Poulan 96198001801 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan 96198001801 manuals!
Problems with Poulan 96198001801?
Ask a Question
Free Poulan 96198001801 manuals!
Problems with Poulan 96198001801?
Ask a Question
Popular Poulan 96198001801 Manual Pages
User Manual - Page 1
Failure to do so can result in the U.S.A. Always Wear Eye Protection During Operation
415332 Rev 2 09.26.07 TH Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
961980018
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
... when setting up spilled fuel.
(h) If fuel is to cause cancer and birth defects or other such structures or buildings. Do not use snow thrower on or cross-
(b) Never add fuel to observe the following safety instructions could result in reverse. Never fill fuel tank indoors.
3.
Failure to a running (except when specifically recommended...
User Manual - Page 3
...SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 20-31
MAINTENANCE 13-14 3 WARRANTY 32 Open the outside doors; Never operate the snow thrower without good visibility or light. Always use .
14. Maintain or replace safety and instruction... owner's manual. 6. ...
User Manual - Page 4
...
1.
Use the correct tools as nuts, washers, bolts, etc., necessary to ensure proper tightness.
2. Store the extra shear bolts, nuts and multi-wrench provided in parts bag in the toolbox. PARTS PACKED SEPARATELY IN CARTON
ASSEMBLY / PRE-OPERATION
Read these instructions and this manual in its entirety before you attempt to lower handle.
5.
User Manual - Page 11
...with a minimum of this manual.
Use fresh fuel next ...service before storage of tank filler neck.
Drain the gas tank, start the engine and let it can be emptied before requiring replacement...problems, the fuel system should be used within 30
days to operate on dipstick is reversible. Replace a damaged or worn scraper bar.
three-wire grounded system. See Storage Instructions...
User Manual - Page 13
... abuse or negligence. LUBRICATION CHART
SAE 5W-30 Motor Oil
See "ENGINE" in the Service and Adjustments section of this manual.
The belts are not adjustable. Replace belts if they are functioning properly. The V-belts on this manual. Using other
local parts dealer.
Check controls to be purchased from your
(OEM) belts available from your nearest...
User Manual - Page 14
..., drive disc and friction wheel require no maintenance. Pour slowly. MUFFLER
Inspect and replace corroded muffler as it cannot come in shortened engine life. Clean the outside of this manual.
9. Place wire where it cannot come in the "PRODUCT SPECIFICATIONS" section of your snow thrower. The only time the lubricant needs attention is...
User Manual - Page 15
... ignition key.
If the belts are of special construction and should be replaced. Wait for all moving parts to stop .
2. Place wire where it should be replaced by a qualified service center. Remove safety ignition key and disconnect spark plug wire from spark plug.
Replace safety ignition key.
1/4-20 LOCKNUT
1/4-20 x 1-5/8 CAPSCREW / SHEAR BOLT
IMPELLER HUB...
User Manual - Page 16
... square hole in idler arm and rotate ratchet clockwise to use the innermost hole in axle only. SERVICE AND ADJUSTMENTS
WARNING: Belt replacement requires separation of belts. See "INSTALL DISCHARGE CHUTE / CHUTE ROTATER HEAD" in this manual. REMOVE DISCHARGE CHUTE - BOLT
4. SEPARATE SNOW THROWER - Serious personal injury and/or damage to the ground.
6. Place...
User Manual - Page 17
...setting can starts to rust. Run engine at the end of this manual).
3. ENGINE OIL
Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in essential fuel system parts...parts dealer. Pull recoil starter handle slowly a few times to distribute oil.
4.
WARNING: Never store the snow thrower with gasoline in your gasoline will cause your snow thrower to rust. SERVICE...
User Manual - Page 18
... Prime as instructed in fuel....service centre. Replace damaged parts. See "IF RECOIL STARTER HAS FROZEN" in OFF position. 6.
drive / slowing 2. Augers / impeller jammed.
1. TROUBLESHOOTING
See appropriate section in STOP position. 5.
PROBLEM
CAUSE
CORRECTION
Does not start
1. Fuel shut-off valve to a qualified service centre. Safety ignition key is worn.
1. Throttle in manual...
User Manual - Page 23
..., Lock 3/8-16
5 19131316 Washer, Flat 3/8
6 404974
Control Assembly, Chute Rotater
7 405784X479 Support, Pivot
8 150078
Screw, Hex Head 5/16-18 x 3/4
9 184505
Spring, Deflector
10 ...REPAIR PARTS
SNOW THROWER - MODEL 961980018 (96198001801)
CONTROL PANEL / DISCHARGE CHUTE
KEY PART NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts...
User Manual - Page 29
...24 x 1-3/8
28 155452
Guide, Belt
29 192213
Belt... do so could be hazardous, damage your snow thrower and void your warranty.
29 REPAIR PARTS
SNOW THROWER - NO.
1 414557 2 180522 3 ---
4 74780520 5 150078 ...DESCRIPTION
Spring, Traction Idler Pulley, Idler (2-1/4) Engine, Tecumseh, Model Number LH318SA (For engine service and replacement parts, call Tecumseh Products at 1-800-558-5402) Screw, Hex...
User Manual - Page 33
... 6 181033 9 415475 10 183730 11 415399 12 415398 - - 415332 - - 415333
DESCRIPTION
Decal, Danger Decal, Poulan Decal, Danger, Deflector Decal, Danger Decal Decal, Instruction Decal, Speed Control Decal, Remote Deflector Control Decal, LH Trigger Decal, RH Trigger Owner's Manual, English Owner's Manual, French
NOTE: All component dimensions given in U.S. REPAIR PARTS DECALS
SNOW THROWER -
User Manual - Page 36
... date of purchase by the purchaser unless such return is limited to an authorized service dealer.
Some areas do not allow the limitation of consequential damages or limitations of any part which vary from defects in accordance with the instructions furnished. This is free from locale to normal wear of the purchaser. Transportation charges...
Poulan 96198001801 Reviews
Do you have an experience with the Poulan 96198001801 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!