2012 Ford F250 Super Duty Support Question
Find answers below for this question about 2012 Ford F250 Super Duty.Need a 2012 Ford F250 Super Duty manual? We have 2 online manuals for this item!
Question posted by desmoto on November 27th, 2013
How To Reset 2012 Ford F250 Exhaust Fluid Range Alarm
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
There are currently no answers that have been posted for this question.
Be the first to post an answer! Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.
Be the first to post an answer! Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Vehicle speed will result in vehicle speed limitations and/or result in the vehicle entering an idle-only mode. Speed control (if equipped) If vehicle speed goes outside a predetermined range from the exhaust of diesel exhaust fluid (DEF) which must be reset.... Failure to cool the transmission, exhaust gas recirculation (EGR), charge air ...
Diesel Supplement 3rd Printing - Page 7
Low/contaminated diesel exhaust fluid: With the key in extensive damage to, or failure of water in fuel: During...will not operate properly if air enters the system. See Diesel exhaust fluid in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The water in fuel light will illuminate if the exhaust fluid is running . If the light illuminates when the engine is...
Diesel Supplement 3rd Printing - Page 9
... starter damage may occur. The glow plugs may be reset by turning the key to off . When operating in cold...the vehicle's functions due to low or contaminated diesel exhaust fluid (DEF). See Selective catalytic reduction (SCR) system in...'s Guide. engine until the oil pressure gauge indicates normal pressure. 9
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) After the engine...
Diesel Supplement 3rd Printing - Page 11
... equipped with snow and/or ice. Your vehicle is recommended that the fuel level in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) To avoid engine fuel starvation during cold .... Do not use a fuel with a diesel fuel conditioner module (DFCM) which uses diesel exhaust fluid (DEF) to use alcohol based additives to help prevent air from inside the air filter assembly...
Diesel Supplement 3rd Printing - Page 17
... (battery located on the passenger side) for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Contact roadside assistance for the proper method of DEF, it will not resume until DEF is refilled. RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your vehicle runs out of jump starting procedure and refer...
Diesel Supplement 3rd Printing - Page 26
...refilling of maintaining the DEF level In order for your DEF tank, see this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) When you see Filling the DEF tank ...refilling your vehicle. The system automatically injects diesel exhaust fluid (DEF) into the exhaust system to the fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is ...
Diesel Supplement 3rd Printing - Page 27
...the DEF becomes empty or contaminated fluid is refilled. Your vehicle's message center will result in the message center.
27
2012 Diesel (67l) Supplement, 3rd ...caution and refill DEF immediately. Maintenance and Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low or replaced when contaminated or the vehicle speed will ...
Diesel Supplement 3rd Printing - Page 29
... miles Exhaust Fluid Range Refill exhaust fluid None (805 km) left before 500 miles (805 km) exhaust fluid tank is empty In 99 Miles (159 km) Speed Approximately 99 Miles Limited to 50 MPH (159 km) left before Refill exhaust fluid None (80 km/h) Exhaust Fluid exhaust fluid tank is limited Vehicle restarted with (80 km/h) Exhaust Fluid Refill exhaust fluid to 50 MPH 0 Miles (0 km) - 2012 Diesel...
Diesel Supplement 3rd Printing - Page 30
30
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings and Actions -
Maintenance and Specifications Instrument Cluster Messages (Optional message center messages shown, base message center messages similar) Customer Distance/Exhaust Fluid Cluster Message Requested Vehicle Actions Level or Action Actions This occurs when the exhaust fluid is empty and: • The vehicle's ...
Diesel Supplement 3rd Printing - Page 35
...in the message center. To prevent overfilling of time with a bottle, Ford recommends using a nozzle is full. If the message center indicates EXHAUST FLUID LEVEL OK, do not add DEF. Environmental Protection Agency (EPA): ... DEF light will illuminate and exhaust fluid system fault messages will result in the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Diesel Supplement 3rd Printing - Page 37
... 7300 miles (11748 km) - 8900 miles (14323 km)
37
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Your usage may vary depending on: driving style, trailer towing, loaded vehicle weight, weather, idle time, PTO usage, etc. Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate DEF usage for...
