Invacare RPL450-2 Support Question
Invacare RPL450-2 Support Question
Find answers below for this question about Invacare RPL450-2.Need a Invacare RPL450-2 manual? We have 1 online manual for this item!
Question posted by mclarney on February 6th, 2013
Have 450-2 And Base Doesn't Work Tryed New Battery And New Controler Still Nothi
The person who posted this question about this Invacare product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Invacare RPL450-2 Manual Pages
Owners Manual - Page 1
Invacare® Reliant™ 450 RPL450-2 Invacare® Reliant 600 RPL600-2
Electric Portable Patient Lift
User Manual
EN
This manual MUST be given to the user of the product. BEFORE using this product, read this manual and save for future reference.
Owners Manual - Page 3
...: This manual MUST be given to the Base 18 Mounting the Battery Charger 19
6 OPERATION
20
Introduction 20 Using the Pendant Buttons 20
Raising/Lowering the Boom 20 Opening/Closing the Legs 20 Activating a Mechanical Emergency Release 21 Performing an Emergency Stop 22 Charging the Battery 23
7 LIFTING THE PATIENT
24
Introduction 24...
Owners Manual - Page 4
...Actuator 36 Checking and Tightening Mast Pivot Bolt 37 Replacing the Swivel Bar 38 Maintaining the Base Adjustment 39 Replacing Casters/Forks 40
Replacing Rear Casters 40 Replacing Front Casters 41 Replacing Forks... Keypad Functions 46
Weighing the Patient 47 Replacing the Battery 48
Calibrating the Reliant Scale 49 Troubleshooting 50
Display Codes 50
Electric Portable Patient Lift
4
...
Owners Manual - Page 8
... when mounting battery on the evaluation of the swivel bar and the patient. Operating the Lift
ƽ
WARNING Although Invacare recommends that two assistants be aware of the position of the health care professional for the RPL600-2 is 450 lbs. ALWAYS keep hands and fingers clear of lift. Pinch points also exist at base of...
Owners Manual - Page 9
...a chair, bed or any stationary object. Lifting the Patient
ƽ
WARNING
When using an adjustable base lift, the legs MUST be inside of plastic back incontinence pad or seating cushion between patient and ... NOT use with patient suspended in a sling attached to the lift, DO NOT roll caster base over uneven surfaces that could cause the patient lift to connect both sides of the sling during...
Owners Manual - Page 13
ELECTRIC LOW PROFILE RPL450-2
74 inches 24 inches
3 Styles 450 lbs 136 lbs 109 lbs
41.0 inches 26.5 inches 4.5 inches 48.0...
4 TECHNICAL DATA
450 LB. Lifts per charge
1 Year
600 LB. MIN.: Base Width OPEN: Base Width CLOSED: Base Height (Clearance): Base Length: Caster Size (FRONT/REAR): Sling Options: Weight Capacity: Weight IN Carton: Weight OUT of Carton: Battery: Charger Input: Charger...
Owners Manual - Page 14
...
DUTY W/O DUTY W/
COMMODE COMMODE
R121
R140*
R141*
L
N/A
N/A
36
45
45
N/A
N/A
7
37
55
55
N/A
N/A
13
N/A
N/A
N/A
450
600
600
4.3 Reliant Scale RLS6
Weight Range: Resolution: Display: Automatic Power Down: Size: Weight: Power: Battery Life: Temperature Range:
Up to 600 Lbs. (272.7 Kg) +/- 0.2 Lbs (.1 Kg) Liquid Crystal Digital Two (2) minutes 5-3/4 L X 3-5/8 W X 4 H .55...
Owners Manual - Page 15
...
Electric Portable Patient Lift The plastic wrap will be removed in the assembly of all parts for safe functional operation.
5.2 Unpacking the Patient Lift 1. The base legs, mast, boom assembly and the swivel bar are manufactured to specifications that secures the boom to the mast. DO NOT remove plastic wrap at...
Owners Manual - Page 16
...bolt with nut.
Each time the mast is removed and returned to the base, the mast MUST be removed from the base for storage or transporting. Remove the shoulder bolt, nut and washer, that ... position and place the mast into the
U-shaped cut -out of the base. 4.
Position the mast in the U-shape cut -out of the base. 3. If locking-type casters are on the patient lift, lock them....
Owners Manual - Page 18
...
5.5 Installing the Leg Actuator to the upright position. 3. D. Position leg actuator between mast brackets. C. SIDE VIEW OF PATIENT LIFT
Pivot
Base Leg
Bracket
%
Hitch Pin
DETAIL "B"
Hitch Pin
Boom Assembly Battery
Control Box
Mast Bracket
Pin Leg Actuator
Pin
Boom Actuator
Mast
Leg Actuator Slot in leg actuator over the pivot bracket. Otherwise...
