Poulan 96198002500 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan 96198002500 manuals!
Problems with Poulan 96198002500?
Ask a Question
Free Poulan 96198002500 manuals!
Problems with Poulan 96198002500?
Ask a Question
Popular Poulan 96198002500 Manual Pages
User Manual - Page 2
... of operation clear of trouble.
5. Be thoroughly familiar with care;
WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of all units with extreme care. Never allow adults to observe the following safety instructions could result in moving parts. Failure to operate the...
User Manual - Page 3
... your snow thrower.
• Follow the instructions under "Maintenance" and "Storage" sections of your hands. TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE SCHEDULE 13
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-37
MAINTENANCE 13-14 3 WARRANTY...
User Manual - Page 4
... you with the exception of the product. Remove all accessible loose parts and parts boxes from carton and check carton thoroughly for shipping purposes. HOW TO SET UP YOUR SNOW THROWER
TOOL BOX (See Fig. 8)
REMOVE SNOW...BOLTS 1/4-20 x 1-3/4 (198636)
(2) SPACERS (198638)
(2) LOCKNUTS 1/4-20
(73800400)
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in the parts bag.
User Manual - Page 9
...of any adjustments or repairs. Do not use choke to stop the forward
or reverse movement of the snow thrower. Full throttle offers the best snow thrower performance.
Set the deflector low to... stop engine. HOW TO USE YOUR SNOW THROWER
Know how to operate all moving parts to stop throwing snow. Remove (do...
User Manual - Page 11
...problems, the fuel system should be reversed, providing additional service...replacement. See Storage Instructions ...for current surface conditions. After considerable use the electric starter if your snow thrower has been shipped, from the factory, already filled with oil.
1.
WARNING: Do not use it can damage the fuel system of this manual... then moving parts to lowest ...
User Manual - Page 13
... every 50 hours of operation and replace if necessary. LUBRICATION
Keep your snow thrower well lubricated
(See "LUBRICATION CHART").
A new spark plug will need to the snow thrower. The belts on this manual. Tire sealant also prevents tire dry rot
(OEM) belts available from your local parts dealer. Check belts for wear. Check for...
User Manual - Page 14
...install klick pin into proper hole in wheel axle (See "TO REMOVE WHEELS" in the Service and Adjustments section of this manual.
9. Install... where it cannot come in the "PRODUCT SPECIFICATIONS" section of this manual).
7. Keep finished surfaces/wheels free of your... setting are lifetime lubricated and require no lubrication. MUFFLER
Inspect and replace corroded muffler as it cannot come ...
User Manual - Page 15
...replace the shear bolts:
1. Wait for all moving parts to slip from spark plug.
Install 1/4-20 locknuts and tighten securely. 15
(OEM) belts available from spark plug. SERVICE AND ADJUSTMENTS
WARNING: To avoid serious injury, before performing any service... auger control lever is recommended that both of this manual.
Wait for all controls and move throttle control to...
User Manual - Page 16
... PULLEY - SERVICE AND ADJUSTMENTS
WARNING: Belt replacement requires separation of belts. Serious personal injury and/ or damage to be fully seated in groove of auger pulley only.
12. Install clutch rod in the Assembly / Pre-Operation section of this manual. If auger belt has become dislodged from around and inside belt keepers.
10. Install the...
User Manual - Page 17
...problems, take your local parts dealer. sand lightly before storing in the tank inside a building where fumes may be stored for proper engine speed. Add stabilizer to a qualified service center.
Overspeeding the engine above the factory high speed setting...manual).
17
ENGINE OIL
Drain oil (with engine warm) and replace...only. IMPORTANT: When installing wheel, be affected...
User Manual - Page 19
... carburetor, refill tank with fresh gasoline. 11. Clean or replace muffler. Replace damaged parts.
Contact a qualified service centre. Insert safety ignition key.
3. Choke is worn.
1. Drive belt is in need of this manual. TROUBLESHOOTING
See appropriate section in fuel. 5. Fill fuel tank. 4. Water in manual unless directed to OPEN position.
2. Drain fuel tank and carburetor...
User Manual - Page 21
... void your warranty.
21 REPAIR PARTS SNOW THROWER - - MODEL NO. 961980025 (96198002500) AUGER HOUSING / IMPELLER ASSEMBLY
2
1
01.07.018-A
KEY NO.
1 2
PART NO.
420495X479 420496X479
DESCRIPTION
AUGER 27 LH AUGER 27 RH
3
4 2
4
KEY PART NO. NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts.
DESCRIPTION
1
174762X479 SKID PLATE...
User Manual - Page 25
...*4
01.09.007-A
*5
NOTES: 1.
ITEMS INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY. MODEL NO. 961980025 (96198002500) CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *6
*6
KEY PART NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. NOTE: All component dimensions given in U.S. Failure to do so could be hazardous...
User Manual - Page 37
... (O.E.M.) replacement parts. NO.
1
181037
2
424610
3
181035
4
181042
5
424609
6
181033
7
415391
8
415390
9
415475
- -
424549
- -
424550
DESCRIPTION
DECAL, DANGER DECAL, POULON PRO, 8.0 HP/27" DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, POULON PRO DECAL, INSTRUCTION DECAL, TRACTION LEVER DECAL, AUGER LEVER DECAL, SPEED CONTROL OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH...
User Manual - Page 40
... replacement under this Warranty, please contact:
Poulan Pro Customer Service Department 1030 Stevens Creek Road Augusta, GA 30907 USA
In Canada contact:
Poulan Pro, Customer Service Department...instructions furnished. For a period of the authorized dealer from this warranty must return the product to products which we will repair or replace, at our option, without charge for parts...
Poulan 96198002500 Reviews
We have not received any reviews for Poulan yet.