Weber SP 100 NG Support and Manuals
Get Help and Manuals for this Weber item
View All Support Options Below
Free Weber SP 100 NG manuals!
Problems with Weber SP 100 NG?
Ask a Question
Free Weber SP 100 NG manuals!
Problems with Weber SP 100 NG?
Ask a Question
Popular Weber SP 100 NG Manual Pages
Owner Manual - Page 2
...
1. DANGER
Failure to follow the assembly instructions in your Weber Gas Barbecue. s Do not operate the Weber Gas Barbecue if there is not natural ...or attempted use charcoal or lava rock in this Owner's Manual may result in serious bodily injury or death, or ... be left unattended. Do not use a flame to correct the problem yourself. 3. s Improper assembly may still be present, and the...
Owner Manual - Page 3
... installation or improper maintenance or service, or failure to perform normal and routine maintenance, including but not limited to damage caused by this Limited Warranty.
Customer Service Center 250 South Hicks Road Palatine, IL 60067-6241 (708) 705-8660 (800) 446-1071
3 Before returning any parts, contact WeberStephen Products Co. Weber will return parts to replace such parts...
Owner Manual - Page 7
... a soap and water solution to check for gas leaks. (See Step "Check for reference. Call the Weber Customer Service Center toll free 1-800-446-1071 to our products, unfortunately an occasional error may occur. Have your owner's manual and serial number of the barbecue available for gas leaks.")
Note - On a small screw for example...
Owner Manual - Page 9
Check contents of hardware packs
Three burner control knobs
Three tool holders
Five tubing plugs (two are spares)
Support rod holder
Swing table end bracket
Two hinge pins (hardware size: 1/4 x 1 1/2 inch clevis pin) (actual size)
Five 1/4-20 x 2 inch bolts (actual size)
Six 1/4-20 x 1/2 inch ...
Owner Manual - Page 13
...c) Are the wing nuts under the frame brace. Do not use barbecue. Figure 7. Figure 8. Figure 9 (a).
Guide screw
(b) Figure 9
(a)
View from behind cooking box
(c) Thumb screws
Figure 8
13 Step 8 Add cooking box... left rear and left within the frame. Contact Weber-Stephen Customer Service.
Set the cooking box in the frame so the burner tubes are misaligned. b) Are the ends of the...
Owner Manual - Page 17
... of the quick disconnect.
WARNING: If there is properly engaged. Contact Weber-Stephen Customer Service. Figure 16 (c). Check for leaks by wetting the connections with water ... persists after checking for leaks. Figure 16 (b). c) Hose to manifold connection. Contact Weber-Stephen Customer Service. When leak checks are no sparks or open flame to apply it does not engage...
Owner Manual - Page 20
...30 pounds. Figure 25 (a). Call our Customer Service Center to tap it lightly with a hammer. The rod should swing freely inside the frame tube. To fully seat the bracket, you can slide... the lower support bracket. Swing the rod up so you may have to order a new part. Figure 25 (b). Step 19
Install swing table
You will need: swing table assembly, support rod, support rod holder ...
Owner Manual - Page 21
... table, accessory rack, three tubing plugs, thermometer and a hammer. Set the accessory rack in the down position.
21 Insert the thermometer into the ends of the cooking box. Figure 26 (d).
To fully seat the plugs, you may have to tap them lightly with a hammer. Step 20
Complete accessory installation
You will need: warming...
Owner Manual - Page 24
...Weber cookbook. The control settings High (H), Medium (M), Low (L), or Off (O) are still very reflective, may require the adjustment of burners tubes...Weber Gas Barbecue, make sure that contain citrus products or abrasive cleaning pads on conditions such as desired. Replacement...detailed cooking instructions. CAUTION: Do not clean your retailer or the Weber-Stephen Customer Service Center. ...
Owner Manual - Page 25
... burners are in the "General Maintenance" section of this manual. WARNING: Do not ignite burners while leak checking.
Since...OPERATE THE BARBECUE. WARNING: If there is a leak. Contact Weber-Stephen Customer Service. When leak checks are complete, turn gas supply OFF at ... pattern. Replace using only Weber authorized replacement hose. s Inspect the burners for gas leaks.
Check that ...
Owner Manual - Page 26
...gas in the venturi section of the burner tubes. Use a brass bristle brush to property....installed. General Maintenance
Weber Spider Stopper Guards
Your Weber Gas Barbecue, as well as any of the air shutter. Main Burner Flame Pattern
The Weber Gas Barbecue burners have been factory set for spiders and other insects access to be OFF and cool. Remove the manifold. (See Section "Replacing...
Owner Manual - Page 27
...burner lights with a match. Figure 12.
Crossover tube
Figure 12 h) To reinstall the burners, reverse ...Crossover Ignition System still fails to see Step "Install igniter" for gas leaks".)
Crossover Ignition System ...the corners of the burners and carefully set it down , and returns to ... Weber-Stephen Customer Service.
27 Pull the manifold and valve assembly out of the cooking box. Guide...
Owner Manual - Page 28
TROUBLESHOOTING & MAINTENANCE
Troubleshooting
Problem
Burners burn with a yellow or orange flame, in conjunction with the smell of the burner tube. Straighten fuel hose. If you can light the Front burner with a match? Clean thoroughly. (See Section "Periodic Cleaning".)
Is the bottom tray "dirty" and not ...
Owner Manual - Page 31
... to the store. Returning the part may occur. This will also void your owner's manual and serial number of any part that is missing, do not go back to our products, unfortunately an occasional error may not be ordered directly from Weber-Stephen Products Company by phone or mail. Parts List
All items are single quantities...
Owner Manual - Page 32
... number 1-800-446-1071. We wish your satisfaction. Our family here at Weber has worked hard to our products, an occasional error may occur. We also welcome
any comments or suggestions you
with any problems with parts or assembly.
For quicker service, please have regarding our products. While we give much attention to produce the...
Weber SP 100 NG Reviews
We have not received any reviews for Weber yet.