kilometers) [Months] Change engine oil and engine oil filter.
Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required.‡ Drain and refill automatic transmission fluid and change sump and cooler return filter (if equipped) (4.7L/5.7L only). 72,000 (115 000) [72] X X X 78,000 (125 000)...[96] X X X X X X X X X X X X 100,000 (160 000) X A I N T E N A N C E S C H E D U L E S X 8 Rotate tires. Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs. Check transfer case fluid level (4X4). SCHEDULE "A" 355 M Miles (Kilometers) [Months] Change engine oil and engine oil filter.
Owner's Manual
Page 370
... Auto Unlock ...16 Automatic Dimming Mirror ...70,74 Automatic Door Locks ...15 Automatic Headlights ...106 Automatic Temperature Control ...184 Automatic Transaxle ...203 Automatic Transmission ...200,203,315 Adding Fluid ...316,317 Fluid and Filter Changes ...318 Fluid Level Check ...315,316 Fluid Type ...318,338 Gear Ranges ...203 Special Additives ...318 Torque Converter ...207 Axle...
... Auto Unlock ...16 Automatic Dimming Mirror ...70,74 Automatic Door Locks ...15 Automatic Headlights ...106 Automatic Temperature Control ...184 Automatic Transaxle ...203 Automatic Transmission ...200,203,315 Adding Fluid ...316,317 Fluid and Filter Changes ...318 Fluid Level Check ...315,316 Fluid Type ...318,338 Gear Ranges ...203 Special Additives ...318 Torque Converter ...207 Axle...
Owner's Manual
Page 371
...Lubrication ...304 B-Pillar Location ...226 Brake Fluid ...338 Brake System ...218,313 Anti-Lock ...218 Disc Brakes ...313 Fluid Check ...313 Hoses ...314 Master Cylinder ...313 Parking ...217 Warning Light ...149,151 Brakes ...218 Brake/Transmission Interlock ...203 Break-In Recommendations, New... Vehicle ...62 Bulb Replacement ...327 Bulbs, Light ...327 Calibration, Compass ...124 Capacities, Fluid ...335 Caps, Filler Power Steering ...303 Car Washes ...321 Carbon ...
...Lubrication ...304 B-Pillar Location ...226 Brake Fluid ...338 Brake System ...218,313 Anti-Lock ...218 Disc Brakes ...313 Fluid Check ...313 Hoses ...314 Master Cylinder ...313 Parking ...217 Warning Light ...149,151 Brakes ...218 Brake/Transmission Interlock ...203 Break-In Recommendations, New... Vehicle ...62 Bulb Replacement ...327 Bulbs, Light ...327 Calibration, Compass ...124 Capacities, Fluid ...335 Caps, Filler Power Steering ...303 Car Washes ...321 Carbon ...