Yamaha EF3000iSE Support Question
Yamaha EF3000iSE Support Question
Find answers below for this question about Yamaha EF3000iSE - Inverter Generator - 3000 Maximum AC Output.Need a Yamaha EF3000iSE manual? We have 1 online manual for this item!
Question posted by pguenette on July 11th, 2015
Electric Start On Yamaha Ef3000ise
Generator will not start electrically turns over good. But it will start on first pull with the recoil.
Current Answers
Answer #1: Posted by TommyKervz on July 13th, 2015 1:05 PM
TommyKervz
Member since:
January 10th, 2013 Points: 17,776,823
Member since:
January 10th, 2013 Points: 17,776,823
See reasons and possible solutions here
Related Yamaha EF3000iSE Manual Pages
Owners Manual - Page 1
OWNER'S MANUAL
Generator
EF3000iSE EF3000iSEB
LIT-19626-01-20
7CH-28199-10
Owners Manual - Page 3
... parts from a Yamaha dealer. P/N LIT-19626-01-20 This manual will provide you with a good basic understanding of the operation and maintenance of Yamaha Motor Corporation, ...Yamaha. AE00002
INTRODUCTION
Congratulations on your purchase of your machine, please consult a Yamaha dealer. If you in the location as shown.
AE00022
EF3000iSE EF3000iSEB OWNER'S MANUAL © 2004 by Yamaha...
Owners Manual - Page 5
...ARE POISONOUS 5 FUEL IS HIGHLY FLAMMABLE AND POISONOUS 5 ENGINE AND MUFFLER MAY BE HOT 5 ELECTRIC SHOCK PREVENTION.....6 CONNECTION NOTES 7 CONNECTION 7 EXTENSION CORD NOTES 7 CONTROL FUNCTION 8 DESCRIPTION 8 CONTROL...11 ENGINE OIL 12 GROUND (Earth 12 BATTERY 13 OPERATION 15 STARTING THE ENGINE 15 APPLICATION RANGE 17 CONNECTION 18 STOPPING THE ENGINE...GENERATOR 37 WIRING DIAGRAM 38
Owners Manual - Page 6
... the factory. fied in material and workmanship for warranty by an authorized Yamaha consumer generator dealer.
SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY...for this warranty shall include parts replaced due to exclusions noted herein.
Any Yamaha non-commercial generator purchased and utilized for commercial or rental applications will the warranty be warranted...
Owners Manual - Page 7
... Manual, that failure may not be void or cancelled if I perform any authorized Yamaha generator dealer within the continental United States. Mail to second owners?
Does the warranty cover... A. BOX 6555 Cypress, California 90630
CHANGE OF ADDRESS
The federal government requires each Yamaha generator dealer is in the Owner's and Service Manual. Box 6555 Cypress, California 90630
...
Owners Manual - Page 9
... NEAR FLAMMABLE MATERIALS. 8 ELECTROCUTION CAN OCCUR IF GENERATOR IS USED IN RAIN,
SNOW, OR NEAR WATER. GARDEZ LA
MACHINE AU SEC EN TOUTES CIRCONSTANCES.
7NJ-24162-10
-4- 1
HOT EXHAUST
***-28176-**
2
OIL
zzzzzz
AC output Rated
Phase DC output Fuel
zzHz zzzKVA zzzV Single zzV zzA Gasoline
YAMAHA MOTOR CO., LTD.
KEEP THIS UNIT DRY AT...
Owners Manual - Page 11
... may overheat. a 1 m (3 ft)
741-098
9 Avoid operating the engine with a dust cover.
741-099
1
9 Be sure to carry the generator only by its carrying
handle(s).
1 Carrying handle(s) (shaded)
741-100
AE00083
ELECTRIC SHOCK PREVENTION 9 Never operate the engine in rain or snow.
741-101
9 Never touch the machine with wet hands or...
Owners Manual - Page 15
... protector turns off automatically when the load exceeds the generator rated output.
763-231
w q
cC
Reduce the load to the connected load.
AE00988
ECONOMY CONTROL SWITCH
q
1 I "RESET" 2 3 "OFF"
AE01048
FUEL COCK KNOB The fuel cock knob is used to supply fuel from the fuel tank to "3" (OFF) when using electric devices that require a large starting...
Owners Manual - Page 20
...-120e
- 15 - Pull the choke knob fully out.
1 Choke knob
q
NOTE:
The choke is not required to start .
1 Upper level
AE01073
STARTING THE ENGINE
NOTE: 9 Before starting the engine, do not connect any electric devices. 9 Turn the economy control switch to the original position.
Electric Starting:
q
3. q
700-006a
761-080
AE00955
OPERATION
NOTE: The generator has been shipped without...
Owners Manual - Page 22
... for more uniform voltage supply than portable generators provide. Examples include some medical equipment, personal computers, and some inverters that sense peak and RMS voltage values.
NOTE: Some precision equipment is
possible but total wattage should not exceed the rated output. AE01000
APPLICATION RANGE
AC
DC
Power factor
EF3000iSE EF3000iSEB
1
0.8-0.95
0.4-0.75 (Efficiency 0.85...
Owners Manual - Page 23
... starting current, such as a compressor or a submergible pump.
- 18 - Make sure the AC pilot light is on any electric devices are in good condition
before plugging it in to the AC receptacle.
761-082
4.
