Husqvarna YTH22V46 Support Question
Husqvarna YTH22V46 Support Question
Find answers below for this question about Husqvarna YTH22V46.Need a Husqvarna YTH22V46 manual? We have 3 online manuals for this item!
Question posted by kcdane on December 1st, 2015
I Ha Be A Husqvarna Tractor M#yth22v46 The Interlock Switch Keeps Popping Up And
I have a husqvarna tractor m#yth22v46 and the interlock switch keeps popping up when the clutch rod hits it and I have to push switch in manually to start it and also cannot keep it running when I want to empty baskets
Current Answers
Answer #1: Posted by TechSupport101 on December 1st, 2015 5:59 AM
TechSupport101
Member since:
May 24th, 2013 Points: 12,171,305
Member since:
May 24th, 2013 Points: 12,171,305
Hi. Well, these switches are replaceable and yours may be defect (so it sounds) requiring a replacement.
Related Husqvarna YTH22V46 Manual Pages
Owners Manual - Page 2
...spillage before turning. • Never leave a running machine unattended. SLOPE OPERATION
Slopes are involved in ...tractor. Always keep the machine in reverse unless absolutely necessary. If the tires lose traction, disengage the blades and proceed slowly straight down a hill in the manual...to neutral and coast downhill. • Avoid starting, stopping, or turning on the slopes slow ...
Owners Manual - Page 7
...
NEUTRAL
HIGH
LOW
CHOKE
FAST
SLOW
IGNITION SWITCH
ENGINE OFF REVERSE OPERATION
SYSTEM (ROS)
ENGINE ON
ENGINE START
PARKING BRAKE
MOWER HEIGHT
MOWER LIFT
LIGHTS ON
FUEL BATTERY
REVERSE
FORWARD
CRUISE CONTROL
CLUTCH/BRAKE PEDAL
15
15
ATTACHMENT
ATTACHMENT
CLUTCH DISENGAGED CLUTCH ENGAGED
DANGER, KEEP HANDS AND FEET AWAY
KEEP AREA CLEAR
SLOPE HAZARDS
(SEE SAFETY RULES...
Owners Manual - Page 8
...Locks clutch/brake pedal into the brake position.
(D) THROTTLE/CHOKE CONTROL - Disengages transmission for 12 volt accessories.
(Z) AMMETER -
Used for braking the tractor and starting and stopping the engine.
(G) REVERSE OPERATION SYSTEM (ROS) "ON" POSITION - Used to your tractor.
(F) IGNITION SWITCH - Used for reverse movement of tractor.
(L) REVERSE DRIVE PEDAL - Used for pushing...
Owners Manual - Page 9
... ATTACHMENT
( ) ATTACHMENT
CLUTCH SWITCH
CLUTCH SWITCH
"DISENGAGED"
"ENGAGED"
Fig. 5
GROUND DRIVE -
• To stop tractor completely, as described above, and set parking brake before stopping may cause "browning" of any tractor can result in severe eye damage. HOW TO USE YOUR TRACTOR
TO SET PARKING BRAKE(See Fig. 4)
Your tractor is equipped with the engine running , any adjustments...
Owners Manual - Page 10
...HEIGHT" in this section of manual). • With mower ...lawns, mow often and after moderate growth. • For best cutting performance, grass over 3" during the cool season and to 4". OPERATION
TO MOVE FORWARD AND BACKWARD (See Fig. 7)
The direction and speed of movement is controlled by the forward and reverse drive pedals. • Start tractor...not running and the attachment clutch engaged ...
Owners Manual - Page 15
... for proper PSI). • Keep tires free of this manual). Tire sealant also prevents tire dry...start unless the brake pedal is fully depressed, and the attachment clutch control is in the Service and Adjustments section of gasoline, oil, or insect control
chemicals which is in the seat. NOTE: Protect your tractor. CHECK REVERSE OPERATION (ROS) SYSTEM • When the engine is running...
Owners Manual - Page 16
...with oil through oil fill dipstick tube.
Keep oil at the factory and fluid maintenance ...change if the tractor is hot. Every 100 hours of this manual. 7. DOCKING POSITION...drain extension to avoid possible engine damage from running or while the transmission is used above 32... overfill.
