Toro 20334 Support Question
Toro 20334 Support Question
Find answers below for this question about Toro 20334 - Personal Pace Electric Start Walk Power Mower.Need a Toro 20334 manual? We have 2 online manuals for this item!
Question posted by trddo on May 3rd, 2011
What Is The Proceedure To Replace The V-belt On A Toro 20334 Self Propelled Mowe
After removal of blade, belt housing and guide, how to remove v-belt from transmission pulley housing?
Current Answers
Related Toro 20334 Manual Pages
Owner's Manual - Page 1
... cause serious injury or death if you need service, genuine Toro parts, or additional information, contact an Authorized Service Dealer or Toro Customer Service and have similar laws.
Introduction
This rotary-blade, walk-behind lawn mower is not equipped with Canadian ICES-002.
© 2011--The Toro® Company 8111 Lyndale Avenue South Bloomington, MN 55420
Register...
Owner's Manual - Page 2
...This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind before you fed uneasy on the machine and in the manual(s) before cleaning the machine, removing ...Replacements
may ricochet back toward awone. Obey all instructions on a slope, do not mow it.
• Mow across the face of slopes;
stop before starting the engine.
• If the machine should start...
Owner's Manual - Page 3
... sources of children.
Never fill containers inside a vehicle or on the ground. Remove gas-powered equipment from the truck or trailer and refuel it on a truck or trailer bed with a plastic liner. Never tamper with manufacturer's recommended parts, when necessar):
Mower blades are explosive. Clean up . Do not change clothing immediatel):
Never overfill fuel...
Owner's Manual - Page 4
...Warning--read the Operator's Manual for information on slopes;
Replace damaged
Manufacturer's Mark
1. Cutting/dismemberment hazard of hand or foot, mower blade--stay away from moving parts.
5. Cutting/dismemberment hazard of potential danger. Safety and instruction decals are located near areas of hand or foot, mower
blade--remove the ignition key and read the Operator's Manual. 2.
Owner's Manual - Page 5
... Required
Procedure
Important: Your mower does not come with a bottle of oil.
i
G009550
Figure 3
2.
contact an Authorized
, Remove the handle _obs from the mower housing (Figure 3). Important: Route... (Figure 4).
Remove the dipstick by rotating the cap counterclockwise and pulling it does come with oil. Move the handle to a level surface.
2.
Before starting the engine, fill...
Owner's Manual - Page 9
.... s/
Note: If the mower does not start after self-propelling, stop walking, hold your sides, and the mower will automatically keep pace with you feel resistance, then pull it lightly until you (Figure 13).
1. Note: When you pull the recoil start handle (Figure 12). Blade control bar
7
_/_'G009546
Figure 10
, Turn the ignition key (Figure 11) (electric-start models only) or...
Owner's Manual - Page 10
... the lawn. Bagging the Clippings
Use the grass bag when you release the blade control
bar, both the engine and blade should stop using
your mower immediately Service Dealer.
Removing the Grass Bag
To remove the bag, reverse the steps above. Operating the Bag-on-Demand Lever
The bag-on-demand feature allows you leave the mower (electric-start...
Owner's Manual - Page 12
... fire warnings, and keep the mower free of the grass blade at a slower pace while mowing. - Walk at a time. Cut the grass more of the following: - Refer to stall. Overlap cutting swaths instead of cutting a full
swath with the blade. Never deliberately mow over aW object.
• If the mower strikes an object or starts to slow down.
Do...
Owner's Manual - Page 13
... Leaves
• After cutting the lawn, ensure that half of leaves on the front wheels one or two notches higher than the rear wheels. For example, set the front cutting height one notch lower than the rear cutting height.
• Slow down your mowing speed if the mower does not cut leaf cover.
Owner's Manual - Page 14
... and dirt from under the mower.
• Replace the air filter;
Recommended Maintenance Schedule(s)
Maintenance Service Interval
After the first 5 hours Before each use a hand fuel pump to running out of the machine from the normal operating position. Important: Refer to your engine operator's manual for 24 hours (electric-start models only).
• Empty...
Owner's Manual - Page 15
... warm it. Return the mower to open the air filter cover
(Figure 19).
