Craftsman 28986 Support Question
Craftsman 28986 Support Question
Find answers below for this question about Craftsman 28986 - 21 HP 42 in. Zero Turn Tractor.Need a Craftsman 28986 manual? We have 1 online manual for this item!
Question posted by jackcarter98306 on September 20th, 2012
Tuneup Parts For Zts6000 42'
What is the psrt number for a tuneup/maintenance kit for the ZTS6000 42" with BS Platinum that includes the oil filter, air filter, spark plug, etc.
If a kit isn't available, what are the part numbers for the individual parts.
Current Answers
Related Craftsman 28986 Manual Pages
Operation Manual - Page 1
Operator's anual
T
°
ZTS
Zero-Turn Rear Engine Riders with Electric Start
Model No. 107.289860 (21HP Briggs & Stratton Engine with 42" Mower)
CAUTION: Before using this
Nota: Una traducci6n en espaSol de este Manual del Operador puede encontrarse en la pagina 37. Sat
about this product, ...
Operation Manual - Page 3
...failure to maintain the riding equipment according to blades, spark plugs, air
cleaners, belts, and oil filters.
• Standard maintenance servicing, oil changes, or tune-ups.
• Tire replacement or... Numbers 9
Assembly 10 Pre-Operation 13 Operation 14 Maintenance 21
Service & Adjustments 30
Storage 34 Specifications 34 Troubleshooting 35 Spanish Operator's Manual 37 Repair Parts...
Operation Manual - Page 7
... fuelsoaked debris. Replace gas cap and tighten securely. 11. SERVICE AND MAINTENANCE
Safe Handling of the transaxle). 24. Use only approved gasoline containers. 3. If this unit unless you strike an object, stop the engine, remove the key, and disconnect the spark plug wire(s)
before storage. 5. Never run the unit in good condition before...
Operation Manual - Page 16
To avoid engine problems always use a single ramp that the crankcase oil is filled to ride on the unit. Use fresh fuel next season.
Remove the fuel cap ...feet (607 cm) horizontally. Do not allow passengers to full mark on slopes with fresh fuel. This rider has a zero turning radius and the wheels could fall off the ramps, or the rider could tip over dry leaves, grass or combustible ...
Operation Manual - Page 18
... Travel
Figure 9.
The lever controls of the zero turn rider are also your lawn. is in reverse unless absolutely necessary. Locate a smooth, flat area of the zero turn rider are very responsive, and learning to steer... to do so near objects. Slow down and repeat. The rider turns as shown in reverse. Zero turn rider. Spend some practice. The BEST method of handling the ground ...
Operation Manual - Page 19
... control lever back to back up and re-cut - Executing Turns
Turning In Place
Figure 10. To turn before mowing.
RightTurn
ADVANCED DRIVING
Executing an End-Of-Row Zero Turn
Your zero turn rider's unique ability to turn in place. Be sure to stop and make your lawn by pivoting directly on the tire tread, it is best to...
Operation Manual - Page 21
...Check / Adjust PTO Clutch
•
•
•
•
•
•
•
ENGINE MAINTENANCE, 21HP Briggs & Stratton
Check Engine Oil Level * Service Air Pre-Cleaner * Change Oil * Service Air Filter * Change Oil & Filter * Clean Cooling Fins * Replace Air Filter * Replace Spark Plug Replace Fuel Filter 1 Check Valve Clearance 1"
8 Hours or Daily
•
25 Hours or Every Season...
Operation Manual - Page 26
... removed and tractor on component parts, and is... slipping, will not engage, or if a new clutch has been installed.
1. Note the position of the 3 adjustment windows (A, Figure 27) in Figure 28.
4. Check the mower blade stopping time. Figure 27.
The PTO clutch is turned...ignition switch and disconnect spark plug wires to prevent ...NOTE: The actual air gap between the rotor...
Operation Manual - Page 32
...jam nuts against the trunnion to Ground A. Figure 37. Mower Deck B. Threaded Rod B. Disconnect the spark plug wire and fasten it away from side-toside (see Figure 37).
5. If the difference is accomplished... turn the mower blades OFF, turn the ignition switch OFF, remove the key, and allow all moving parts to -Side
Figure 38. Trunnion
C. Unequal or improper tire pressure may need leveling. Turn...
Operation Manual - Page 34
...System Oil Capacity
Briggs & Stratton ELS
21 @... variety of factors including, but not limited to, accessories (air cleaner, exhaust,...Maintenance and Storage instructions in the Safety Rules section, then perform the following steps:
• Turn...maintenance items. • Fill with SAE J1995 (Revision 2002-05). Alternator, Battery: 230 CCA 44 oz (1.3 liters) w/o filter; 48 oz (1.42 liters) w/filter...
Operation Manual - Page 35
...wiring & replace broken or frayed wires. Contact Sears Parts & Repair. Service pre=cleaner and/or replace air filter element.
Spark plug faulty, fouled, or incorrectly gapped.
Drain excess oil.
Always remove the ignition key, disconnect the spark plug wire and fasten it away from the plug before beginning the maintenance, to START position.
Allow engine to CLOSED position...
Operation Manual - Page 79
...21...Self Locking, 3-5/8 LG 1 HOSE, Oil Drain, 16-1/2 LG 3 SCREW, Hex...42...AIR DUCT, Inlet 1 CAPSCREW, Hex Head, 5/16-18 x 3/4, G5 1 CONTROL, Throttle 2 SCREW, Pan Head Taptite Torx, 1/4-20 x 5/8 1 SCREW, Pan Head Taptite Combo, 310-16 x 3/4 1 KNOB, Throttle 1 HOSE, Fuel, 19.5" (See Frame, Body & Seat Group for fuel tank assembly.) 2 CLAMP, Hose
Footnotes Note * See Briggs & Stratton Engine Repair Parts...