Owners Manual - Page 20
... legs of the lift to maneuver the lift under the bed, return the legs of the base for optimum stability and safety. To close the legs of the lift to the maximum open...patient. Thoroughly read the instructions in the maximum open button. The pendant is based on the evaluation of the health care professional for all lifting preparation and transferring to lower the boom and the patient...
Owners Manual - Page 24
...;
WARNING
The legs of the lift must be used for optimum stability and safety. however, our equipment will permit proper operation by one assistant is based on the evaluation of the health care professional for easy attachment of the lift to the maximum open the legs of the patient lift to maximum.
2.
Owners Manual - Page 26
... patient back onto the stationary surface and correct this problem otherwise, injury or damage may occur.
For this procedure, refer to FIGURE 7.1 on the base of hte patient lift.
The lower center of gravity provides stability making the patient feel more secure and the lift easier to make sure...
Owners Manual - Page 28
... patient and lift the patient off the stationary surface and before the patient is based on the evaluation of the patient lift are NOT properly in the maximum open ... all lifting preparation and transferring to/from a bed or chair.
When the legs of the health care professional for optimum stability and safety. however, our equipment will permit proper operation by one assistant...
Owners Manual - Page 32
... Patient Lift
32
Part No. 1145810 Mast/Base joint loose. Refer to Replacing the Boom Actuator on page 40.
Refer to Charging the Battery on
box. Unusual noise from pivots. and...of the boom Refer to the control box.
open when button is too high.
Refer to Charging the Battery on page 23.
Refer to control Replace the battery pack. Contact your Dealer. Boom...
Owners Manual - Page 33
... MAINTENANCE
IN-HOME INSPECT EVERY SIX (6) MONTHS
X X X X X X
X X X
Part No. 1145810
33
Electric Portable Patient Lift THE MAST Mast MUST be securely assembled to each new user.
Base opens/closes with ease. Inspect and clear wheels of the lift. 10 Maintenance
10.1 Maintenance Safety Inspection Checklist
For individual home use, a full inspection is...
Owners Manual - Page 34
... boot. ACTUATOR ASSEMBLY Inspect hardware on mast, boom and base. Check for wear. 10 MAINTENANCE
ITEM
THE BOOM Check all...for wear.
Inspect to ensure smooth quiet operation.
SLINGS AND HARDWARE CHECK ALL SLING ATTACHMENTS each time it is centered between the base legs. Inspect bolted joints of boom for wear. THE SWIVEL BAR Check the bolt / hooks for wear or deflection.
INITIALLY...
Owners Manual - Page 35
...or maintenance of the casters
2
once a year. Keep lift and slings clean and in good working order. A light grease (waterproof
auto lubricant) may be noted and reported to
extreme moist ... Boom Mounting Bracket 3. If any part of safe, efficient and satisfactory service with minimum care and maintenance.
Lubricate the following points:
1. Swivel Bar 2. from lift surface. Wipe all...
Owners Manual - Page 40
...;
The bushing will be loose and may occur. Examine and replace if
worn.
3. Line up the mounting holes in the new rear caster and the fork. 5. Locknut
Rear Caster Bushing
Base Fork
Bolt
Electric Portable Patient Lift
40
Part No. 1145810 Remove the bolt and locknut that floor area is clear of...
Owners Manual - Page 41
... lift on its side. 2.
Unscrew the existing fork from the lift. Replacing Front Casters
1. Line up the mounting holes in between.
Install the new fork onto the base. 5. Locknut
Front Casters
Washer
10 MAINTENANCE Base
Fork
Bolt
Part No. 1145810
41
Electric Portable Patient Lift Washer will fall out from between the two...
Similar Questions
Invacare Model: 5490ivc Serial # Ivc05d789426
The bed rises but the foot and head motor not working, it is clicking but not turning. Is it has a s...
The bed rises but the foot and head motor not working, it is clicking but not turning. Is it has a s...
(Posted by tokyhi 2 years ago)
Unit Will Only Display The Word Flo When Button Pushed
(Posted by ldyjack 2 years ago)
When Using The Concentrator Does Not Stop Beeping
What to do for stop beeping in red alert The machine seems to be working perfectly
What to do for stop beeping in red alert The machine seems to be working perfectly
(Posted by caluvillagran 9 years ago)
The Battery
I own one of these but the battery pack is broken. How much to purchase a new one?
I own one of these but the battery pack is broken. How much to purchase a new one?
(Posted by sagatiaej 10 years ago)
When You Try To Raise Unit You Hear A Clicking Replaced Battery
(Posted by mrobinson81923 11 years ago)