Check the crankcase oil level before starting in one year. CLEAN AIR SCREEN
TO ...
Owners Manual - Page 29
...9/32 x 7/8 x 16 Ga. Harness Pigtail Harness 12-Volt Pigtail Switch Reverse TT Pedal Control
NOTE: All component dimensions given in U.S. TRACTOR - - inches 1 inch = 25.4 mm
29 NO.
1 532...3/4 Box Battery Switch Interlock Push-In Harness Socket Light w/4152J Bulb Light Cable Battery Cable Starter Fuse Nut Keps Hex 1/4-20 unc Cable, Ground Switch, Seat Switch, Ign Key\Chain Switch Light / Reset...
Instruction Manual - Page 7
.... OPERATION
These symbols may appear on your tractor or in death, serious injury and/or property...SWITCH
ENGINE OFF REVERSE OPERATION
SYSTEM (ROS)
ENGINE ON
ENGINE START
PARKING BRAKE
MOWER HEIGHT
MOWER LIFT
LIGHTS ON FUEL BATTERY
REVERSE
FORWARD
CRUISE CONTROL
CLUTCH/BRAKE PEDAL
15
15
ATTACHMENT
ATTACHMENT
CLUTCH DISENGAGED CLUTCH ENGAGED
DANGER, KEEP HANDS AND FEET AWAY
KEEP...
Instruction Manual - Page 10
... the engine not running and the attachment clutch engaged will shut ...manual). • With mower in desired height of cut to disengage. Tighten securely. • Repeat for forward travel only.
Fig. 8
• Put attachment lift lever in most terrain conditions. For healthier and better looking lawns...") • Start mower blades by the operator to leave the seat with tractor on rough, ...
Instruction Manual - Page 15
...
Raise seat. CAUTION: Use only a replacement blade approved by the manufacturer of this manual). CHECK OPERATOR PRESENCE SYSTEM
• When the engine is running and the attachment clutch is hazardous, could damage your tractor and void your local parts dealer.
MAINTENANCE
TRACTOR
Always observe safety rules when performing any attempt by the operator to open...
Instruction Manual - Page 16
...Determine temperature range expected before starting in increased oil consumption when...• Unlock drain valve by pushing inward and turning counterclockwise.
•...and replace if necessary. Keep oil at the factory and...tractor is hot. Do not overfill.
Service air cleaner more frequently to slip from running...this manual.
• Use gauge on level surface.
• Oil will not run ...
Instruction Manual - Page 27
... IDLE THE LIGHTS WILL DIM. MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01
SCHEMATIC
SCH11
RED
A
AMMETER (OPTIONAL)
WHITE
S
B
M
A1 G
L A2
BATTERY
RED
FUSE
SOLENOID
BLACK
WHITE
STARTER
M
BLACK
CLUTCH/BRAKE (PEDAL UP)
BLACK
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
GRAY
REVERSE SWITCH (NOT IN REVERSE)
NOTE
YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM...
Instruction Manual - Page 29
Bulb Switch Interlock Cover Terminal Harness Pigtail Switch Reverse
NOTE: All component dimensions given in U.S. Socket Asm. TRACTOR - - Dash Screw Thd ...Switch Interlock Push-In Harness Socket Light w/4152J Bulb Light Cable Starter Fuse Nut Keps Hex 1/4-20 unc Cable, Ground Switch, Seat Switch, Ign Key/Chain Switch Light/Reset Harness Ign. inches 1 inch = 25.4 mm
29 MODEL NUMBER YTH22V46...
Instruction Manual - Page 33
...231 532 40 72-87
DESCRIPTION
Handle Parking Brake Bolt Spacer Retainer Washer Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Washer 25/32 x ... Pin Cotter 1/8 x 3/4 Retainer Clip Spring, Return, Clutch Rod Control Nut Push Latch Brake Parking Keeper V-Idler Spacer Axle
KEY PART NO. TRACTOR - - MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01
DRIVE
KEY...
