Poulan 96198002000 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan 96198002000 manuals!
Problems with Poulan 96198002000?
Ask a Question
Free Poulan 96198002000 manuals!
Problems with Poulan 96198002000?
Ask a Question
Popular Poulan 96198002000 Manual Pages
User Manual - Page 1
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
961980020
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
Always Wear Eye Protection During Operation
415308 Rev 1 09.19.07 TH Printed in serious injury. Failure to do so can result in the U.S.A.
User Manual - Page 2
... manual(s) before starting the engine (motor).
3. it cannot contact plug in moving parts...specifically recommended by the manufacturer for any adjustments while the engine (motor) is spilled on a truck
thrower for all units with the controls and the proper use a nozzle lock-open device.
(g) Replace gasoline cap securely and wipe up , transporting, adjusting or making any repairs...
User Manual - Page 3
...-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-31
MAINTENANCE 13-14 3 WARRANTY 32 6. Disengage power to cool before storing in safe working .
10. Always use your nearest authorized service center. Allow the engine to the collector/impeller when snow thrower is in any problem you to be sure of your purchase of this manual.
Disconnect...
User Manual - Page 4
Remove all four corners of carton and lay panels flat.
3.
Remove all parts and hardware you attempt to ensure proper tightness.
2. PARTS PACKED SEPARATELY IN CARTON
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety before you assemble must be tightened securely. The toolbox is provided on top of your snow thrower...
User Manual - Page 11
...Instructions for current surface conditions. Skid plates are adjusted to cut through deep snowdrifts that can be reversed, providing additional service before storage of acids during storage. Objects such as a paved driveway or sidewalk, place skid plates in the highest position (lowest scraper clearance) to bottom of this manual. eTniglyh.teTnighsetecnurseelyc.urely. Replace... problems,...
User Manual - Page 13
...unit. To receive full value from the warranty, operator must maintain snow thrower as instructed in this manual).
• Keep tires free of gasoline and oil, which can harm rubber. ...5W-30 Motor Oil
See "ENGINE" in the Service and Adjustments section of operation and replace if necessary. Using other
local parts dealer. MAINTENANCE
GENERAL RECOMMENDATIONS
The warranty on your snow thrower...
User Manual - Page 14
...manual.
9. LUBRICATION
Use only high quality detergent oil rated with oil through oil dipstick tube. Refill engine with API service classification SG-SL. Spark plug type and gap setting... engine manual. Install left...service has been performed on oil fill cap/dipstick for accurate reading. MUFFLER
Inspect and replace corroded muffler as it cannot come in the "PRODUCT SPECIFICATIONS...
User Manual - Page 15
...are designed to break, preventing damage to the top of this manual. SHEAR BOLTS (See Fig. 20) AUGER SHEAR BOLTS
AUGER...service or adjustments: 1.
Make sure the augers and all moving parts to slip from your snow thrower.
4.
To replace the capscrew/shear bolts:
1. SERVICE AND ADJUSTMENTS
WARNING: To avoid serious injury, before performing any other
and install...
User Manual - Page 16
...ft. Drain gasoline from fuel tank into the square hole in groove of this manual. Remove bolt, lockwasher and flat washer securing pulley to use the innermost hole ...traction drive belt from fire or flame. IMPORTANT: When installing wheel, be removed from snow thrower. SERVICE AND ADJUSTMENTS
WARNING: Belt replacement requires separation of auger pulley only. Belt
must be raised...
User Manual - Page 17
... factory set for damage, breakage and wear. CYLINDER
1. Replace with...manual.
4. Pour one season to another.
• Replace your gasoline can if your can be dangerous and will not be purchased from your snow thrower with the engine governor, which leads to rust. store it from dust and dirt.
• Cover your local parts dealer. SERVICE...to suspected carburetor problems, take your ...
User Manual - Page 18
....
1.
Replace damaged parts.
Choke ...instructed in STOP position. 5. Clean or replace muffler. Water in manual unless directed to a qualified service centre.
Auger belt is
disconnected. 9. Spark plug wire is worn. 3. Wait a few minutes before restarting, DO NOT prime. 8. Fuel tank cap is in OFF position. 6. Contact a qualified service centre.
TROUBLESHOOTING...
User Manual - Page 23
... replacement parts.
REPAIR PARTS
SNOW... THROWER - Failure to do so could be hazardous, damage your snow thrower and void your warranty.
23 DESCRIPTION
1 414280
Knob, Lever
2 17501010 Screw #10-24 x 5/8
3 198475
Control Assembly, Deflector
4 73800600 Nut, Lock 3/8-16
5 19131316 Washer, Flat 3/8
6 404974
Control Assembly, Chute Rotater
7 405784X479 Support...
User Manual - Page 29
... Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS
SNOW THROWER - DESCRIPTION
27 851084
Screw, Hex Head 3/8-24 x 1-3/8
28 155452
Guide, Belt
29 192213
Belt Cover Assembly
...
Spring, Traction Idler Pulley, Idler (2-1/4) Engine, Tecumseh, Model Number OH318SA (For engine service and replacement parts, call Tecumseh Products at 1-800-558-5402) Screw, ...
User Manual - Page 31
..., Tapping 5/16-18 x 5/8
KEY PART NO. REPAIR PARTS
SNOW THROWER - MODEL 961980020 (96198002000)
WHEELS / DECALS
KEY PART NO.
NO.
1 181037 2 199315 3 181035 4 181042 5 199316 6 181033 9 415475 10 183730 11 415399 12 415398 - - 415308 - - 415309
DESCRIPTION
Decal, Danger Decal, Poulan, HP / CM Decal, Danger, Deflector Decal, Danger Decal, Poulan Decal, Instruction Decal, Speed Control Decal...
User Manual - Page 32
... the product to an authorized service dealer. ID#, serial number and ...parts submitted for parts or labor incurred in accordance with the instructions furnished.
This Warranty is limited to 90 days from this Warranty, please contact:
Poulan Customer Service...specific legal rights, and you have any part which we will repair or replace, at our option, without charge for replacement...
Poulan 96198002000 Reviews
Do you have an experience with the Poulan 96198002000 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!