Hayward HydroRite UVO3 Support Question
Hayward HydroRite UVO3 Support Question
Find answers below for this question about Hayward HydroRite UVO3.Need a Hayward HydroRite UVO3 manual? We have 1 online manual for this item!
Question posted by Archieduiker52 on November 2nd, 2019
How Do You Replace The Quartz Sleeve On The Hydrorite Uvo3?
I purchased a new quartz sleeve (the old one was cracked) but cannot find instructions to replace it. Is there a special wrench to remove the old one
Current Answers
Answer #1: Posted by waelsaidani1 on November 3rd, 2019 2:07 AM
waelsaidani1
Member since:
May 12th, 2013 Points: 19,501,777
Member since:
May 12th, 2013 Points: 19,501,777
Related Hayward HydroRite UVO3 Manual Pages
HydroRite UVO₃ Owners Manual - Page 1
092596 RevC
HydroRite UVO3
2" Residential UV/Ozone Sanitizing System
Owner's Manual
Contents
Safety Instructions..........1 Before you Begin 2 Installation 3 Operation 7 Maintenance 7 FAQs 10 Troubleshooting............11 Replacement Parts.........12 Warranty 14
Model: HYD-UVO
Hayward Pool Products 620 Division Street, Elizabeth NJ 07207
Phone (908)-355-7995 www.hayward.com
USE ONLY HAYWARD ...
HydroRite UVO₃ Owners Manual - Page 2
... quartz sleeves are extremely delicate. Do not use this device for swimming pool use only replacement lamp specified by the ends only. FAILURE TO CONNECT THIS DEVICE TO A GFCI SUPPLY CIRCUIT COULD RESULT IN ELECTRICAL SHOCK CAUSING SERIOUS BODILY INJURY, INCLUDING DEATH.
• WARNING - Never touch the glass with alcohol.
• CAUTION - IMPORTANT SAFETY INSTRUCTIONS...
HydroRite UVO₃ Owners Manual - Page 3
... creation of Venturi (necessary for converting oxygen contained in the quartz sleeve area, into the water stream using multiple HydroRites, plumb vessels in parallel. When the HydroRite is designed for vessel cap
2
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS For larger installations, more than swimming pools and spas will void your health or the health of this product...
HydroRite UVO₃ Owners Manual - Page 4
... ONLY HAYWARD GENUINE REPLACEMENT PARTS Refer to install your supplier or Hayward. Remove power to a GFCI protected circuit. power cord that are unanswered when you have completed the reading of the Vessel. Check Valve
TO POOL
FROM POOL
Optional Bypass
NOTE: For optimum performance, the Venturi should be plumbed AFTER the HydroRite system
9 ft interlock...
HydroRite UVO₃ Owners Manual - Page 5
...GENUINE REPLACEMENT ...removing union tails.
Plumbing the HydroRite System
Note that high flow conditions would be put
back together after gluing the union tails to a concrete or wood base. Four mounting holes are located in damage to the pool...HydroRite is only operating when there is used. The controller's mounting brackets require a total of a spa...cracking of water flow.
25
HydroRite...
HydroRite UVO₃ Owners Manual - Page 6
...
here
Ozone Tube
5
1
Plug Ballast cable into the
sleeve, twist clockwise to isolate the vessel from the feeder,... cables through the appropriate cutout. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS All in installation.
venturi tube into the back...Electrical Connections
Do not plug in the HydroRite system. Note that connects to connectors, remove the four screws securing the large ...
HydroRite UVO₃ Owners Manual - Page 7
... (Stabilizer) to prevent this reaction. Use the recommended level of Cyanuric Acid regardless of your HydroRite unit become frayed or damaged, unplug it is indoors or outdoors.
6 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
NOTE: Should the electrical power cord of whether it from HydroRite or the sun, will deplete the pool's chlorine over time.
HydroRite UVO₃ Owners Manual - Page 8
... will clean the quartz sleeve. Automatic Cleaning of the vessel only when cleaning, then disconnected during normal operation. The cleaner is not running and HydroRite shuts off and the pool water stops flowing.