Instruction Manual - Page 42
Keep Hands
Away
WHEELS AND TIRES
1
2
11 3
4
7
10
5
9
6
8
wheel_art_1-tex
KEY PART NO. DESCRIPTION
1 532 05 91-92 Cap Valve Tire 2 532 06 51-39... Decal, Engine H.P. 5 532 42 38-29 Decal, Customer Respons. 6 532 43 33-91 Decal, Replacement 7 532 17 05-63 Decal, Mower Warn. MODEL NUMBER YTH22V46 (96043010100), PRODUCT NO. 960 43 01-01
DECALS
2
56
2
9
3
1
7
4
12
KEY PART NO. NO...
Parts Manual - Page 3
... IDLE THE LIGHTS WILL DIM. MODEL NUMBER YTH22V46 (96043016200), PRODUCT NO. 960 43 01-62
SCHEMATIC
SCH11
RED
A
AMMETER (OPTIONAL)
WHITE
S
B
M
A1 G
L A2
BATTERY
RED
FUSE
SOLENOID
BLACK
WHITE
STARTER
M
BLACK
CLUTCH/BRAKE (PEDAL UP)
BLACK
ATTACHMENT CLUTCH (CLUTCH OFF) BLACK
GRAY
REVERSE SWITCH (NOT IN REVERSE)
NOTE
YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM...
Parts Manual - Page 5
...YTH22V46 (96043016200), PRODUCT NO. 960 43 01-62
ELECTRICAL
KEY PART NO. DESCRIPTION
1
532 16 34-65 Battery
2
874 76 04-12 Bolt Hex Head 1/4-20 x 3/4
8
532 41 41-26 Box Battery
16 532 17 61-38 Switch Interlock Push...Ga.
102 532 40 44-54 Harness Pigtail
105 532 40 75-68 Switch Reverse
NOTE: All component dimensions given in U.S. TRACTOR - - Dash
41 817 72 04-08 Screw Thd Cut 1/4-20 ...
Parts Manual - Page 9
...Spring 1" Pin Cotter 1/8 x 3/4 Retainer Clip Spring, Return, Clutch Rod Control Nut Push Latch Brake Parking
KEY
NO.
170 171 183 184 185 186 187...Link Clutch Ground Drive Bellcrank Ground Drive Keeper Bellcrank Ground Drive Washer 25/32 x 1-5/8 x 16 Ga. TRACTOR - - Spring, Brake Spring Return Cruise Rod, Brake Ring E Rod,...NUMBER YTH22V46 (96043016200), PRODUCT NO. 960 43 01-62
DRIVE
KEY PART NO.
Parts Manual - Page 18
... Rim Asm 8" Rear - - 532 14 43-34 Sealant, Tire (10 oz. MODEL NUMBER YTH22V46 (96043016200), PRODUCT NO. 960 43 01-62
DECALS
10
4
2
56
1 2
3
9...Tube)
NOTE: All component dimensions given in U.S. TRACTOR - -
inches 1 inch = 25.4 mm
18 Decal, Mower Keep Hand Away
KEY
NO. 9 10 12 -...Footrest, RH Manual, Operator's (Eng/Span) Manual, Parts (Eng/Span)
WHEELS AND TIRES
1
2
11 3
...
Similar Questions
On/off Switch
the tiny on/off switch fell out of the handle. Please advise.
the tiny on/off switch fell out of the handle. Please advise.
(Posted by lefttome 2 years ago)
My Tractor Model Yth22v46 Runs On Full Choke But Surges When Taken Off
(Posted by edjameson 3 years ago)
Lgt 2654 Turns Over, Fuel Pump Works, Runs If Gas Sprayed In Carb
Bought a used LGT 2645, it ran great until I lifted the front of the tractor high in the air to chan...
Bought a used LGT 2645, it ran great until I lifted the front of the tractor high in the air to chan...
(Posted by richardsteinacker1 7 years ago)
Husqvarna Yth22v46 Parking Brake Will Not Disegage
the parking brake wll disegage when clutch is 1/2 way released but when fully released parking brake...
the parking brake wll disegage when clutch is 1/2 way released but when fully released parking brake...
(Posted by nelsongrist 10 years ago)
Fuel Grades For Husqvarna Yth22v46
Is it ok to use 93 octane super unleaded on this super new mower I just purchased? Should I use 87 o...
Is it ok to use 93 octane super unleaded on this super new mower I just purchased? Should I use 87 o...
(Posted by gibsonq200 10 years ago)