Poulan 96194000506 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan 96194000506 manuals!
Problems with Poulan 96194000506?
Ask a Question
Free Poulan 96194000506 manuals!
Problems with Poulan 96194000506?
Ask a Question
Popular Poulan 96194000506 Manual Pages
User Manual - Page 1
IMPORTANT MANUAL
Do Not Throw Away
• Español, p. 19
OWNER'S MANUAL
MODEL NUMBER:
96194000506
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
Always Wear Eye Protection During Operation
424027 10.03.08 SR Printed in serious injury. Failure to do so can result in U.S.A.
User Manual - Page 2
...trouble. Keep the area of operation clear of all persons, small children and pets at all instructions...before starting when setting up spilled fuel... in the manual(s) before operating...safety instructions could result in moving parts. ...specifically recommended by the manufacturer for this unit.
Never fill fuel tank indoors.
3. IMPORTANT
Safe Operation Practices for any damage, and repair...
User Manual - Page 3
... for transporting the snow thrower in any problem you to give best possible dependability and performance. TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE 13-14
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17-18
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 36-52
MAINTENANCE SCHEDULE 13 3 WARRANTY...
User Manual - Page 11
...Be sure both plates are empty. Replace a damaged or worn scraper bar....nuts, then moving parts to assure fuel freshness....on each side of this manual. ADD GASOLINE (See Fig...engine problems, the fuel system should be emptied before requiring replacement.... to stop.
2. See Storage Instructions for a few seconds, remove...oil with snow thrower on your parts bag may become worn. If necessary...
User Manual - Page 13
... damage to
parts dealer.
MAINTENANCE
GENERAL RECOMMENDATIONS
The warranty on your snow thrower are of special construction and should be replaced by original equipment manufacturer
NOTE: To seal tire punctures and prevent flat tires due to
(OEM) belts available from your nearest dealer.
The belts on this manual should be made periodically to service this manual). corrosion...
User Manual - Page 14
... the crankcase oil level before next oil change. All oil must meet API service classification SG-SL. • Be sure snow thrower is required, use . For approximate capacity see "PRODUCT SPECIFICATIONS" section of this manual.
WARNING: Remove safety ignition key and disconnect spark plug wire from spark plug. LUBRICATION Use only high quality...
User Manual - Page 15
...the top of this manual. Place wire where it cannot come in auger shaft and install a new 1/4-20 ...parts have sheared. SERVICE AND ADJUSTMENTS
WARNING: To avoid serious injury, before performing any other components. WARNING: To avoid serious injury, never operate your snow thrower.
4. Install... and place wire where it should be replaced. Disconnect spark plug wire from spark plug...
User Manual - Page 16
...
5.
While separating the auger housing from your nearest service centre/department. Serious personal injury and/or damage to be replaced at the same time.
FRAME ASSEMBLY
AUGER HOUSING
HANDLES
...check carefully for proper routing of this manual.
4. Install the two (2) hex bolts and tighten securely.
15. INSTALL ENGINE PULLEY - INSTALL BELT COVER and two (2) screws. ...
User Manual - Page 17
....
• Use fresh fuel next season. Inspect and replace belts, if necessary (See "TO REPLACE BELTS" in the Maintenance section of fuel gum deposits during storage. Replace if necessary.
5. ENGINE
See engine manual. NOTE: Fuel stabilizer is to be sure to suspected carburetor problems, take your local parts dealer. Add stabilizer to distribute oil.
4. Always follow the...
User Manual - Page 18
TROUBLESHOOTING
See appropriate section in the Operation section of power
1.
Water in fuel line. 3. Prime as instructed in manual unless directed to spark plug.
9. Connect wire to a qualified service centre/department.
Loss of this manual. Reduce speed and width of this manual. 7. Move choke to FAST position.
5.
Recoil starter is worn.
1. Drive belt is...
User Manual - Page 37
REPAIR PARTS
SNOW THROWER - inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL NUMBER 96194000506
AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36
PART NO.
175321X479 196710 188909...
User Manual - Page 41
... be hazardous, damage your snow thrower and void your warranty.
41 REPAIR PARTS
SNOW THROWER - ITEMS INDICATED WITH AN * ARE LISTED AS REFERENCE FOR SERVICE PARTS ONLY. NOTE: All component dimensions given in U.S. MODEL NUMBER 96194000506
CONTROL PANEL / DISCHARGE CHUTE
2
2 *3
1 *6
*6
KEY NO.
1 2 *3 *4 *5 *6
PART NO.
420337 17501010 420678 420677 420675 420674
DESCRIPTION
LEVER/CABLE...
User Manual - Page 43
MODEL NUMBER 96194000506
5
1
6
8
5 8
6
2 39
7
8 49
KEY PART 7 NO.
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. NO. REPAIR PARTS...003-A
1
KEY PART NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
43 DESCRIPTION
1
419797X479 LOWER TUBE
2
418313X479 PIVOT SUPPORT
2
3
150078
BOLT...
User Manual - Page 52
...NO.
1 2 3 4 5 6 7 8 9 - - PART NO.
181038 422041 181034 181041 183879 181032 415391 415390 415476 424027
DESCRIPTION
DECAL, DANGER DECAL, POULAN, 800S / 24" DECAL, DANGER, DEFLECTOR DECAL, DANGER DECAL, POULAN DECAL, INSTRUCTION DECAL, TRACTION LEVER DECAL, AUGER LEVER DECAL, SPEED CONTROL OWNER'S MANUAL, ENGLISH / SPANISH
NOTE: All component dimensions given in U.S.
REPAIR PARTS DECALS...
User Manual - Page 56
... which we will repair or replace, at our option, without charge for replacement under this warranty must return the product to an authorized service dealer. ID#, serial number and date of purchase of your product and the name and address of the authorized dealer from the date of the product.
5. This Warranty gives you specific legal rights...
Poulan 96194000506 Reviews
We have not received any reviews for Poulan yet.