Hayward Power-Flo LX Support Question
Hayward Power-Flo LX Support Question
Find answers below for this question about Hayward Power-Flo LX.Need a Hayward Power-Flo LX manual? We have 3 online manuals for this item!
Question posted by jbrightwell2 on September 16th, 2012
How Many Hp Is This Pump The Numbers I Have Are .model 548a85a04
The model is 548A85A04 then it has these no. SP-1515-Z1-EW
It says hayward power flo pump it also has S125J RPM 3450 or 8450 not sure hard to read can you please tell me what the HP is on this the guy said it was 3 HP I don't want to buy it if its not.
Thank you for any help you can be
Current Answers
Related Hayward Power-Flo LX Manual Pages
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 1
...spas if so marked.
Use motor bonding lug to the pool...pools and may be avoided. A permanently installed pool is adequate for the HP (KW) rating and distance from power source. Connect only to the pool as air bleed (if available) on power and allow a reasonable time for storable pools...TL-98
HAYWARD HIGH-PERFORMANCE PUMPS
INSTALLATION AND... your pump is to electric supply;
READ AND...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 2
...1
PART NUMBER
MODEL SP-1575LXTL
MODEL SP-1580TL
MODEL SP-1580X15TL
SPX1500-N2
SPX1500-N2
SPX1500-N2
SPX1580-BP
SPX1580-BP
SPX1580-BP
SPX1580-Z-1
SPX1580-Z-1
SPX1580-Z-1
SPX1500-F
SPX1500-L
SPX1500-L
SPX1250-XZ-2
SPX1250-XZ-2
SPX1250-XZ-2
SPX1580-AAP
SPX1580-AAP
SPX1580-AAP
SPX1500-Y-2
SPX1500-Y-2
SPX1500-Y-2
To order, specify motor manufacturer, HP and pump model no. NO...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 3
... cover to pump housing with four (4) motor securing bolts. (Be sure motor base ... pump housing-O-ring end first. SEAL CHANGE INSTRUCTIONS
Power Flo™ LX ...Series with Twist Lock Cord
GENERAL Exercise extreme care in slot at end of motor.* Hold screwdriver so as above, is now exposed.
4. For safety, all power shut off the impeller.
5. SINGLE PHASE
MOTOR KW HP...
Models: SP1575LXTL SP1580TL and SP1580X15TL - Page 4
... reading)
NOTE:
Your Hayward pump motor is equipped with water and that pool ...sure all suction openings.
3. a.
b. Tighten all electric power. Check voltage to make sure pump is locked firmly in U.S.A. Open pump and check for : 1.
E. LOW FLOW - Clogged or restricted strainer or suction line; Plugged or restricted discharge line of Hayward Pool Products, Inc. Pump...
SP1575X15 - Page 1
....
4. Open all electric power. Store pump and motor in cooling. Turn on filter. (The air that vents are tight. Keep motor clean. The advanced design reduces required maintenance to aid in a dry, well-ventilated room. Motor must be performed by applicable electrical codes. Make sure suction joints are free from freezing. HAYWARD POOL PRODUCTS, INC...
SP1575X15 - Page 2
... NUMBER MODEL...
SP1575X15 (With Strainer) SPX1500N2 SPX1500B SPX1500H SPX1500F SPX1500KA SPX1500AA SPX1500Y2 SPX1515Z1E SPX1500CA SPX1500W SPX1250R SPX1500P SPX1500D2 SPX1700FG SPX1500XE Motor Strainer Housing O-Ring Basket Strainer Cover O-Ring Strainer Cover Drain Plug w/Gasket Strainer Shim Ring (Horizontal Outlet Pumps Only)
NO. Head Housing Cover Housing Gasket Impeller Seal Assembly Pump...
SP1575X15 - Page 3
... and fasten housing cover to fill strainer with seven (7) bolts and nuts. Be sure to pump housing with water before performing service or maintenance.
1.
SEAL CHANGE INSTRUCTIONS
SP1500 SERIES
...power before restarting.
*For A.O. Carefully press ceramic seat, with ceramic seat inside, into clear plastic seat retainer-polished surface facing out.
SINGLE PHASE
MOTOR
KW
HP...
SP1575X15 - Page 4
... has sufficient "priming water": 1. Tighten all suction openings. 3. MOTOR CUTS OUT-Check for : 1. D. Make sure pump/strainer housing is clean and properly seated. F. Binding and overload. (Amperage reading)
NOTE: Your Hayward pump motor is equipped with water and that pool water level is locked firmly in suction (bubbles issuing from return fittings). 4. The motor will...
Owners Manual - Page 1
...if ignored presents a potential hazard. This is the safety-alert symbol.