AE01023
CONNECTION
Alternating Current (AC)
cC
9 Be sure all electric devices including the lines
and plug connections are turned off
before connection to the generator...
Owners Manual - Page 24
.... Check for a few seconds at first when using electric devices that require a large starting current cannot be started.
- 19 -
Reduce the total wattage of the generator temporarily discharging more than its rated wattage.) While the overload indicator light is detected, the inverter control unit overheats, or the AC output voltage rises. However, this is not a malfunction. (The...
Owners Manual - Page 25
...install the battery. NOTE: Press to the specified generator rated output if the DC protector turns off again, consult a Yamaha dealer. 2
1
AE00825
Battery Charging
NOTE: The generator DC rated voltage is between 1.26 and 1.28...-238a
1 Red 2 Black
2. NOTE:
9 Make connections to the battery after starting the
engine.
761-081a
9 Clamp the red wire to the positive (+) terminal and
the black...
Owners Manual - Page 29
...Starting System
** 13.* Decarbonization
14. Check choke operation.
Ask an authorized Yamaha dealer for crack or damage. *Replace if necessary.
Check recoil...Yamaha dealer. ** : Related to emission control system. No. Item
8. Fuel Line 10. *C*hoke knob 11. Cooling System
12. Generation
15.*
Fittings/ Fasteners
Remarks
Clean fuel tank filter. Replace if necessary.
Check electric ...
Owners Manual - Page 36
A wrong fuse will cause electrical system damage and A FIRE HAZARD.
"BATTERY".)
2.
cC
Be sure the engine switch is turned to "STOP" to use specified fuse. Replace the blown fuse with one of proper amperage. Specified fuse: 10 A
NOTE: If the fuse immediately blows again, consult a Yamaha dealer.
- 31 - Remove the side cover 1 and the...
Owners Manual - Page 37
...
AE01078
TROUBLESHOOTING
Engine won 't produce power 2 Safety device (AC) to "ON". Add engine oil.
700-006 763-120g... Faulty ignition system ....
Fuel cock knob to reset the DC protector.
- 32 - AE00785
Generator won 't start
1. Engine oil system Insufficient
2 Oil level is low .... Electrical systems 2 Engine switch to "OFF" .... Tighten nuts properly. 2 Damaged gasket .... Poor ...
Owners Manual - Page 38
... in the spark plug area.
9 To prevent FIRE HAZARDS be sure to "ON", then pull the recoil starter and check if the oil warining light flickers. M
OK
Clean the spark plug. Consult a Yamaha dealer. AE00515
A ENGINE DOES NOT START
B Turn the engine switch to place the spark plug as far way as possible from the...
Owners Manual - Page 41
It is recommended that these items be serviced by a Yamaha dealer.
- 36 - The acronyms conform to the latest version of the SAE's recommended practice document J1930, "Diagnostic Acronyms, Terms, and Definitions For Electrical/Electronic System". AE00789
EXHAUST EMISSION CONTROL SYSTEM AND COMPONENTS
Item
Acronym
9 CARB. MAGNETO ASSY EI (Electronic Ignition)
PLUG, SPARK
9 ...
Owners Manual - Page 42
AE00707
GENERATOR
Unit
AC Output
Rated Voltage
V
Rated frequency
Hz
Rated current
A
Rated Output
kVA
Safty Device: Type
DC Output
Rated voltage
V
Rated current
A
Safety Device: Type
EF3000iSE
EF3000iSEB
120 60 23.3 2.8 Electronic
12 12 DC protector
- 37 - AE00701
AE00702
DIMENSIONS
Overall Length Overall Width Overall Height Dry Weight
SPECIFICATIONS
Unit mm (in) ...
Owners Manual - Page 43
... Orange
R Red
W White
Y Yellow
B/W Black/White
R/W Red/White
G/Y Green/Yellow
W/L White/Blue AE00751
WIRING DIAGRAM EF3000iSE
q
w LO OL
e
LO OL
@0
GG
YY
R
R
L
L
O
O
!7
!8
r
O O
Y
Y...
Br
!4
OFF
!3 ON
START
!5
R/W
G/Y
RR
R
G/Y R/W
M @4
L
!6
770-052
1 Main coil 2 Sub coil 3 DC coil 4 DC rectifier 5 Control unit 6 AC pilot light 7 AC receptacle 8 Ground (Earth) ...
Similar Questions
Generator Will Not Turn Over It Has 12 Volts To The Starter But When I Turn Key
When I turn key on I get nothing no oil light no green light just nothing and it only has 29 hours o...
When I turn key on I get nothing no oil light no green light just nothing and it only has 29 hours o...
(Posted by crazychris242448 1 year ago)
120/240 Volt Ac Output
1)Does Yamaha produce and sell a device that will cause these two generators in parallel to output 1...
1)Does Yamaha produce and sell a device that will cause these two generators in parallel to output 1...
(Posted by laynerd 10 years ago)
Had Remote Start Installed And Since Then My Batter Keeps Going Dead
(Posted by kkwetzel3128 10 years ago)
I Have Yamaha Ef3000ise It Has At Times Run Like The Choke Is On.
it seems to chug and the whole generator shakes violently so i have to shut it off. i let it sit for...
it seems to chug and the whole generator shakes violently so i have to shut it off. i let it sit for...
(Posted by csandre55 11 years ago)