Schwinn Aerosport Support and Manuals
Get Help and Manuals for this Schwinn item
View All Support Options Below
Free Schwinn Aerosport manuals!
Problems with Schwinn Aerosport?
Ask a Question
Free Schwinn Aerosport manuals!
Problems with Schwinn Aerosport?
Ask a Question
Popular Schwinn Aerosport Manual Pages
Schwinn Owner's Manual - Page 3
... upside down)
3 The following manual is only a guide to assist you choose to write or call us concerning missing parts, service questions, operating advice, and/or assembly questions.
16 Trowbridge Drive Bethel, CT 06801 USA www.schwinnbikes.com
Service sƟcker locaƟon (Opposite side of maintaining and repairing your bicycle. The bicycle you have purchased is...
Schwinn Owner's Manual - Page 6
... SPEED BICYCLE
Get to know the parts of your bicycle. Your model may have additional accessories such as fenders, bags, carriers, etc.
Single speed bicycles vary greatly. Seat Rear reflector Seat post binder bolt or quick-release skewer
Seat stay Training wheel bracket
Rear sprocket Spokes
Handlebar grip Brake control cable
Head set Head...
Schwinn Owner's Manual - Page 7
...bicycles vary greatly. PARTS IDENTIFICATION
MULTI SPEED BICYCLE
Get to know the parts of your bicycle. Your model may have additional accessories such as fenders, bags, carriers, etc.
Gear control cable
Freewheel
Wheel reflector Rim
Seat Rear reflector
Seat post Quick release
Rear Brake
ShiŌ lever Handlebar stem
Head set... with assembly, maintenance, and troubleshooting.
Schwinn Owner's Manual - Page 10
.... They are designed to be ridden on paved roads only. To be taken off -road, cyclocross, or touring with racks and panniers.
BEFORE YOU RIDE
ASTM F2043
Suitable for road riding
(only)
ASTM CONDITION 12
INTENDED1 NOT INTENDED1
MAXIMUM WEIGHT LIMIT1, 3
"This is a set of conditions for the operation of a bicycle on a regular...
Schwinn Owner's Manual - Page 11
... the air landing hard and hammering through things.
Some of a bicycle that includes Condition 1 and Condition 2 as well as hardcore mountain...
INTENDED1 NOT INTENDED1
MAXIMUM WEIGHT LIMIT1, 3
"This is a set of conditions for the operation of tire contact with the ground ... intermediate terrain (e.g., hilly with relatively wide tires that are designed to 30cm (12in.) or less." For use , or...
Schwinn Owner's Manual - Page 13
... must also be seen and recognized as an integral part of the state where you know your bicycle. Federal regulations require every bicycle (over 16") to enforce these rules with all ... brackets regularly to be wearing a helmet. Many states require specific safety devices. These reflectors are designed to comply with your bicycle. Make sure you ride and to pick up and reflect ...
Schwinn Owner's Manual - Page 19
... of CPSC compatible reflectors. • Ensure bicycle is equipped with street lighting, if possible.
©2010
19 Slow down and use familiar roads with a full set of correctly positioned and clean reflectors. • Refer to p. 15 of this manual. • Use a properly functioning lighting set of a white front lamp and a red rear lamp. •...
Schwinn Owner's Manual - Page 27
... to properly assemble this manual. We recommend that you have purchased the bicycle already fully assembled and ready to properly assembly, repair, or maintain your experience or ability to ride OR in the shipping carton in this unit, please consult a qualified specialist before riding. The following instructions will enable you need replacement parts or have doubts...
Schwinn Owner's Manual - Page 49
...; After all traffic laws. Service your adjustments are attached and all your bicycle regularly by referring to the relevant...to the bicycle and injury to a professional bicycle shop. ASSEMBLY
©2010
49
Failure to do this manual, OR take...Correct maintenance of your bicycle will allow you encounter any problems, refer to the appropriate section and make any trouble areas. Make sure ...
Schwinn Owner's Manual - Page 51
... bicycle. When cleaning, use a gas station service pump to inflate bicycle tires. Check the following potential problems:
• Dirty or greasy rims. CAUTION: These can render your brakes ineffective. To check, pump the tire up to pull tire into place. A slow leak caused by a specialist.
• Loose hub bearings: Lift each ride. Again, spoke repairs...
Schwinn Owner's Manual - Page 55
...in the pedal bearings then adjustment, lubrication or replacement is usually possible to the internal bearings and axle...bicycle refers to all parts that transmit power to the rear wheel including the pedals, chain, chainwheel, crank set...cannot be disassembled to allow this manual and further assistance should be ... of this , but on less complex models it centered, and re-tighten the fixing...
Schwinn Owner's Manual - Page 57
... turning the spindle clockwise. 3. Do not attempt service without access to get oil on the tires or rim braking surfaces.
©2010
57
Pack the ball bearing retainers with light oil at least every month, or after use in order to a detailed bicycle repair manual for any damaged parts.
Rear Sprocket Front Chainwheel (Fig. 4.11...
Schwinn Owner's Manual - Page 63
Problem
Possible Cause
Gear shifts not working properly
• Derailleur cables sticking/...; Adjust indexing
• Replace chainring, sprockets and chain
• Replace chain • Lubricate or replace link • Seek advise at a bicycle shop
• Re-true if possible, or replace • Tighten mounting bolts • Repair or replace chainring/set • Adjust derailleur travel...
Schwinn Owner's Manual - Page 66
... retain as a record of your purchase.
*Please retain your sales receipt for any possible warranty claims.
Your Name:
Address:
Date Purchased:
Place of Purchase:
Model & Brand Information:
Wheel Size:
Color:
Service sƟcker locaƟon (Opposite side of the serial number)
Serial Number: Model #:
WARRANTY
66
©2010
Serial number locaƟon...
Schwinn Owner's Manual - Page 67
... to damage due to improper installation of potential problems, inappropriate use or abuse. WARRANTY
16 Trowbridge Drive Bethel, CT 06801 USA Retailer Service: 1-800-843-2453 www.schwinnbikes.com
©2010
67 These parts are guaranteed against defective materials and workmanship for stunting or jumping. 2. Your bicycle has been designed for general transportation and recreational...
Schwinn Aerosport Reviews
We have not received any reviews for Schwinn yet.