ISPFSERIES Rev G
PowerFlo LX™ / PowerFlo II™ / EP Pump Series
Owner's Manual
Contents
Product Warnings 2 Installation 4 Start-Up & Operation 6 Shaft ... including the following: Failure to hazards. Hayward Pool Products 620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995 www.haywardnet.com
USE...
Owners Manual - Page 2
... suction outlet components immediately.
Failure to keep suction outlet components clear of the pool/spa
from the suction outlets can result in an entrapment. Failure to remove pressure test...such as a means of the limb. Before starting system pump, fully open position. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
2 Read and follow all National, State, and Local codes applicable...
Owners Manual - Page 3
.... Power should interrupt power. Provide a properly located electrical receptacle. Failure to pump housing with applicable local codes,
regulations, and the National Electric Code (NEC). Notes to a gas supply line. Run a continuous wire from lawn mowers, hedge trimmers and other general wiring procedures. WARNING -
Failure to ground all metal parts of swimming pool, spa, or...
Owners Manual - Page 4
...area, one to four (4) feet above the pool water line. The pump suction and outlet ports have molded-in strainer ... reduce vibration and stress on ALL models, use , it rains. To avoid pump strain, support suction and outlet independently...local and national codes. Installation Instructions
Pump Location
The PowerFlo LX™ and EP series pumps MUST be solid -
Wind the tape...
Owners Manual - Page 5
...circuit, be sure to seal wire...pool, spa, or hot tub. Connect a No. 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on electrical connections. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
5
Match supply voltage to pool users. Permanently ground motor.
it will prevent normal pump operation. Reset if necessary. Voltage
Voltage at full load, consult power...
Owners Manual - Page 6
... seal. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
6 NEVER operate the pump without water. RELEASE ALL PRESSURE from base. 4. See filter owner's manual. When water source is running.
Keep motor dry and covered during storage. Fill strainer housing with plastic film or bags.
CLOSE VALVES in your pool/spa system. Priming Pump
Open all...
Owners Manual - Page 7
..., exposing the impeller. 4. If assembly is secure. Re-assemble strainer by pushing clip down onto grooved pump cover coupling. Open all electrical power service to use this product. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
7 Prime pump according to seal leakage. 10. Insert basket and fasten strainer cover. 16. To reduce risk of water before...
Owners Manual - Page 8
...Hayward pump motor is felt, check for clogging or obstruction in OPEN position. 2. Centrifugal switch stuck in suction. Make sure pump/strainer housing is filled with water and the cover O-ring is leaking. You may be sure... has cooled, provided the power source is at motor or power drop (frequently caused by removing the skimmer basket and holding your pool dealer can build up to...
Owners Manual - Page 9
... regularly. DATE OF INSTALLATION
INITIAL PRESSURE GAUGE READING (CLEAN FILTER
PUMP MODEL HORSEPOWER
FILTER MODEL
SERIAL NUMBER
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
9 Cavitation due to clean...to whine. See "Shaft Seal Change Instructions" in
this point or putting in pool, and
unrestricted discharge return lines. Equipment base vibrating. Check For:
1. Insure air...
Owners Manual - Page 10
...
---- Motor (for SP1540C) - 40 GPM
SPX1540Z1E
----
SPX1510Z1XE
Motor (for each pump have "TL" at end of model number to Part No. SPX1510Z2E)
*All Twist Lock versions for SP1580X15) - 1-1/2 HP
---- on
Refer to a "2" (i.e.
Motor (for SP1580) - 1 HP
----
SP1750, 1775, 1780
SPX1500N2 (6 Req'd.) SPX1705B SPX1580Z1 SPX1500H SPX1500KA
Refer to Part No. SW1585X20, SW1585X25...
Owners Manual - Page 11
... warranty gives you specific legal rights, and you . The limited warranty excludes damage from the date of purchase, when used in single family residential applications.
HAYWARD® Pool Products Limited Warranty
To original purchasers of this Warranty Certificate (upper portion) in a safe and convenient location for a particular purpose. Proof of purchase is...
Owners Manual - Page 12
... PARTS
12
PowerFlo LX™ / PowerFlo II™ / EP Pump Series Warranty Card Registration
Register online at www.hayward.com
Please Print Clearly:
Years Pool has been in service
First Name Last Name 1 year 1-3 4-5 6-10 11-15 >15
Street Address Purchased from
City State___________ Zip____________
Builder Retailer Pool Service Internet/Catalog
Phone Number Purchase Date...
Similar Questions
Where Is Power Switch For Hayward 1.5 Hp Pump
(Posted by andylaurag 10 years ago)
Haward Power Flo Pump--model S48a85a04, Sp-1515-z1-ew,
Hello, I am trying to replace this above pump with basket. The problem I am seeing is that the outle...
Hello, I am trying to replace this above pump with basket. The problem I am seeing is that the outle...
(Posted by rjsviper22 10 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)