2015 Polaris Sportsman ETX Support Question
2015 Polaris Sportsman ETX Support Question
Find answers below for this question about 2015 Polaris Sportsman ETX.Need a 2015 Polaris Sportsman ETX manual? We have 1 online manual for this item!
Question posted by doby607 on February 20th, 2022
Bike Wants To Kill Whe Throttling,idles Perfect,no Lights,codes
bike will start and idle with no problem, will sputter when trying to throttle, no codes, engine light will show when bike sputters
Current Answers
Answer #1: Posted by SonuKumar on February 21st, 2022 6:51 AM
SonuKumar
Member since:
May 9th, 2021 Points: 16,621,300
Member since:
May 9th, 2021 Points: 16,621,300
https://www.justanswer.com/motorcycle/hl1jv-2015-polaris-etx-will-idle-when-give.html
How do I adjust my Polaris Sportsman throttle?
Adjust throttle cable freeplay at the handlebar.
Locate the throttle cable. adjuster at the handlebar.
Squeeze the end of the rub- ber boot and slide it far. enough to expose the end of. ...
Loosen the adjuster lock nut.
Rotate the boot to turn the. adjuster until 1/16" to 1/8" ...
Tighten the lock nut.
Squeeze the end of the rub-
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Manual Pages
Owners Manual - Page 21
Do not make sudden turns or stops, and do not make sudden throttle changes. • Wet brakes may cause changes in the owner's manual for carrying cargo or pulling a trailer. Apply them lightly several times while driving slowly. Improper Cargo Loading
Overloading the ATV or carrying/towing cargo improperly may have reduced stopping...
Owners Manual - Page 22
... and loss of the vehicle. ATV operators assume all risk associated with highway-approved lights. Use caution and drive at reduced speeds in your entire route. After any other...dealer inspect the entire machine for possible damage, including (but not limited to) brakes, throttle and steering systems.
Physical Skills
Safe operation of this rider-active vehicle requires good judgement and...
Owners Manual - Page 24
... age of 16 increases your chance of control. SAFETY
Safety Labels and Locations
Discretionary Warning
WARNING • Never operate this ATV on hilly terrain, use throttle and brakes gradually, and shift weight uphill. • REVERSE operation can be dangerous even at low speeds. To prevent loss of control, avoid sudden braking...
Owners Manual - Page 25
...Warning
Clutch Cover Warning
WARNING • Moving parts hazard under belt-clutch guard. Always apply throttle gradually while in reverse.
7175486
4X4 (AWD) Warning (ETX Model)
WARNING Do not ...
23 Do not activate override while throttle is engaged. To prevent serious injury, do not operate vehicle with guard removed. • Do not modify engine or clutch. This may result causing...
Owners Manual - Page 26
FEATURES AND CONTROLS
Switches
Headlight Switch
Engine Stop Switch Mode/Reverse Override Switch
4X4 Switch Main Key Switch
Mode/Reverse Override Switch This vehicle is in serious injury or death. Pressing the override button while the throttle is also used to toggle through the modes of control, which may result in reverse.
4X4...
Owners Manual - Page 27
.... The key must be in the ON position and the engine stop switch must be in the RUN position to start or run when the switch is off and to change the lights from high beam to low beam. FEATURES AND CONTROLS
Switches
Engine Stop Switch Move the stop switch either left or right...
Owners Manual - Page 28
... position when the operator releases the throttle lever, engine speed will be limited to idle when the lever is spring loaded. Engine speed returns to idle speed.
2x4
26
Always contact your dealer for free movement and return before operating the vehicle. Always check the lever for service before starting the engine. Engine speed and vehicle movement are...
Owners Manual - Page 33
.... Do not use fuel with a minimum pump octane number of 87 = (R + M/2) octane. Fuel Tank Cap
31 EPS remains engaged whether the vehicle is moving or idle.
Use either leaded or unleaded gasoline with ethanol content greater than 10 percent, such as E-85 fuel. Refuel on a level surface. See page 35 for...
Owners Manual - Page 45
...Display Code Definitions
Diagnostic Codes
Component Throttle Position Sensor Engine Temperature Sensor Condition Voltage Too High Voltage Too Low Voltage Too High Voltage Too Low Temperature Too High Engine ... Pump Driver Circuit Fan Relay Driver Circuit Idle Air Control Starter Enable Circuit All Wheel Drive Control System Power Throttle Safety Signal
Active Descent Control System
*Assumes unipolar...
Owners Manual - Page 47
... idle. 5. Fill the fuel tank with vehicle operation and handling. 4. Break in the clutches and belt by operating at 25 hours. 8. OPERATION
Break-In Period
Engine and Drivetrain Break-in period as recommended. Add oil if necessary to familiarize yourself with gasoline. Vary the throttle positions. Do not operate at first. Pull only light...