Operation Manual - Page 84
fully nested in
31
gear teeth
29
Parking Brake Switch
10
44
36 \
41
\
42
43
33
F
Ref: Front Panel
F
)
* Note: Handlebars out (locked) compress
brake spring to be'--. Controls Group
NOTE: ...hardware torque specification chart.
12 Ibs. inward force measured 1" above bottom of foam grips
24
33
32 \
/f
32
21 )_12
ZTS 6000 - 107.289860
28
Brake arm to 3" length.
32
PTS - 12
Operation Manual - Page 85
..., w/5/16-18 NILN (Brake/Clutch) 1 ROD, Park Brake- Controls Group
REF NO PART NO.
1 1726410SM
2 1727796ASM
3 1960686SM
4 1720452SM
5 1919381SM
6 1960086SM
7 1917356SM ...7091298SM
18 7015761YP
19 1960027SM
20 7091591SM
21 7300993AYP 22 7090188SM
23
1920161SM
24
...
38
1666697SM
39
1921977SM
40
1715025SM
41
1919438SM
42
1727603ASM
43
1921221SM
ZTS 6000 - 107.289860
QTY...
Operation Manual - Page 86
... in
31
gear teeth
29
Parking Brake Switch
10
44
36 \
41
\
42
43
33
F
Ref: Front Panel
F
)
* Note: Handlebars out (locked) compress
brake spring to be'--. inward force measured 1" above bottom of foam grips
24
33
32 \
/f
32
21 )_12
ZTS 6000 - 107.289860
28
Brake arm to 3" length.
32
PTS...
Operation Manual - Page 95
... Instructions 1 DECAL Craftsman Logo (Large) 1 DECAL Operator Instructions Front 1 DECAL Operator Intructions Bottom 1 DECAL Tracking Adjustment ZT 7000 1 DECAL ZTS 7500, 20/42 1 DECAL Height of Two (Not Shown) 1 LITERATURE PACK, SEARS ZTS 6000 21/42 (Not Shown)
ZTS 6000 - 107.289860
Footnotes Note * Not a service part. Craftsman ZTS 1 DECAL Seat Deck R.H. PTS - 23
Operation Manual - Page 97
...
7 1733578ASM
8
1734185ASM
9 1733576ASM
lO
1734242ASM
11 1931277SM
12 1935048SM
13 1931338SM
14 1931333SM
15 1931211SM
16 1733844SM
17 1734243ASM
18 1714255SM
19 1960534SM
2o
1732360SM
21
1924940SM
22
1922130SM
23
1667812SM
24
1733577ASM
25
1733575ASM
26
1731403ASM
27
1732966SM
27
1734048SM
1 BRACKET, Gauge Wheel L.H. QTY. Front 4 NUT, Hex Flange, 3/8-16 ESNA...
Operation Manual - Page 99
... 7072537SM 9 1730100BNYP 10 1731917SM 11 1731898ASM 12 7024467SM 13 7091633SM 15 721083BMYP 16 1960686SM 17 721369BMYP 18 1931333SM 19 1923683SM 20 0166x4MA 21 094707MA
2 NUT, Hex Nylock, 5/8 2 PULLEY, Drive, 5-1/2 2 SPACER, Pulley 4 RING, Retaining, 1-3/4 4 BEARING,...1/2 2 WASHER, Belleville
ZTS 6000 - 107.289860
Footnotes
PTS - 27 QTY. 42" Mower Deck - Housing & Arbor Group
REF NO PART NO.
Operation Manual - Page 101
...
5 7
13
33 34 35
36
42 45 192 238 337 617
Part No.
796005 794114
Qty.
1 1
...
1
692011
691751
2
690822
1
Description
Boot-Spark Plug Stud-Rocker Arm
Sealant-Liquid Seal-Valve Gasket...Kit-Reference 121
PTS-29
12/09/2008 No.
635 830 850 868 883 914
1022
1023 1026
1029 1034
Part No.
331877-0144-B1
J
883
1022
1022
238 O 617 _!)
914 _
1026 ___
63t_',
Assemblies include all parts...
Operation Manual - Page 106
...include all parts shown in frames.
No.
188
202
209
216 222 227
232
265 267
333 334
356 474 501
Part No. Qty. No.
505
526 562
789 851 877 877A 1059 1119
Part... Screw
(Regulator) 1 Bolt
(Governor Control Lever) 1 Harness-Wiring 1 Terminal-Spark Plug 1 Wire/ConnectorAlternator Wire/ConnectorAlternator
1 Kit-Screw/Washer 4 Screw
(Alternator)
A Gasket Set-Reference 1095
Engine Gasket Set-...
Similar Questions
Zts 6000 Lawn Tractor Belt Keeps Coming Off.
I have a Craftsman zts 6000 zero turn mower and after about 5 minutes of cutting the belt that rotat...
I have a Craftsman zts 6000 zero turn mower and after about 5 minutes of cutting the belt that rotat...
(Posted by jaemundy 8 years ago)
How Do I Adjust The Ground Travel On A Craftsman Zero Turn Mower
(Posted by mrBigBe 9 years ago)
Transmission Drive Belt Replacement On Craftsman Zts6000
How Do You Replace A Drive Belt On A Craftsman Zts 6000 Zero Turn Mower
How Do You Replace A Drive Belt On A Craftsman Zts 6000 Zero Turn Mower
(Posted by JAXGEP 9 years ago)
What Size Oil Filter Do It Need For My Zero Turn
(Posted by Anonymous-134248 10 years ago)
