Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by salerusla on December 17th, 2013
Toro Push Lawn Mower Troubleshooting Wont Stay Running
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on January 19th, 2014 6:04 PM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
Hi, if your mower starts but won't stay running, it's likely either a problem in the fuel tank/fuel line or carburetor. Try flushing the gas tank and carburetor, giving the carburetor a good cleaning to make sure no holes or venturis are clogged, and checking the fuel hose for burrs or blockages. Then fill the gas tank with new gas and give it a try.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
And here are a couple other links that may be useful:
- How to troubleshoot a lawn mower with starting issues
- Top 5 Ways to Keep Your Lawn Mower Running Longer and Better
Related Toro 20332 Manual Pages
Operation Manual - Page 1
... cause serious injury or death if you need service, genuine Toro parts, or additional information, contact an Authorized Service Dealer or Toro Customer Service and have similar laws.
This spark ignition system ...Code Section 4442 to use or operate the engine on the product.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 ...
Operation Manual - Page 2
...potential personal injury hazards. Tall grass can hide obstacles.
• Do not mow on this mower ...run.
• Disengage the drive system, if so equipped, before operating. Failure to a complete stop the engine and check for holes, ruts, bumps, rocks, or other safety protective devices in wet grass. Only use accessories approved by the blade. Stay behind rotary lawn mowers...
Operation Manual - Page 3
... of a child. Do not run the engine indoors or in safe working condition.
• Never tamper with a portable container, rather than the operator.
• Be alert and turn mower off if a child enters the...vehicle or on the ground away from your view of Gasoline
To avoid personal injury or property damage, use a nozzle lock-open flame, spark, or pilot light such as necessary.
3 ...
Operation Manual - Page 4
...Important: Safety and instruction decals are located near areas of hand or foot, mower blade-stay away from moving parts.
5. Thrown object hazard-keep bystanders a safe distance ...-read the Operator's Manual for information on slopes; Cutting/dismemberment hazard of hand or foot, mower blade-do not discard. 2. contains lead; Replace damaged decals. Manufacturer's Mark
1. Warning-read...
Operation Manual - Page 5
...that you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with oil in the crankcase, then do the following: 1. Note: When the ... oil into the oil fill tube, then remove the dipstick.
5. Dipstick
Figure 4
3. Move the mower to the operating position. 3. Wipe the dipstick clean with oil. Note: If the oil level is...
Operation Manual - Page 6
... securely. Product Overview
3
Charging the Battery
No Parts Required
Procedure
Electric-start models only)
6
Grass bag 2. Important: Do not overfill the crankcase with oil and run the engine. Figure 5
1. Handle
8.
Operation Manual - Page 7
...days old.
1.
Important: To reduce starting problems, add fuel stabilizer to a level surface. 2.
Move the mower to the fuel all season, mixing it with a clean cloth.
4.
Drain the excess oil until the ...is at the Full mark on the dipstick (Figure 8). Fill the fuel tank with oil and run the engine. Remove the dipstick (Figure 8). Do not mix oil with an API service classification ...
Operation Manual - Page 8
CAUTION
If the engine has been running, the muffler will be hot and can severely burn you feel resistance, then pull it ... bar against the handle (Figure 10). Keep away from the hot muffler. Allow the rope to return to the same height as desired. Lower the mower
Note: The cutting height settings are 1 inch (25 mm); 1-3/8 inches (35 mm); 1-3/4 inches (44 mm); 2-1/8 inches (54 mm); 2-1/2 ...
Operation Manual - Page 9
... 13
WARNING
A worn grass bag could allow the mower to recycle the grass and leaf clippings back into the lawn. If the mower still does not roll backward easily, contact an Authorized...recycling the clippings. If the side discharge chute is on the mower, remove it is sharp; contacting the blade can also try reaching just under the personal pace handle to the metal handle and push the mower...
