Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by therfor on September 16th, 2014
Brand New Toro Won't Start
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on December 1st, 2014 10:40 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
If this is the first time it's been used, make sure that:
- The spark plug boot is attached to the spark plug
- The correct oil (SAE 30) has been added to the oil reservoir
- Fresh, new unleaded gas has been added to the gas tank
- If it won't start using the key switch, try starting it manually
- Make sure the battery and/or fuse are installed (if applicable for your model)
If you've checked all that and it still won't start, there are many other factors that could potentially prevent your mower from starting (even though they are highly unlikely on a brand new mower).
- The spark plug boot is attached to the spark plug
- The correct oil (SAE 30) has been added to the oil reservoir
- Fresh, new unleaded gas has been added to the gas tank
- If it won't start using the key switch, try starting it manually
- Make sure the battery and/or fuse are installed (if applicable for your model)
If you've checked all that and it still won't start, there are many other factors that could potentially prevent your mower from starting (even though they are highly unlikely on a brand new mower).
One possible cause of the mower not starting at all is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start. (You can find instructions for replacing the spark plug here.)
If neither of those solutions helps, try spraying some starting fluid into the carburetor (with the air filter removed and the mower off) then put the filter back on and try starting the mower -- if it starts then dies, there is probably a blockage in the carb, or a problem with the fuel.
If nothing else has worked, attach a spark plug tester to your spark plug to see if the plug is getting electricity. If it's not, there's a problem before the spark plug, with one of the internal electrical components.
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
Related Toro 20332 Manual Pages
Operation Manual - Page 1
... Proposition 65 Warning The engine exhaust from an Authorized Service Dealer or at www.Toro.com. Model and serial number plate
Write the product model and serial numbers in... for cutting brush or for agricultural uses. Introduction
Model No. Figure 2 1.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up Model...
Operation Manual - Page 2
... mow it.
• Mow across the face of lawn mower will be ordered through the engine manufacturer. You could cause...8226; Never direct discharged material toward the operator. If you start to meet safety, emission, and operating requirements, the actual ... responsible adults, who are a major factor related to potential personal injury hazards. Stop the blade when crossing gravel surfaces.
&#...
Operation Manual - Page 3
... trailer bed with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to operate the machine.
• Use ...8226; Never tamper with the rim of Gasoline
To avoid personal injury or property damage, use a nozzle lock-open flame...contact with safety devices. Allow engine to prevent unintended starting .
• Never make any fuel-soaked debris. ...
Operation Manual - Page 5
Before starting the engine, fill the engine with a clean cloth.
4.
Move the handle to a level surface. 2. Install and...Remove and discard the protective plastic sheet that you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with oil in the engine, but it out (Figure 4). Insert the dipstick fully into the oil fill tube, wait...
Operation Manual - Page 6
.... Install the dipstick into the oil fill tube securely. Refer to Charging the Battery in the Maintenance section. Blade control bar
9. Ignition key (electric-start models only)
6 Bag-on the dipstick reads Full.
6. Side discharge chute
3. Handle knob (2)
6. Drain the excess oil until the oil level on -demand lever
5.
Handle
8. ...
Operation Manual - Page 7
...you and others.
• To prevent a static charge from a major name-brand service station (Figure 7). Move the mower to the fuel all season, mixing it with fresh unleaded regular gasoline (having ...87 or higher) from igniting the gasoline, place the container and/or mower directly on the dipstick. Important: To reduce starting problems, add fuel stabilizer to a level surface. 2. Do not mix...
Operation Manual - Page 8
... muffler. Set the front wheels to the same height as desired.
Note: When you pull the recoil start handle (Figure 12). Raise the mower
Figure 9 2. and 4 inches (102 mm).
8
Figure 11
Starting the Engine
1. To lower the mower, move the front cutting height levers rearward and the rear cutting height levers forward. Lower the...
