Home » LiftMaster » Garage Door Openers » LiftMaster SW490

LiftMaster SW490 Support Question

Find answers below for this question about LiftMaster SW490.
Need a LiftMaster SW490 manual? We have 2 online manuals for this item!

LiftMaster Overview Questions Manuals Reviews Videos Research

Question posted by Ocgdoors on April 4th, 2014

71-416-7nh

How do you install the 71-416-7nh in the sw490

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related LiftMaster SW490 Manual Pages

SW490 GL BOARD Manual - Page 1

... PASSAGE GATE USE. MODEL SW470 MEDIUM DUTY SWING GATE OPERATOR GLCONTROLLER BOARD MODEL SW490 HEAVY DUTY SWING GATE OPERATOR 2 YEAR WARRANTY Serial located on electrical box cover) Installation Date INTENDED FOR PROFESSIONAL INSTALLATION ONLY. VISIT WWW.LIFTMASTER.COM TO LOCATE A PROFESSIONAL INSTALLING DEALER IN YOUR AREA. THIS MANUAL IS TO BE LEFT WITH THE...

SW490 GL BOARD Manual - Page 2

... for Swing and Ornamental Grill Type Gates 8 Warranty Sign Placement 8 INSTALLATION Post Mounting (SW470 9 Pad Mounting (SW470 10 Pad Mounting (SW490 11 Control Arm and Gate Bracket Installation (SW470 12 Control Arm Assembly (SW490 13-14 Manual Disconnect 14 WIRING AVERTISSEMENT Power Wiring Installation 15 On/Off Switch Power Wiring 16 Stop/Reset Button Control...

SW490 GL BOARD Manual - Page 3

....25" (61.6 cm) 20" (50.8 cm) 10" (25.4 cm) 14.25" (36.2 cm) 13.38" (34 cm) 13.63" (34.6 cm) 13" (33 cm) MODEL SW490 • 1/2 HP Motor Maximum Gate Weight - 750 lbs. (340.2 kg) Maximum Gate Width - 16 ft. (4.9 m) • 3/4 HP Motor Maximum Gate Weight - 900 lbs. (408.2 kg...

SW490 GL BOARD Manual - Page 4

... a home of one-to four single family dwellings, or a garage or parking area associated therewith. Below are intended for a control...motorized gate systems. UL325 requires that the installation must use on both the open and close directions of gate travel. ... The SW470 and SW490 are the six types of entrapment protection systems recognized by security personnel. The opener can be used ...

SW490 GL BOARD Manual - Page 11

...the gate. Secure the operator to 4" above grade Depth required by local codes or below frost line 11 Figure 2 SW490 GATE OPERATOR INSTALLATION TABLE GATE LENGTH (FEET) 8-9 10-11 12-13 14-15 16-17 18-19 20-21 22 P DIMENSION IN...P Gate 5" Output Shaft Fence 1/2" Redhead (4 Required) 8" Operator 28" Concrete Pad 18" x 34" min. Pour concrete pad. 5. INSTALLATION PAD MOUNTING (SW490) 1.

SW490 GL BOARD Manual - Page 12

... installation (Figure 1). 2. The extension arm should be prevented from opening . Attach the other end of the actuator arm to Fence Figure 3 Eccentric stop during installation ...Plate Installation Detail Hinge Pin Eccentric stop (operating position after adjustment). SW470 Perpendicular to the gate brackets (Figure 3). Be sure that the control arm and actuator are appropriate for SW490 2"...

SW490 GL BOARD Manual - Page 13

... the gate panel's length and referring to the gate installation table (Dimension B) on the operator so that the key is not to seal the open stop 's hole in the operator's cover. 3. Assemble... control arm extension. Figure 1 Close Stops Left hand installation Right hand installation SW490 Parallel to hold pipe firmly. Do not tighten until testing and all final adjustment have...

SW490 GL BOARD Manual - Page 14

...should swing freely. I N S TA L L AT I O N CONTROL ARM ASSEMBLY (SW490) continued Gate Hinge Open gate position 2" 34" Closed gate stop D Control arm hub assembly Output Shaft C 13...Inches) B Dimension (Inches) C Dimension (Inches) D Dimension (Inches) X Dimension (Inches) Y Dimension (Inches) SW490 Gate Installation Table 8-9 10-11 12-13 14-15 16-17 4.5 4.5 4.5 4.5 4.5 24 30 36 42 48 13...

SW490 GL BOARD Manual - Page 17

...for 30 seconds. 3. NEVER permit anyone to cross path of constant closure is not connected BEFORE installing the receiver. It must be set at the NORMAL mode (Figure 1). The receiver is PROHIBITED.... switch remotes. To erase all remote control codes: Press and hold the button on residential garage door openers because it can be used with up to 31 of any type 315 MHz remote control ...

SW490 GL BOARD Manual - Page 18

...close limit switch. Turn on the shaft. Gate should move during some steps. If gate does not open the open limit switch or an improper electrical connection may have been made. Turn off power. Rotate cam in... all set screw. 10. Be sure close direction. 5. Press OPEN button (if installed) or connect terminals 5 & 7 on J1 terminal strip. Limit cam should now be already actuating...