• Over Temperature - Maintenance
HydroRite has been designed for cleaning instructions. Cleaning the sleeve should be replaced. The quartz sleeve can contribute to...
HydroRite UVO₃ Owners Manual - Page 9
...pool water. 4. Remove the Stainless Steel Baffle There is a stainless steel baffle that there remains no water is performed. Manual Cleaning of the Quartz Sleeve
To remove and clean the quartz sleeve...quartz sleeve until it away from the light engine (see adjacent diagram). The vessel cap is removed by unscrewing the four mounting screws that no pressure inside the HydroRite... HydroRite... remove ...
HydroRite UVO₃ Owners Manual - Page 10
... of the glass sleeve is removed from freezing. Scheduled UV Lamp Replacement
In addition to fully insert into place.
11. BROKEN QUARTZ SLEEVES, OR WATER DAMAGE CAUSED BY BROKEN QUARTZ SLEEVES, ARE NOT COVERED UNDER YOUR LIMITED WARRANTY.
10.
Ice formation inside a climate controlled enclosure. Note that service is required, contact your HydroRite unit during the winter...
HydroRite UVO₃ Owners Manual - Page 11
...switch that are compatible with pools equipped with ALL Pool chemicals? NO, not unless the HydroRite is a potent sanitizer and oxidizer but can
be affected by the HydroRite is re-established. HydoRite...in front of the vessel. A. Is HydroRite compatible with Hayward Salt Chlorine Generator Systems. Over time, the stainless steel baffle can be replaced on /off , simply unplug the power...
HydroRite UVO₃ Owners Manual - Page 12
... Lit
If this occurs:
• The quartz sleeve seal is bad. • There is a broken or cracked quartz sleeve. There is firmly in obtaining a new ballast. • Verify that the electrical ...• The lamp has become disconnected from the vessel:
• The HydroRite vessel is being generated. You should reset. A replacement ballast is lit. If so, resolve the issue. • The lamp ...
HydroRite UVO₃ Owners Manual - Page 13
...Vessel Drain Plug Vessel O-Ring Kit Valve Actuator 3-Port Diverter Valve
12 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Replacement Parts
Part Number GLX-HYDCTLUVO GLX-HYDVESSUVO GLX-HYDXFMR GLX-HYDPCB GLX-HYDFUSE GLX-HYDBALLAST HYXSLACA HYXSFANA... Harnesses UV Lamp Cable Fan Assembly Stainless Steele Sleeve With O-Rings Ozone Manifold and Interlock Switch Quartz Sleeve Assembly Residential Lamp -
HydroRite UVO₃ Owners Manual - Page 15
..., UV lamp cable, quartz sleeve and stainless steel sleeve carry a One (1) year warranty from freezing, negligence, improper installation, improper use or care or any nature. To obtain warranty service, please contact the place of purchase. Hayward shall not be responsible for any consequential, special or incidental damages of merchantability or fitness for cartage, removal, repair or...
HydroRite UVO₃ Owners Manual - Page 16
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS All other trademarks not owned by those third parties. Hayward is a trademark of their respective owners. FOR FURTHER INFORMATION OR CONSUMER TECHNICAL SUPPORT, VISIT OUR WEBSITE AT
www.hayward.com
Hayward is a registered trademark and HydroRite is not in any way affiliated with or endorsed by Hayward...
Similar Questions
Sas Chlorine Generator
The power has shut down on my generator, what could be the causes
The power has shut down on my generator, what could be the causes
(Posted by tnordcv 7 years ago)
Drive Error
pump has stalled, have tried every recommendation , stall message continue
pump has stalled, have tried every recommendation , stall message continue
(Posted by charlesstewart39 7 years ago)
I Recently Lost Power, Now My Ecommand 4 Panel Will Not Turn My Pump On.
I can only turn the pump on and off with the panel breaker. The panel is no longer controlling the p...
I can only turn the pump on and off with the panel breaker. The panel is no longer controlling the p...
(Posted by karenmonroelvnv 9 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)