Hayward NorthStar Support Question
Hayward NorthStar Support Question
Find answers below for this question about Hayward NorthStar.Need a Hayward NorthStar manual? We have 1 online manual for this item!
Question posted by fsxa on March 25th, 2014
What Capacitor Is On A 1.5 Hp Hayward Northstar Motor
The person who posted this question about this Hayward product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Hayward NorthStar Manual Pages
All NorthStar models - Page 1
... that will provide many years of today's in-ground swimming pool/spa that is specifically engineered for the demanding requirements of efficient, dependable, corrosion-free service. To prevent potential injury and to avoid unnecessary service calls, read this manual carefully and completely. The Hayward NorthStar Pump is equipped with large capacity filters, heaters, and...
All NorthStar models - Page 2
...local codes, regulations, and the
National Electric Code (NEC). WARNING - Use of the motor. WARNING - Closely supervise children
at
least every ten years, or if found to be ...be installed and serviced only by a qualified professional. Pool and spa components have a finite life. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump Series
Page 2 of injury, do...
All NorthStar models - Page 3
... continuous wire from external bonding lug to pool structure will increase risk for information on the motor housing and to all metal parts of swimming pool, spa, or hot tub, and to all ..., hedge trimmers and other general wiring procedures. Hazardous voltage can result in mechanical entrapment. NorthStar™ Pump Series
Page 3 of the limb. All electrical wiring MUST be in the...
All NorthStar models - Page 4
... burns. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar™ Pump Series
Page 4 of pump components. All suction and discharge valves MUST be OPEN when starting system pump, fully open filter manual air relief valve.
Before servicing pool and spa circulation system, all internal parts. Motors operate at high temperatures and if they...
All NorthStar models - Page 5
...pool...motor clean.
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD... GENUINE REPLACEMENT PARTS This product should have continuous slope upward from excess moisture and flooding. Pump may be installed and serviced only by a qualified professional.
Allow adequate access for cooling.
NorthStar...tight (but not over-tightened). Pump motors require free circulation of 15
HP 3/4 1 1 1/2 2 2 ...
All NorthStar models - Page 6
...motor.
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Do NOT use the fewest possible fittings (but not limited to motor...pool structure. If voltage is adequate for all applicable local codes,
regulations, and the National Electric Code (NEC). Reference NEC codes for the HP... provided on the motor housing and to all metal parts of swimming pool, spa, or hot tub...
All NorthStar models - Page 7
...-
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pump MUST be permanently connected to Start-Up
NOTE - Full Rate (FR)
HP
KW
3/4
0.55
1
0.75
...temperature no longer than 100° F (38° C). 5. NorthStar™ Pump Series
Page 7 of water (not air or air ...Motor Specifications
Max Rate (MR)
HP
KW
1
0.75
1-1/2
1.10
2
1.55
2-1/2
1.87
3
2.20
-
-
All NorthStar models - Page 8
....
Running pump dry may damage pump and voids warranty. Do NOT add chemicals to pool/spa system directly in suction and outlet pipes. 3. RELEASE ALL PRESSURE from valve. NOTE -
If pump does NOT prime within five minutes, stop motor and determine cause. No lubrication is lower than the pump, pump will depend on...
All NorthStar models - Page 9
... serious personal injury or death. 1.
Failure to pump before draining pump. Contact your pool/spa system. Pull the diffuser off of the two-part replacement seal.
Disconnect pump from strainer housing. (See Parts Diagram on the motor shaft. A. Removing the Motor Assembly (See Parts Diagram on page 11 of
this manual for a long time...
All NorthStar models - Page 10
... engages. (Be sure housing gasket is now exposed. WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Replace motor cover to be reassembled. Press the ceramic seat with a clean, soft, cotton ...facing away from seal plate.
9. Press the spring seal assembly onto the motor shaft -
NorthStar™ Pump Series
Page 10 of this manual for pump component locations.)
...
All NorthStar models - Page 11
... Impeller Ring
Impeller Kit (Includes Impeller, Impeller Ring, Seal Assy)
Ctn. NorthStar™ Pump Series
Replacement Parts
Parts Diagram
Page 11 of 15
Parts Listing
Ref. No. Qty. 1 1 1 1 10 10 10 10 10 1 1
10 (5 for 2-3 HP)
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Part No. 1 SPX3200UNKIT 2 SPX3200UG 3 SPX4020TP 4 SPX4000M 5 SPX4000S
6 & 7 SPX4000CLO...
All NorthStar models - Page 12
... HP FR 1 HP FR 1 ½ HP FR 2 HP FR 3 HP FR 1 HP MR
1 ½ HP MR 2 HP MR 2 ½ HP MR 3 HP MR 1 ½ HP MR 2 SP 2 HP MR 2 SP 2 ½ HP MR...Motor P/N SPX1607Z1BNS SPX1610Z1BNS SPX1615Z1BNS SPX1620Z1BNS SPX1630Z1BNS SPX1607Z1MNS SPX1610Z1MNS SPX1615Z1MNS SPX1620Z1MNS SPX1625Z1MNS SPX1610Z2MNS SPX1615Z2MNS SPX1620Z2MNS
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NorthStar...
All NorthStar models - Page 13
... at motor or power drop (frequently caused by undersized wiring or extension cord use). Low Flow -
WWW.HAYWARDPOOL.COM
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS NOTE: Your Hayward pump motor is ...until the problem is filled with the wiring diagram on pool wall. 3. Be sure to automatically restart once the motor has cooled.
Leaking O-ring or packing glands on suction ...
All NorthStar models - Page 14
... restricted or undersized suction line or leak at once.
© Hayward Pool Products, 2007 All rights reserved. Solution: Correct suction condition or ...HAYWARD GENUINE REPLACEMENT PARTS Check For:
1. Motor bearings noisy from return fittings). Plugged, restricted, or damaged impeller.
Vibration due to improper mounting, etc. backwash as required. 5. D.E. filters - NorthStar...
All NorthStar models - Page 15
...Pool:
□ Vinyl □ Fiberglass □ Gunite
Size of Pool
Years pool has been in a safe and convenient location for cartage, removal and/or reinstallation labor or any other products from the date of purchase. NorthStar™ Pump Series
Page 15 of 15
HAYWARD... above limitation or exclusion may not apply to : Hayward Pool Products, 620 Division Street, Elizabeth, NJ 07207, ...
Similar Questions
Hayward Northstar Pool Pump .where Is The Capacitor?
(Posted by omidmsirro 9 years ago)
What Type Of Capacitor Is In The Northstar Pump?
(Posted by kph10blacko 9 years ago)
1 Hp Hayward Sp5500z2 Pool Pump Power Flo Matrix Motor Wont Start
(Posted by Rvesjeevi 10 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)