2. Replacing the Air Filter
Service Interval: Every 25 hours 1. Replace the air filter (Figure 19). 3. G005822
1. Note: If the oil level is at a local recycling center.
15 Install the dipstick into the oil fill tube, then
remove the dipstick. 10.
Pour...
Owner's Manual - Page 16
...remove the adhesive-backed covering.
, Remove the screw that the charger is disconnected from the batter>
A flashing light that alternates between red and green indicates that protects the battery compartment. Charging the Battery
Service Interval: Every 25 hours
Electric-start...is charging the batter):
4
1. Replacing the Fuse
Electric-start
models only
CALIFORNIA Proposition 65 Warning...
Owner's Manual - Page 17
... 7.
Examine the blade whenever you run out of the blade to point toward the mower housing. , Use a torque wrench to tighten the blade bolt to 60 ft-lb (82 N-m). The blade is du_ or ...the blade with the air filter up. 3. If you removed in serious personal injury. If the blade is damaged or cracked, replace it immediatel3: If the blade edge is sharp; Fuse holder
4• Replace the ...
Owner's Manual - Page 18
... vdth the bag-on the mower housing (Figure 28).
7
Figure 27 This figure is running. • Do not allow bystanders in the cable (Figure 27). 3. the garden hose
, Start the engine and run it from the mower.
Start the engine and run it for the purpose of adjustment , adjust the self-propel drive cable.
, Loosen the cable...
Owner's Manual - Page 20
... Warranty (45 Day Limited Warranty for Commercial Use)
The Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler ¢
20 in Mulcher/Bagger Walk Power Mowers
Conditions and Products Covered
Items and Conditions Not Covered
The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly...
Parts Catalog - Page 1
Form No. 3371-850 Rev B
22in Recycler® Lawn Mower
Model No. 20334-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com. Original Instructions (EN)
*3371-850* B
Parts Catalog - Page 2
...Abbreviations
AR: as required ASM: assembly BBC: blade brake control BHTF: button head thread forming CARR...round head PTH: phillips truss head PTO: power-take-off RH: right hand ROPS: roll...: slotted round head STD: standard TAP: self tapping TTH: torx truss head
2 For ...an illustration has a reference number.
Ordering Replacement Parts
To order replacement parts, please supply the part number, ...
Parts Catalog - Page 3
... Chute and Rear Door Assembly 4 Rear Bag Assembly 5 Engine and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Electrical Assembly 10 Attachments and Accessories 11
© 2012-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in...
Parts Catalog - Page 6
... 1 Shield-Muffler
3 32144-1
3 Screw-Taptite
5 106-3999
1 Spacer-Driver
6 106-3987
1 Blade Driver ASM
7 108-9764-03 1 Blade-22 Inch
8 108-3766-03 1 Support-Blade
9 105-8579
1 Bolt-Blade
10 105-3030-03 1 Guide-Belt
11 95-1726
3 Screw-Taptite
12 114-7937
1 Cover-Belt
13 46-8091
2 Screw-HWH
14 2210-316
1 Stop-Rope
16 121...
Parts Catalog - Page 8
...
6 104-8699
2 Bearing-Ball
7 108-9782
2 Bushing-Sleeve
8 108-9781
2 Arm-Pivot, Rear
9 108-9780
2 Arm-Spring
10 110-0549
2 Knob-HOC
11 115-4652
1 Transmission
12 115-4669
1 Belt-V
13 114-7977-03 1 Bracket-Transmission
Ref. Part Number Qty. Part Number Qty. Transmission and Rear Wheel Drive Assembly
Ref.
Similar Questions
Toro Recycle Manual 20334 Self Propelled Does Not Work
(Posted by khamik 9 years ago)
Toro 20334 Self Propelled Does Not Walk
(Posted by naeescncz 10 years ago)
How To Replace The Torsion Spring On A Toro Personal Pace Lawn Mower
(Posted by vlsteevette 10 years ago)
Electric Start Toro Law Mower Will Not Start Cold 20334
(Posted by pinoNtha 10 years ago)
Toro Self Propelled Lawn Mower Personal Pace Won't Pull The Mower 20332
(Posted by pksrsc 10 years ago)