Operation Manual - Page 10
...small stones and other similar debris to another. contacting the blade can result in serious personal injury or death to the mower. • For bagging the grass and leaf clippings, press the
button on the...-on-demand door and the surrounding opening (Figure 16) before you to either collect or recycle grass and leaf clippings while the grass bag is sharp; Lower the rear deflector. WARNING
...
Operation Manual - Page 11
...bag is on the mower and the bag-on-demand lever is sharp;
Stop the engine and wait for cutting very tall grass.
WARNING
The blade is in serious personal injury. Figure 17
...Demand Lever). contacting the blade can result in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating position. Installing the Side Discharge Chute
Lift ...
Operation Manual - Page 12
...lawn, set the front wheels at 2-1/8-inch (54 mm) and the rear wheels at a slower pace while mowing.
- Walk at 2-1/2 inches (64 mm). Overlap cutting swaths instead of the grass blade at a time.
WARNING
Wet grass or leaves can cause the mower...• After cutting the lawn, ensure that the blade could hit.
• Avoid striking solid objects with a Toro replacement blade. Raise the...
Operation Manual - Page 13
... Service Dealer (go to www.toro.com to your engine operator's manual for Maintenance
1. Refer to your engine operator's manual. • Refer to running out of the machine from the... can cause personal injury. Disconnect the spark plug wire from the normal operating position. tip the mower prior to your engine operator's manual for additional maintenance procedures. Run the engine dry...
Operation Manual - Page 14
... dipstick (Figure 20). Figure 19
Changing the Engine Oil
Service Interval: After the first 5 hours Yearly
Run the engine a few minutes before changing the oil to settle. 8. Wait 3 minutes for Maintenance. 3.... dipstick. Return the mower to Preparing for the oil to warm it. Refer to the operating position. 6. Note: If the oil level is at a local recycling center.
14
Install the...
Operation Manual - Page 15
...a wall outlet. Note: When the battery no longer holds a charge, recycle or dispose of the lead-acid battery according to the mower wire harness
located below the ignition key (Figure 22).
• A green...Every 25 hours
Electric-start models only
If the battery does not charge or the engine does not run with a 40-amp plug-in type fuse.
1.
Note: Your battery charger may be blown. Replace...
Operation Manual - Page 16
...to point toward the mower housing. 6.
Figure 25
4. Remove the blade, saving all mounting hardware (Figure 26).
Wear gloves when servicing the blade.
1. Replace the fuse in serious personal injury.
If the ... Install the covering over the battery compartment. 7. Tip the mower onto its side with the screw that you run out of wood, put your weight behind the
16
Fuse
...
Operation Manual - Page 17
... the water on the cable support. Start the engine and run it for the purpose of adjustment, adjust the self-propel drive cable. 1.
Loosen the cable support nut (Figure 27). 2. Wash out the area under the mower housing. • Wear eye protection. • Stay in the operating position (behind the
handle) when the...
Operation Manual - Page 18
...hours (electric-start models only). If you must store the mower in an enclosure near an open flame.
• Allow the engine to run until you must charge the battery every 90 days (electric...-start models only).
2. Loosen the handle knobs until it is sufficiently dry.
6.
Recycle it .
1. Allow the ...
Operation Manual - Page 20
...:
Products
22 in Recycler and 20 in Mulcher/Bagger and Attachments GTS (Guaranteed to Start) Engine Battery
Warranty Period 2 - The dealer will not start your product's engine in one location, or institutional or rental use, is at Toro Warranty Company.
*Residential purposes means use of your sole remedy under "Lawn Mowers") or access our...
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Similar Questions
Toro Personal Pace Mower Wont Stay Running Brand New
(Posted by bazm4 10 years ago)
My Toro Recycler Lawn Mower Wont Stay Running
(Posted by lvbarmehr 10 years ago)
Toro Recycler Mower 20331 Wont Stay Running
(Posted by grmgr 10 years ago)
Manual Control Push Lawn Mower Wont Stay Running
(Posted by jakBr 10 years ago)
2011 Toro Recycler Personal Pace Lawn Mower Wont Stay Running
(Posted by EssTss4 10 years ago)