SW490 GL BOARD Manual - Page 19

... two screws holding the hall bracket to the frame. 2. MODEL SW470 Hall Effect Cable Mounting Screw (2) AVERTISSEMENT ATTENTION Hall Effect Bracket Pulley Magnet Pulley MODEL SW490 Mounting Screw (2) Mounting Bracket Hall Effect Cable ADVERTENCIA PRECAPMuUalglenyeCt IÓN Pulley Hall Effect Magnet 19 These operators use an internal entrapment protector system. b. .020" (.051...

SW490 GL BOARD Manual - Page 32

... 76-G0564 SEE NOTE 4 (Y) 230 VOLT MOTOR CONNECTION (Y) RPM - LOOP OBS. SUPPLY RPM GND RADIO COMMAND J2 PLUG SHADOW R3 +24 Vdc CLOSE STOP SOFT OPEN HARD OPEN INT. SINGLE PHASE WIRING DIAGRAM (SW490) 1 PHASE POWER IN (GN) GROUND (W) (GN) GL CONTROL BOARD 24 Vac - IN 24 Vac -COMMON J2 PLUG (GY) (Y) SOFT...

SW490 GL BOARD Manual - Page 33

... R 2 208/230V MOTOR O/L NOTE 4 575V MOTOR "A" LIMIT CONTACTOR A RPM - SUPPLY RPM GND RADIO COMMAND SHADOW +24 Vdc CLOSE STOP SOFT OPEN HARD OPEN INT. GL FIELD WIRING & ADJUSTMENTS MODEL TYPES: HORSEPOWER: VOLTAGE/PHASE: SW490 (HSW) 1/2, 3/4 & 1 208,230,460 & 575V - 3 PHASE ONLY DRAWING NUMBER: 01-G1979-3 845 Larch Avenue, Elmhurst, IL 60125 DATE: 7/29...

SW490 GL BOARD Manual - Page 37

... Belt 28" 17-2002 Pulley, 2", Bore 5/8", Key 3/16" G172701 Pulley, 7" 19-2075 Chain, #50-75 19-9024 Master Link, #50 G232016 Limit Switch N.C. REPAIR PARTS - SW490 Refer to page 40 for your operator, certain components may not be added or removed from these lists. Complete Electrical Panel Replacement Kits To order...

SW490 GL BOARD Manual - Page 38

SW490 A5 A1 A4 A3 A5 A2 D10 A7 D11 D5 D21 D20 D1 D12 D18 D12 D17 D4 D3 6 3 D14 D15 D6 D19 D13 8 1 A6 5 2 4 D7 D16 D2 E5 E3 D8 D9 F E1 7 E4 E2 38 ILLUSTRATED PARTS -

SW490 GL BOARD Manual - Page 39

... SW490-33-23, SW490-33-43, SW490-50-23, SW490-50-43 SW490-75-23, SW490-75-43 SW490-100-23, SW490-100-43 All 1PH All 3PH All 115V 1PH All 230V 1PH SW490-33-21, SW490-50-21, SW490-75-21 SW490-33-11 SW490-50-11, SW490-100-21 SW490-75-11 SW490-100-11 SW490-100-53-G, SW490-75-53-G SW490-100-43-G SW490-100-23-G, SW490...

SW490 S3 BOARD Manual - Page 4

...operator for use in an industrial location such as gated communities, apartment complexes, hotels, garages, retail stores, or other buildings servicing the general public. COMMERCIAL/GENERAL ACCESS VEHICULAR ...16 82-HN75-28 82-NH38-06 84-RH-75 85-LS-38 Table 1: Parts Supplied SW490 DESCRIPTION STOP BUTTON ARM CHANNEL EXTENSION ARM HOLDER GATE BRACKET EXTENSION ARM 39" GALVANIZED STEEL PIPE...

SW490 S3 BOARD Manual - Page 14

... control arm on the operator in keyway. Do not tighten until final adjustment is inserted properly in the positions appropriate for degree of gate opening required. 14 Installation Control Arm Assembly 1 SW490: Set the control arm stops on operator with set screws in Figure 9. Insert (2) hex head set screw. Doc 01-G0665 Rev...

SW490 S3 BOARD Manual - Page 24

...shout off at fully opened or closed position. Limit nuts not properly adjusted. Check limit switches. The motor is pressed. Gate closes when OPEN button is connected ...type. Inspect control station and all field wiring. 24 Troubleshooting Troubleshooting A properly installed SW470 or SW490 operator will operate for many years with a minimum or service maintenance. Should electrical...

SW490 S3 BOARD Manual - Page 28

...2 LIM. Parts having one or more X in the part no. Doc 01-G0665 Rev C 28 SW490 Parts List and Drawing SW490 Parts List PART NO. 02-401-SP (N) 03-8024 03-ABDIN-4 06-2025-T 08-2001 10-2005...25 80-575 8121CGS00600 82-HN75-28 82-PX06-26 82-PX08-10T 82-PX10-04 85-FW-06 QTY. SWITCH, AUX.OPEN/CLOSE 1 DPST ON/OFF TAG 20A 125277VAC 1 SWITCH BOX 2 ACTUATOR ARM STOP 4 SPACER 2 6-32 HEX NYLON STANDOFF...