Owners Manual - Page 50
... 116 24 25 96 25 98 101 8 63-74
Coolant hoses (if applicable) Inspect for leaks Throttle Ensure proper operation Indicator lights/switches Engine stop switch Air filter, pre-filter Air box sediment tube Headlamp Brake light/taillight Riding gear Winch (if equipped) Ensure operation Ensure proper operation Inspect, clean Drain deposits whenever visible...
Owners Manual - Page 59
...slowly. Do not make sudden throttle changes.
57
If this is not thoroughly inspected after operating in water, restarting can result in serious engine damage. If it's unavoidable...engine. Do not make sudden turns or stops. The following areas need special attention: engine oil, transmission oil, demand drive fluid, rear gearcase oil, and all grease fittings. Apply them lightly...
Owners Manual - Page 61
Apply the brakes lightly for obstacles or people behind the vehicle. 2. Avoid turning at wide open the throttle suddenly. 7. Always check for stopping. 5. Do not operate at sharp angles. 6. Never open throttle. Operate the throttle just enough to build in the exhaust, resulting in engine popping and/or engine damage.
59 OPERATION
Driving in Reverse
Follow these...
Owners Manual - Page 105
... fuel. General causes of non-recommended oil or incorrect throttle body adjustments.
103 MAINTENANCE
Spark Plugs
Spark Plug Inspection
Normal.... This indicates the proper type and heat range for the engine and the service. A damp oil film covers the firing end... Spark Plug The wet fouled insulator tip is gray, tan or light brown. A white insulator tip indicates overheating, caused by use of...
Owners Manual - Page 107
... 4. 7.
Start the engine. 4. Remove the arrester cleanout plug from the bottom of the exhaust, cover or plug the exhaust outlet. Quickly squeeze and release Clean-Out Plug the throttle lever several ... the engine in the muffler, elevate the rear of the vehicle while purging. Lightly tap on the spark arrester while the system is hot. Outlet 3. Stop the engine. MAINTENANCE...
Owners Manual - Page 110
... PARK. 4. Allow the engine RPM to settle to idle speed, then shift the transmission to your dealer for 10-15 seconds to drain completely. Test for more than 10 seconds. 5. Take the vehicle to the lowest available range. 6. Remove the drain plug. Reinstall the drain plug. 3. Apply varying throttle for service as soon...
Owners Manual - Page 118
... slide it far enough to its original position. If the engine idle speed is preset by the manufacturer. Loosen the adjuster lock nut. 4. Boot 5.
While adjusting freeplay, be sure to 1/8" (1.5-3 mm) of the inline cable adjuster. 3. Lock Nut
Adjuster
116 MAINTENANCE
Throttle Body/Idle RPM
Idle RPM is not satisfactory, please see your POLARIS dealer...
Owners Manual - Page 134
... items:
Wheels and tires Suspension components Brake components Seat components Clutches and components Steering components Batteries Light bulbs/Sealed beam lamps Filters Lubricants Bushings Finished and unfinished surfaces Carburetor/Throttle body components Engine components Drive belts Hydraulic components and fluids Circuit breakers/Fuses Electronic components Spark plugs Sealants Coolants...
Owners Manual - Page 144
...
Gasoline Handling ...11 Gauge, Code Definitions ...42-43 Gauge, Digital/Analog...34-41 Gear Selector ...32 Gloves ...9
N
Noise Emission Control System ...75
O
Oil Engine ...81-84 Transmission...85-86... System...106-108
I
Idle RPM Adjustment ...116 Immersion Maintenance ...104 Indicator Lamps ...35 Instrument Cluster ...34-43
K
Key Switch...25 K-Turn ...56
L
Lights ...98-101 Headlight Housing...
Owners Manual - Page 145
... Shock ...115 Starting the Engine ...49 Steering Assembly ...92 Storage ...117-122 Storage Tips ...120-122 Switches 4X4 Switch (if equipped) ...24, 33 Engine Stop Switch ...25 Headlight Switch ...25 Main Key Switch ...25 Mode/Reverse Override Switch . . 24
T
Taillight Lamp Replacement ...101 Throttle Body Adjustment ...116 Throttle Cable Freeplay Adjustment 116 Throttle Lever ...26 Tires...
Similar Questions
My 2016 Polaris Ranger Crew Diesel Want Go Over 16 Mph?
(Posted by Teekiernan 1 year ago)
Throttle Position Sensor Replacement On 2016 Polaris Sportsman 450 H.o.
I'm trying to locate where the throttle position sensor on the Polaris sportsman 450 HO is and for t...
I'm trying to locate where the throttle position sensor on the Polaris sportsman 450 HO is and for t...
(Posted by Youhozz 2 years ago)