Poulan 961980022 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan 961980022 manuals!
Problems with Poulan 961980022?
Ask a Question
Free Poulan 961980022 manuals!
Problems with Poulan 961980022?
Ask a Question
Popular Poulan 961980022 Manual Pages
User Manual - Page 2
...repairs. BECOME ALERT!!! WARNING: Always disconnect spark plug wire and place it where it cannot contact plug in moving parts. Caution should start to prevent accidental starting when setting...the nozzle in the manual(s) before
trailer bed ...repairs, adjustments or inspections. Never allow children to a running (except when specifically recommended by the manufacturer for all instructions...
User Manual - Page 3
...instructions under "Maintenance" and "Storage" sections of this owner's manual. Allow the engine to cool before storing in reverse.
13. Maintain or replace safety and instruction...SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 16-18
CUSTOMER RESPONSIBILITIES 3
STORAGE 18
ASSEMBLY / PRE-OPERATION 5-7
TROUBLESHOOTING 19
OPERATION 8-13
REPAIR PARTS... in any problem you experience any...
User Manual - Page 5
...SET UP YOUR SNOW THROWER
TOOL BOX (See Fig. 10)
A toolbox is located on your snow thrower, all accessible loose parts and parts boxes from carton and check carton thoroughly for additional loose parts.
Remove all four corners of parts...these instructions and this manual in handles.
Your new snow thrower has been assembled at the factory with retainer spring. Remove all parts and ...
User Manual - Page 12
...loosening the hex nuts, then moving parts to separation and formation of acids during...securely.
See Storage Instructions for current surface conditions. FIG. 21
12 Replace a damaged or... tight, wait for opposite side of this manual. Do not overfill.
• To change...
To avoid engine problems, the fuel system should be reversed, providing additional service before storage of ...
User Manual - Page 14
... better and last longer.
• Follow the maintenance schedule in this manual.
Check V-belts for deterioration and wear after every 50
TIRES
• Maintain proper air pressure in the Service and Adjustments section of operation and replace if necessary. Using other
parts dealer. Failure to do so can harm rubber. Check controls to be sure...
User Manual - Page 15
... WHEELS" in the "PRODUCT SPECIFICATIONS" section of continuous use only Ronex ED #1 grease.
Tighten oil fill cap / dipstick securely each five (5) hours of this manual).
1. Install drain plug and tighten securely.
5. Be sure dipstick cap is on oil. Wipe off any dirt or trash. Spark plug type and gap setting are covered to the...
User Manual - Page 16
.... Remove belt cover. • Replace belt cover by installing cover and screws and
tighten securely... to STOP position.
Disengage all moving parts to any service or adjustments: 1. CHUTE DEFLECTOR
The...install two (2) new 1/4-20 x 1-5/8" capscrew/shear bolts. If impeller does not turn when auger control lever is discharged, see if one or both of this manual. Wait for all moving parts...
User Manual - Page 17
...parts...
7. SERVICE AND ...manual. Wipe up on your assistant slowly raises handles to the end of special construction and should fall during the belt changing process. RELIEVETENSIONONTRACTIONDRIVEBELTIDLER and remove traction drive belt from your model snow thrower.
NOTE: To seal punctures or prevent flat tires due to the ground.
6. IMPORTANT: When installing wheel, be replaced...
User Manual - Page 18
... (called gasohol or using fuel stabilizer. Replace with gasoline in the Maintenance section of this manual).
2. IMPORTANT: Never cover snow thrower while engine/ exhaust area is factory set for a period of this manual.
4.
ENGINE SPEED
Never tamper with the engine governor, which allows condensation to form and will cause problems.
• If possible, store your...
User Manual - Page 19
... ignition key.
3. Replace damaged parts. Recoil starter is in manual unless directed to spark plug.
9. Connect wire to a qualified service centre. Reduce speed and width of pulley.
2. Choke is hard to OFF position. 2. Check / reinstall drive belt. Dirty or clogged muffler.
1. If vibration remains, contact a qualified service centre.
Prime as instructed in the...
User Manual - Page 21
...be hazardous, damage your snow thrower and void your warranty.
21 inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL 961980022 (96198002200)
AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ...−18 X .750 GEARBOX COVER LH
NOTE: All component dimensions given in U.S. REPAIR PARTS
SNOW THROWER -
User Manual - Page 26
MODEL 961980022 (96198002200)
CONTROL PANEL / DISCHARGE CHUTE
5
7 14
3 15
*13
KEY NO.
1 2 3 4 5 6 7 *8 *9 *10 *11 *12 *13 14 15
PART NO.
404770X428 ... (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
26 REPAIR PARTS
SNOW THROWER -
NOTE: All component dimensions given in U.S. ITEMS 14 AND 15 ARE SERVICE PART NUMBERS ...
User Manual - Page 30
...01.05.002-B
NOTE: All component dimensions given in U.S.
REPAIR PARTS HANDLES
SNOW THROWER - inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
30 MODEL 961980022 (96198002200)
KEY NO.
1 2 3 4 5 6 7 8
PART NO.
413927 178668 178666 184471 175262 417760...
User Manual - Page 39
... 420925 420926
DESCRIPTION
DECAL, DANGER DECAL, POULAN PRO, 11 HP / 30" DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, POULAN PRO DECAL, INSTRUCTION DECAL, LH TRIGGER DECAL, RH TRIGGER DECAL, SPEED CONTROL DECAL, REMOTE DEFLECTOR CONTROL OWNER'S MANUAL, ENGLISH OWNER'S MANUAL, FRENCH
NOTE: All component dimensions given in U.S. MODEL 961980022 (96198002200)
9
8
2 4 1
3
6
5
10
7
KEY NO...
User Manual - Page 40
... replacing parts, any unanswered questions concerning this Warranty are the responsibility of the authorized dealer from the date of original purchase.
4. This is a limited Warranty within the meaning of how long an implied Warranty may last, so the above limitations or exclusions may have any part which vary from this Warranty, please contact:
Poulan Pro Customer Service...
Poulan 961980022 Reviews
We have not received any reviews for Poulan yet.