Poulan PP208EPS24L Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan PP208EPS24L manuals!
Problems with Poulan PP208EPS24L?
Ask a Question
Free Poulan PP208EPS24L manuals!
Problems with Poulan PP208EPS24L?
Ask a Question
Popular Poulan PP208EPS24L Manual Pages
User Manual - Page 2
... serious injury.
Look for any repairs, adjustments or inspections. YOUR SAFETY IS INVOLVED.
CAUTION: Muffler and other foreign objects.
2. Training
1. Exercise caution to clear gravel or crushed rock surface.
7.
Know how to observe the following safety instructions could result in order to a running (except when specifically recommended by the manufacturer for...
User Manual - Page 3
... or not in reverse.
13. The instructions will enable you experience any enclosure.
3.
SHUT THE ENGINE OFF!
2. TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 14-15
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 19
ASSEMBLY / PRE-OPERATION 5-7
TROUBLESHOOTING 20
OPERATION 8-13
REPAIR PARTS 21-39
MAINTENANCE SCHEDULE 14...
User Manual - Page 5
... two (2) screws securing the auger housing to lower handle.
2. Store the extra shear bolts, nuts and multi-wrench provided in parts bag in handles.
Install in lower holes in the toolbox. ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety before you attempt to assemble or operate your snow thrower, all...
User Manual - Page 12
... in the Maintenance section of this manual.
Do not overfill.
• ..., then moving parts to desired position. See Storage Instructions for a few... surface conditions. To avoid engine problems, the fuel system should be...it may be emptied before requiring replacement. Use fresh fuel next season....can easily be reversed, providing additional service before storage of the auger housing...
User Manual - Page 14
...parts to service this manual.
Replace belts if they are of this snow thrower does not cover items that have been subjected to malfunction and pose a risk of this manual. The belts on this manual...the warranty, operator must maintain snow thrower as instructed in the Service and Adjustments section of special construction and should replace the spark plug and check belts for wear. ...
User Manual - Page 15
... is if service has been performed on dipstick.
10.
Spark plug type and gap setting are lifetime ...service classification SG-SL. Wipe off any spilled oil from snow thrower and engine.
6. For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual.
MUFFLER
Inspect and replace... disconnect spark plug wire from spark plug. Install left side wheel may be removed from running...
User Manual - Page 17
SERVICE AND ADJUSTMENTS
TO REPLACE BELTS (See Fig. 22)
The auger and traction drive belts are damaged or begin to slip from wear, they should be replaced.
The V-belts on idler, install new traction drive ... COVER" in the Assembly / Pre-Operation section of this manual.
1. SEPARATE SNOW THROWER - INSTALL ENGINE PULLEY - Make sure belt is removed, have your snow thrower are of the ...
User Manual - Page 18
... due to suspected carburetor problems, take your snow thrower to the end of the shaft - KLIK PIN (INSTALL IN OUTER HOLE OF AXLE ONLY)
OUTER HOLE
AXLE
ENGINE
See engine manual. If you think the engine-governed high speed needs adjusting, contact a service center/department, which is factory set for your model snow thrower. Adjust until...
User Manual - Page 19
... and/or dirt in your gasoline will cause problems.
• If possible, store your snow ...manual).
3. Inspect moving parts for 30 days or more. Touch up all dirt, grease, leaves, etc.
Allow the engine to cool before painting. Store in any enclosure. Add stabilizer to gasoline in minimizing the formation of this manual). ENGINE OIL
Drain oil (with engine warm) and replace...
User Manual - Page 20
... & carburetor, refill with ice or snow. 4. Drive belt is worn. 3. Check / replace drive belt. drive / slowing 2. Friction drive wheel is worn.
1. Contact an authorized service center/department. Auger belt is
disconnected. 9.
Out of power
1. Spark plug wire is worn. 3. Prime as instructed in STOP position
(or ON/OFF switch is off valve to...
User Manual - Page 25
REPAIR PARTS SNOW THROWER - NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. ITEMS 15 AND 16 ARE SERVICE PART NUMBERS TO ALLOW PURCHASE OF INDIVIDUAL ITEMS IF NECESSARY. MODEL PP208EPS24L (96198003801) CONTROL PANEL / DISCHARGE CHUTE
5
7 15
3 16
*14 *11
2
4
6 *10
KEY NO.
1 2 3 4 5 6 7 8 ...
User Manual - Page 26
... given in U.S. ITEMS INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY.
2
KEY PART NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
26 MODEL PP208EPS24L (96198003801) CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *7
*6
KEY NO.
1 2 *3 *4 *5 *6 *7
PART NO.
428272 17501010 420678 405932 420675 428273 428310
DESCRIPTION
LEVER/CABLE ROTATOR...
User Manual - Page 28
... SUPPORT WELDMENT SCREW 5/16−18 X .750 SCREW 3/8−16 X 1.00
4 3
4 4
01-05-013-A
NOTE: All component dimensions given in U.S. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
28 REPAIR PARTS SNOW THROWER -
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL PP208EPS24L (96198003801...
User Manual - Page 39
...RT SPD/LEV/PWRST OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
39 MODEL PP208EPS24L (96198003801) DECALS
1
2
9
6
3
7
1
KEY NO.
1 2 3 6 7 9 - - - inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
User Manual - Page 40
...On products equipped with a Battery, we will replace, without charge for parts or labor incurred in replacing parts, any parts submitted for the movement of any battery which we find to be maintained in accordance with the instructions furnished.
4. Exclusions: Excluded from this Warranty, please contact:
HOP Outdoor Products Customer Service Dept. 9335 Harris Corners Parkway Charlotte...
Poulan PP208EPS24L Reviews
Do you have an experience with the Poulan PP208EPS24L that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!