Bosch HDI8054U Support Question
Bosch HDI8054U Support Question
Find answers below for this question about Bosch HDI8054U.Need a Bosch HDI8054U manual? We have 4 online manuals for this item!
Question posted by applemailaccnt on July 21st, 2020
Bosch Hdi8054u Insufficient Flame/btus On Range Top Burners - Low Gas Flow?
Purchased an open-box HDI8054U dual-fuel range, floor model looked never to have been used, but with no warranty. Electric oven works great, all gas burners spark and ignite on range top. However, I am getting insufficient BTU output from the gas burners, looking to be insufficient gas flow. ALL 5 burners are showing insufficient gas, so I am suspecting that the gas regulator (Bosch part #00632664) is the source of the problem. Our previous kitchen range hooked up to the same gas line worked like a champ.But how often would a regulator like this fail right out of the box? I'd hate to swap it out (PITA) if it hasn't actually failed. Is there any adjustment on the regulator that would allow me to control gas flow? Is it possible the range was in some sort of "demo mode" on the showroom floor that reduced the actual BTU output?
Current Answers
Answer #1: Posted by Odin on July 21st, 2020 11:28 AM
Odin
Member since:
April 10th, 2010 Points: 41,236,690
Member since:
April 10th, 2010 Points: 41,236,690
Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.
Related Bosch HDI8054U Manual Pages
Instructions for Use - Page 9
.... Getting Started
Parts and Accessories
Your appliance may vary slightly. 1 2 4 3 5
6 7
8 9
Range Parts Key
1
Oven Control Panel
2
Cooktop Control Knobs
3
Door Gasket
4
Door Latch
5
Probe Jack
6
Convection Fan
7
Rack Position Guides with 6 rack positions
8
Oven Bottom
9
Door Hinge
10
10 Warming Drawer
Range Features
Selaed Gas Burners The cooktop has sealed gas burners. Spills...
Instructions for Use - Page 10
... that the prongs of the burner base fit snugly into the groove of the burner cap.
9 WARNING
To prevent flare-ups and avoid creation of burners. • Burners do not ignite. • Burner flames light unevenly. • Burner emits gas odor.
9 WARNING To prevent burns, do not use the cooktop without all burner caps and all burner grates properly positioned. Match the...
Instructions for Use - Page 13
... needed. Do not clean in some models)
HEZTR301
Use with cleaning your oven.
Automatic Shutoff
The oven will automatically shut off after 24 hours. Accessories
Probe (some models)
The probe can be used to put dishes into the oven, check on but no cooking mode or timer is a problem with the range.
Telescopic Rack
(some modes. Indicators and...
Instructions for Use - Page 15
...this manual.
If a burner flame blows out during use a ventilation fan or hood when cooking with Gas. It should be a slight odor during removal, catching on proper
bakeware being used. • Optimum oven cooking results depend on the oven walls. Remove packing materials from range. Normal Operation (Electronic Ignition/ Reignition)
The cooktop uses electronic igniters to operating...
Instructions for Use - Page 16
... adjustment is normal during initial use . If the flame is completely or mostly yellow, verify that the regulator is normal.
Figure 3: Checking Flame Characteristics Foreign particles in the gas line may cause an orange flame during the initial startup. This is set for the correct fuel. This should disappear with natural gas. Allow unit to make sure...
Instructions for Use - Page 26
..., place food in desired position before heating the oven.
• Preheat the oven when using a concealed bake element. For Best Results
• Use the cooking recommendations as a guide.
• Open the door as briefly as the guide for recommended rack positions. Getting the Most Out of Your Oven
General Tips
Pan Placement
Baking results are better if...
Instructions for Use - Page 44
... appliance's internal workings); (4) adjustment, alteration or modification of any kind; (5) a failure to comply with any applicable state, local, city, or county electrical, plumbing and/or...use, use or storage of an indoor product outdoors, use the Product, or visits where there is under no event shall Bosch have been altered, defaced, or removed; TO THE EXTENT ALLOWED BY LAW, THIS WARRANTY...
Installation Instructions - Page 8
...installation instructions. Plug the range into place, making sure to avoid damaging flooring.
___ 5. Additional Parts Needed for Hard-Wired Installations
Dual Fuel models only
• Flexible ...Electrical Installation, Gas Connection, Testing the Installation and Customer Service.
___ 3. (Optional) Remove the oven door to reduce the unit weight and to provide access to Protect Floor...
Installation Instructions - Page 10
... either 120/240 VAC or 120/208 VAC. Check local codes for use a new power cord. Note the grey box (E) designating the acceptable area on . Dual Fuel and Gas Models: The gas connection is adequate Contact your local utility company to verify that the present electric service to your range according to data plate for the 208/240 VAC...
Installation Instructions - Page 12
... this opening to the cabinet wall make sure the screws engage the frame of the cabinet, not the thin wall of the cabinet wall. Prepare Walls and Floor
Seal any obstructions (extra electrical or gas connections, etc.) so that the anti-tip bracket is moved.
Mount the bracket using a 1-1/4" wrench.
2. Do not use of fire - The range...
Installation Instructions - Page 13
... cord must be properly installed.Strain reliefs vary.
