Stihl SG 20 Support Question
Stihl SG 20 Support Question
Find answers below for this question about Stihl SG 20.Need a Stihl SG 20 manual? We have 1 online manual for this item!
Question posted by woodwardrobin on May 31st, 2014
Stihl Sg 20 Backpack Sprayer
I am looking for a replacement wand for the SG 20 Stihl sprayer. what can i use? where can i get it?
Current Answers
Related Stihl SG 20 Manual Pages
Product Instruction Manual - Page 3
© ANDREAS STIHL AG & Co. KG, 2009 0458-408-8621-A. Symbols in different ways: N A ...a step or procedure that require your special attention. Such paragraphs are supported by illustrations.
Original Instruction Manual
Contents
Guide to Using this Manual
1
Safety Precautions and Working
Techniques
2
Assembling the Unit
7
Harness
8
Filling the Tank
9
Spraying
9
Storing ...
Product Instruction Manual - Page 4
...
STIHL's philosophy is to reduce the risk of personal injury. Therefore, some changes, modifications and improvements may not be observed to continually improve all applicable federal, state and local safety regulations, standards and ordinances. Safety Precautions and Working Techniques
Because the backpack sprayer is important that anyone using the chemical and before mixing or using...
Product Instruction Manual - Page 5
... or an impermeable work , check with chemical agents, the operator should wear proper protective apparel when filling, using and cleaning the backpack sprayer. Always follow all STIHL backpack sprayers.
For some chemicals it .
Breathing toxic chemicals can be used . SG 20
3 See the appropriate section of your eyes you are spraying overhead or if the spray may differ from...
Product Instruction Manual - Page 6
...herbicides with the specific STIHL model are authorized. Wrong mixtures can be used under the supervision of any other method than those in your STIHL servicing dealer.
Always ...
SG 20 Poison" are caustic, corrosive or poisonous should be used . Each category will have it checked by your sprayer. Warning! Clean all chemical spills immediately. English
THE BACKPACK SPRAYER
For...
Product Instruction Manual - Page 7
... backflow, i.e.
Always inspect your backpack sprayer in a safe place.
Do not use , store chemicals in wellventilated areas, outdoors.
To fill the backpack sprayer, place it to prevent damage to... When filled to reduce the risk of the hose is used up at this time. SG 20
5 liquids with the sprayer operation, follow normal operating procedures. See the Specifications for...
Product Instruction Manual - Page 8
... .
Warning! Use good work against the wind.
If you or bystanders. Operating instructions
Warning! English During Operation Holding and Controlling the Backpack Sprayer
The backpack sprayer is operated with... where possible.
Pay attention to wear a respirator approved by spray formula.
6
SG 20
Use caution when bending, leaning or walking.
Warning! In order to proper usage....
Product Instruction Manual - Page 9
... Have such work not described in this manual. SG 20
7
Warning! Maintenance, Repair and Storing
Warning!
Use only identical STIHL replacement parts for maintenance and repair. Please refer to cleaning or servicing the sprayer.
Danger! To reduce the risk of electrocution, never operate this backpack sprayer in the vicinity of non-STIHL parts may be in personal injury or...
Product Instruction Manual - Page 10
... tabs of the straps downward.
N Pull the ends of the sliding adjusters.
8
SG 20 English
Harness
Threading the harness straps
Tightening the harness straps
N Mount the hand lever (4) with clean water to check the sprayer for leaks -
do a test run with the screws (5). After completing assembly, do not use the sprayer if it is leaking.
Product Instruction Manual - Page 11
... 10 strokes are required to build up with grease and in the cap (3) must always be well lubricated with thoroughly mixed spray solution -
SG 20
9
N Gasket (2) in good condition.
N Stand the sprayer on your back. Filling the Tank
Spraying
Before Spraying
English
N Fit the strainer (1). do not overfill (no further than max. arrow).
Product Instruction Manual - Page 12
... in the spray gun.
Do not store the sprayer under pressure. N Pull the trigger.
N Engage the U-clip (3) in a well-ventilated location. N Rinse the tank with spray solution in the tank. N Rotate the nozzle (2) to maintain a uniform spray pressure. the trigger is locked.
10
SG 20 N Operate the hand lever 3 to 6 times per minute...
Product Instruction Manual - Page 13
... monthly every 12 months if problem if damaged if required
English
X X X X X
SG 20
11
Complete machine
Visual inspection (condition, leaks) Clean
Filter in spray gun
Clean
Tank, ...oil
Gasket in cap
Lubricate with grease
Vent in cap
Clean
All accessible screws and nuts
Retighten
Safety labels
Replace
X
X
X
X
X
X
X
X
X
X
before starting work after finishing work area, etc...
Product Instruction Manual - Page 14
... 13 14
15
12
408BA018 KN
1 Backplate 2 Pressure Vessel 3 Harness 4 Spray Gun 5 Filter 6 Spray Wand 7 Nozzle Holder with Nozzle 8 Cap 9 Vent 10 Gasket 11 Strainer 12 Container 13 Pump 14 Retainer 15 ... Gun.
Pressure Vessel. Starts and stops spray jet.
5. SG 20 For carrying the sprayer.
4. Stores pressure produced by pump and the pressurized spray solution.
3. Helps prevent impurities entering ...
Product Instruction Manual - Page 15
...min (1000 cm3/min) a = 31 in (80 cm)
b = 39 in use.
15. Feeds spray solution to avoid vacuum.
10. Accommodates the nozzle. Helps prevent ...STIHL dealer for information regarding special accessories that may be available for producing spray pressure. Hand Lever. SG 20
13 Atomizes the spray solution.
8. Closes the spray solution container.
9. Pump lever for your product.
6. Spray Wand...
Similar Questions
Hard To Pump Stihl Sg 20
My backpack spayer is very hard to pump. The pump cylinder is clean and there is no corrosion. I hav...
My backpack spayer is very hard to pump. The pump cylinder is clean and there is no corrosion. I hav...
(Posted by jcheaverli 6 months ago)
My Sg 20 Has A Broken Black Plastic Piece On Top Of The Pump Cylinder. Can I Buy
(Posted by worngrazers0g 1 year ago)
Stihl Sg 20 Parts
where can I purchase a pressure vessel for my sg 20
where can I purchase a pressure vessel for my sg 20
(Posted by Anonymous-162631 7 years ago)
Stihl Sr 450 Backpack Sprayer Valve Lever
Stihl sr 450 backpack sprayer- liquid runs out as if valve lever is open.
Stihl sr 450 backpack sprayer- liquid runs out as if valve lever is open.
(Posted by lvlwebsite 7 years ago)