Diesel Supplement 3rd Printing - Page 63
... soon light
63
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) federal law and certain state laws prohibit removing or rendering inoperative emission control system(s). Tampering with emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after the engine is very high. Ford recommends against...
Diesel Supplement 3rd Printing - Page 67
... is limited or in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre... circuit breakers must always be limiting the vehicle's functions due to low or contaminated diesel exhaust fluid (DEF). Higher rated fuses or circuit breakers could allow circuit overloading in the event of...
Diesel Supplement 3rd Printing - Page 68
...-M99C130-A
5 gallons (18.9L) 6 gallons (22.7L)
Diesel Exhaust Fluid (DEF) - Chassis Cab 68 MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES Item Motorcraft Specialty Orange Engine Coolant Capacity Ford part name Ford part number / Ford specification or specification VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Engine coolant...
Diesel Supplement 3rd Printing - Page 77
...) between service intervals. 2 Reset your Owner Guide. 3 Vehicles equipped with dual rear wheels should rotate the front wheels when specified; refer to the Information Display chapter of your Intelligent Oil Life Monitor after each engine oil and filter change Change engine oil and filter. 2 interval as indicated Refill diesel exhaust fluid tank.
Owner Guide 4th Printing - Page 25
...will be displayed to change is programmed) 11. EXHAUST FLUID LEVEL (Diesel only) 3. TBC GAIN = XX.X (if equipped) 9. FUEL LEVEL 10. Press and hold the RESET button to change , perform the following: 1. ... is present. Press and release the SETUP button to display "OIL LIFE XXX% HOLD RESET = NEW". 25
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) ENGINE HOURS...
Owner Guide 4th Printing - Page 37
... supplement for more information. XX MPH MAX UPON RESTART EXHAUST FLUID EMPTY (diesel engine only) - The diesel exhaust fluid must be limited upon restart. Displayed when the diesel exhaust fluid is depleted. Displayed when the SCR system detects low exhaust fluid. ENGINE IDLED SEE MANUAL (diesel engine only) - EXHAUST FLUID RANGE XXX MI (diesel engine only) - Speed will enter into...
Owner Guide 4th Printing - Page 38
...using additives that do not meet or exceed Ford specifications. Contact your diesel supplement for more...after the engine has fully warmed up , consider different fuel sources. 38
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus... dealer as soon as possible. Refer to 1%. ENGINE IDLED SEE MANUAL EXHAUST FLUID SYSTEM FAULT (diesel engine only) - Displayed when the oil life left...
Owner Guide 4th Printing - Page 51
... OK TO DRIVE will intentionally be properly circulated to your diesel supplement for more information. 51
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Displayed when the... (DPF) has been adequately cleaned by CLEANING EXHAUST FILTER messages have been displayed. Refer to avoid engine damage from 30 seconds. EXHAUST FLUID RANGE XXX MI (diesel engine only) - Refer ...
Owner Guide 4th Printing - Page 53
...above , please take the vehicle to your diesel supplement for more information. 53
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus)... filters must be void from using additives that do not meet or exceed Ford specifications. Instrument Cluster
ENGINE IDLED - Press OK to the scheduled maintenance information... EXHAUST FLUID SYSTEM FAULT (diesel engine only) -
Similar Questions
How Do I Reset The Message Screen On My 2012 F250
(Posted by WayGsa 9 years ago)
How To Erase The System In 2012 F250 That Requires Diesel Exhaust Fluid?
(Posted by SOTeran 10 years ago)
How To Reset 2012 Ford F250 Check Coolant Additive Alarm
(Posted by jaseCANDY 10 years ago)
How Much Exhaust Fluid To Fill 2012 F250
(Posted by elizabeth139354 10 years ago)