Poulan 96198002501 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan 96198002501 manuals!
Problems with Poulan 96198002501?
Ask a Question
Free Poulan 96198002501 manuals!
Problems with Poulan 96198002501?
Ask a Question
Popular Poulan 96198002501 Manual Pages
User Manual - Page 1
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
961980025
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in the U.S.A. Always Wear Eye Protection During Operation
424714 11.03.08 SR Printed in serious injury.
User Manual - Page 2
...instructions on the machine and in the manual(s) before operating this is generally a warning of California to observe the following safety instructions ...parts become extremely hot during operation or while performing an adjustment or repair to a running (except when specifically recommended by the manufacturer for use of all clutches and shift into neutral before starting when setting...
User Manual - Page 3
... any enclosure.
3. We have stopped rotating.
3.
TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE SCHEDULE 13
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-37
MAINTENANCE 13-14 3 WARRANTY 40 Open the outside doors; Never operate the snow thrower...
User Manual - Page 4
....
4
nuts and multi-wrench provided in parts bag in assembly, operation and maintenance of your snow thrower.
HOW TO SET UP YOUR SNOW THROWER
TOOL BOX (See ...1-3/4 (198636)
(2) SPACERS (198638)
(2) LOCKNUTS 1/4-20
(73800400)
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety before you attempt to the pallet.
4. Remove the two (2) screws securing the auger...
User Manual - Page 11
...easily be emptied before requiring replacement. Replace a damaged or worn scraper...can be reversed, providing additional service before storage of tank filler ... become worn. See Storage Instructions for current surface conditions. ...problems, the fuel system should be picked up and thrown by loosening the hex nuts, then moving parts...and formation of this manual. three-wire grounded system...
User Manual - Page 13
... any maintenance. NOTE: Use only Original Equipment Manufacturer (OEM) parts to service this manual).
/ 19-24.5 N-m). LUBRICATION CHART
SAE 5W-30 Motor Oil...instructed in the Service and Adjustments section of this manual. To receive full value from your nearest dealer. All adjustments in this manual should be checked at least once each season.
• Once a year, you should be replaced...
User Manual - Page 14
...snow thrower and engine.
6.
Install drain plug and tighten securely.
5. MUFFLER
Inspect and replace corroded muffler as it cannot come in the "PRODUCT SPECIFICATIONS" section of this manual.
9.
Change the oil after.... Be sure dipstick cap is if service has been performed on oil fill cap/dipstick for accurate reading.
SPARK PLUG
Replace spark plug at the factory. We do...
User Manual - Page 15
... a authorized service centre/department. Use only original equipment shear bolts as supplied with your snow thrower.
4. If impeller does not turn when auger control lever is engaged, check to see "TO CONTROL SNOW DISCHARGE" in the impeller, the capscrews are of this manual.
and should be replaced at the same time. Install 1/4-20 locknuts...
User Manual - Page 16
...10. INSTALL ENGINE PULLEY - INSTALL BELT COVER and two (2) screws. See "INSTALL DISCHARGE CHUTE / CHUTE ROTATER HEAD" in this section of auger pulley only.
12. SERVICE AND ADJUSTMENTS
WARNING: Belt replacement requires ...you bring snow thrower completely together and check carefully for proper routing of this manual.
4. Wipe up on the auger belt and squeeze sides together above pulley...
User Manual - Page 17
... stabilizer to allow the stabilizer to a qualified service center. SERVICE AND ADJUSTMENTS
TO REMOVE WHEELS (See Fig. 22)
• Remove the klik pin and remove wheel from your local parts dealer. If you think the engine-governed high speed needs adjusting, contact a qualified service center, which is factory set for pushing or transporting the snow thrower...
User Manual - Page 19
...
9.
See "IF RECOIL STARTER HAS FROZEN" in the Operation section of this manual. 7. Drive belt is worn. 3. Out of traction 1. Primer not depressed. 7. Water in STOP position. 5. Replace spark plug. 10. Engine idles or runs roughly
1. Contact a qualified service centre. Replace damaged parts.
Loss of fuel. 4.
of pulley. 2. Friction drive wheel is flooded. 8. Auger belt...
User Manual - Page 25
... FOR SERVICE PARTS ONLY. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. NO.
1
420337
2
17501010
*3
420678
*4
420677
*5
420675
*6
420674
DESCRIPTION
LEVER/CABLE ROTATOR ASSEMBLY SCREW 10−24 X .625 ROTATOR HEAD ROTATOR PIVOT BRACKET PULLEY PIVOT CABLE ASSEMBLY
*4
01.09.007-A
*5
NOTES: 1. REPAIR PARTS SNOW THROWER...
User Manual - Page 26
...SUPPORT
3
17000512
BOLT 5/16−18 X .750
4
17000616
SCREW 3/8−16 X 1.00
2 4
3
4
4
01.05.004-B
4
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts... HARNESS BULB
1
KEY PART
NO. NO. MODEL NO. 961980025 (96198002501) HANDLES
3 2
71
4 5
6
5
4
KEY PART NO. Failure to do...
User Manual - Page 37
...Original Equipment Manufacturer (O.E.M.) replacement parts. PART NO.
181037 424610 181035 181042 424609 181033 415391 415390 415475 424714 424715
DESCRIPTION
DECAL, DANGER DECAL, POULON PRO, 8.0 HP/27" DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, POULON PRO DECAL, INSTRUCTION DECAL, TRACTION LEVER DECAL, AUGER LEVER DECAL, SPEED CONTROL OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All...
User Manual - Page 40
... any parts submitted for replacement under this Warranty, please contact:
Poulan Pro Customer Service Department 1030 Stevens Creek Road Augusta, GA 30907 USA
In Canada contact:
Poulan Pro, Customer Service Department 5855 Terry Fox Way Mississauga, Ontario L5V 3E4
giving the complete mfg. Exclusions: Excluded from this warranty must return the product to an authorized service dealer. The...
Poulan 96198002501 Reviews
Do you have an experience with the Poulan 96198002501 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!