Operation Manual - Page 9
... on -demand lever is in serious personal injury or death to disengage the wheel drive.
If the bag-on the mower, remove it is damaged, install a new Toro replacement bag.
Note: If the mower does not start models only).
Raise and hold your sides, and the mower will automatically keep pace with your hands on the upper handle...
Operation Manual - Page 10
... debris to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling the grass and leaf...bystander's direction and result in serious personal injury. Rear deflector
Figure 14 3.
Bag-on the handle (Figure 14).
3.
contacting the blade can result in serious personal injury or death to another. lever...
Operation Manual - Page 11
If the grass bag is on the mower and the bag-on-demand lever is sharp; Figure 17
Removing the Side Discharge Chute
To...to Operating the Bag-on-Demand Lever).
WARNING
The blade is in serious personal injury. contacting the blade can result in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating position. Installing the Side ...
Operation Manual - Page 12
...new blade before the cutting season begins.
• Replace the blade when necessary with a Toro replacement blade. Cutting Leaves
• After cutting the lawn, ensure that the blade could hit.
• Avoid striking solid objects with each pass.
- WARNING
Wet grass or leaves can cause the mower... If the mower strikes an object or starts to clump on your mowing speed if the mower does not ...
Operation Manual - Page 13
... tip the mower onto its side, with a hand pump; Gasoline is flammable, explosive and can cause personal injury. never siphon. If you must
13
Preparing for 24 hours (electric-start models only).....shoptoro.com. Note: Replacement parts are available from an Authorized Service Dealer (go to www.toro.com to stop.
2.
Stop the engine and wait for any maintenance procedure. Figure 18
3....
Operation Manual - Page 14
.... Install the dipstick into the oil fill tube, then
remove the dipstick. 10. Tip the mower onto its side with the air filter up to drain the used oil properly at the Full ... pour a small amount of oil in
the crankcase. 7. Note: If the oil level is at a local recycling center.
14 Wait 3 minutes for the oil to Preparing for Maintenance. 3. Important: Do not overfill the crankcase...
Operation Manual - Page 15
...
15 Charging the Battery
Service Interval: Every 25 hours
Electric-start models only
If the battery does not charge or the engine....
1. Wash hands after handling. Connect the charger to the mower wire harness
located below the ignition key (Figure 22).
•...wall outlet. Note: When the battery no longer holds a charge, recycle or dispose of the lead-acid battery according to cause cancer and ...
Operation Manual - Page 16
...The blade is damaged or cracked, replace it . Refer to point toward the mower housing. 6.
While holding the blade with the screw that you removed in ... Install the battery compartment with a block of gasoline. 1 2 3
1. Replace the fuse in serious personal injury.
Install the new blade and all mounting hardware (Figure 25).
5.
contacting the blade can result in the fuse holder (...
Operation Manual - Page 17
... water on -demand in an enclosed area.
17 Start the engine and run it for the purpose of adjustment, adjust the self-propel drive cable. 1. Tighten the nut on the mower housing (Figure 28).
For best results, clean the mower soon after you install a new self-propel cable or if the self-propel drive...
Operation Manual - Page 18
... Figure 29. When you fold the handle.
Recycle it stops. If you must charge the battery every 90 days (electric-start model only). 2. Run the mower until it according to run until the engine stops from running out of hard starting. Remove the ignition key (electric-start models only). Connect the wire to prevent cylinder...
Operation Manual - Page 20
...
A 2-Year Full Warranty (45 Day Limited Warranty for Commercial Use)
The Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler® 20 in Mulcher/Bagger
Walk Power Mowers
Conditions and Products Covered
The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly promise to...
Parts Catalog - Page 1
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Original Instructions (EN)
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA. All Rights Reserved
Similar Questions
Brand New Toro Wont Start Model 20334
(Posted by GaJe 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
My Brand New Toro 22 In Recycler Lawn Mower Will Not Start
(Posted by terjeanw 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 12 years ago)