Dual Fuel Ranges - Frame grounded to gas ranges). Use only cord kits rated 125/250 volts (minimum), 30 amperes and labeled "For Use with your range cord must be removed from the range to terminal block.
Dual fuel ranges have a gas cooktop and an electric oven.
1. English 10
Feed range cord through the neu-tral conductor is...
Installation Instructions - Page 18
...valve and reapply leak detection fluid. 6. The gas connection is complete.
English 15
E D
D
B
C
B
B A
Gas Flow to Range
F
Item
A
Elbow;
It is to be conducted by the installer according to the instructions given in the range if connections may have been disturbed during rigid pipe testing.
1. Rigid Pipe Connector Method
If using a flexible connector, return to "Flexible...
Installation Instructions - Page 20
...slots.
MED LOW HIGH PROOF _+ ON/OFF
5.
Select the BAKE mode. Otherwise, continue with the rails attached to be tested for assistance.
Test the Rangetop Burners
Each burner must be...flame symbol. 2. Open door all the way to self open. Door must be removed and reinserted until seated on and the oven begins to test operation.
See the Use and Care Manual for proper ignition...
Installation Instructions - Page 21
... result as explained above, contact Bosch service for the correct fuel.
Soft Blue Flames: Normal for more information.
4.
Verify that the flame is too large, contact service. It should be blue with an inner and outer cone. Test each rangetop burner in and turn the knob to the flame symbol until the burner ignites.
2. Once the air has...
Installation Instructions - Page 4
... of the authority having jurisdiction. The qualified service agency is responsible for possible conversion from LP back to natural gas in the future
• This kit is used to convert dual fuel ranges and gas ranges from the gas supply piping system by a qualified service agency in the manufacturer's instructions supplied with its own pressure regulator. 9 IMPORTANT SAFETY...
Installation Instructions - Page 5
...have an I.D. Shut off the gas supply to the appliance prior to convert the appliance for use with an adjustable wrench.
4. Remove range power cord from electrical outlet or turn it over pressing... must be at breaker box
Procedure
Convert Pressure Regulator from the top of the cover plate so that the letters "LP" (rather than 6'. to the "OFF" position. 2. Gas Hex Cap
NA Pin
...
Installation Instructions - Page 6
... in Use and Care manual).
2. Reinsert screws in jet holder to natural gas.
4. Burner Grate Burner Cap Burner Base Orifice
Ignitor
Convert Cooktop Valves for burner to the top of oven cavity.
3.
Insert the socket driver with 5 screws. Replace screws. If your range is dual fuel your conversion is attached to light.
6. For gas range conversions, continue to detach electrical wires...
Installation Instructions - Page 7
... interior back panel of carbon monoxide.
5.
Test Electric Ignition
Turn on power at the breaker and return to all 5 screws gently. If a leak appears, turn orifice clockwise until all detection fluid residue. Adjust Bake Burner Orifice
The bake burner orifice is complete. CAUTION: Never check for Gas Leaks
Broil Orifice
.
Immediately switch off all leaks...
Installation Instructions - Page 8
... the low setting. 3. It should carry over , or surround, the entire burner. 4. Verify that the burner maintains a minimum, steady,
flame without going out.
Test Cooktop Burners:
Each burner must be tested for LP Gas. The burner will ignite after 30-75 seconds. Push down and turn the knob to "Convert Cooktop Valves for the correct fuel. Return to the ignition symbol...
Installation Instructions - Page 9
... Manual for troubleshooting information. More Closed: Less Blue Flame More Carryover Less Lifting or Blowing
Test Bake Burner
Test Ignition
Set the oven to maintain the temperature. Open the
shutter if it through the access hole in the Use and Care Manual. Refer to alter the flame characteristice. The oven burner air shutter is lifting or blowing or not...
Similar Questions
Disconnect Instructions For Bosch Dual Fuel Oven Pressure Regulator
I need to install a natural gas pressure regulator in a Bosch dual fuel range model HD17282U/03. How...
I need to install a natural gas pressure regulator in a Bosch dual fuel range model HD17282U/03. How...
(Posted by gary32993 5 years ago)
Bosch Dual Fuel Range/oven Model # Hd17152u/03
The oven will not heat up after trying several different heating settings.
The oven will not heat up after trying several different heating settings.
(Posted by dellga01 9 years ago)
Has Anyone Tried To Paint The Worn Knobs On Their Bosch Dual Fuel Range?
Like many people, the knobs on my Bosch Dual Fuel Range are showing wear after only two months. Si...
Like many people, the knobs on my Bosch Dual Fuel Range are showing wear after only two months. Si...
(Posted by natemom 12 years ago)
Bosch Dual Fuel Slide In Burner Issue
Two burners will not light. Gas it present
Two burners will not light. Gas it present
(Posted by kranksr 12 years ago)
Brand New Range, One Burner Has No Gas. Why?
Only 3 burners have gas, the other is nothing. I have removed the burner orifice and still nothing.
Only 3 burners have gas, the other is nothing. I have removed the burner orifice and still nothing.
(Posted by Freelancer66040 12 years ago)