Poulan 96194000500 Support and Manuals
Get Help and Manuals for this Poulan item
This item is in your list!
View All Support Options Below
Free Poulan 96194000500 manuals!
Problems with Poulan 96194000500?
Ask a Question
Free Poulan 96194000500 manuals!
Problems with Poulan 96194000500?
Ask a Question
Popular Poulan 96194000500 Manual Pages
User Manual - Page 1
IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
96194000500
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions. Always Wear Eye Protection During Operation
414938 Rev. 3 09.20.07 TH Printed in serious injury.
Failure to do so can result in U.S.A.
User Manual - Page 2
...parts. Do not put hands or feet near or under rotating parts...when setting up...specifically recommended by the manufacturer for all instructions on a truck or
thrower for any damage, and repair the damage before unclogging the collector/impeller housing or discharge chute, and when making repairs. BECOME ALERT!!!
Keep the area of operation clear of trouble...in the manual(s) before ...
User Manual - Page 3
... collector/impeller.
The instructions will enable you experience any enclosure.
3. Always observe the "SAFETY RULES".
TABLE OF CONTENTS
SAFETY RULES 2-3
MAINTENANCE SCHEDULE 13
PRODUCT SPECIFICATIONS 3
SERVICE AND ADJUSTMENTS 15-17
CUSTOMER RESPONSIBILITIES 3
STORAGE 17-18
ASSEMBLY / PRE-OPERATION 4-6
TROUBLESHOOTING 18
OPERATION 7-12
REPAIR PARTS 36-47
MAINTENANCE...
User Manual - Page 11
...30 days to bottom of this manual. Use fresh fuel next season. See Storage Instructions for a few seconds, remove ...housing, it run until "FULL" mark on your parts bag may become worn. Do not overfill.
•...service before storage of snow in normal conditions, such as gravel, rocks or other debris, can easily be emptied before requiring replacement. FIG. 18
To avoid engine problems...
User Manual - Page 13
...warranty, operator must maintain snow thrower as instructed in the Service and Adjustments section of this manual).
• Keep tires free of ...dealer.
The belts are functioning properly.
Check for wear. hours of operation and replace if necessary. Replace belts if they are not adjustable. Using other
parts dealer. NOTE: Use only Original Equipment Manufacturer (OEM) parts...
User Manual - Page 14
...Install drain plug and tighten securely.
5. Wipe off any dirt or trash. Remove oil fill cap/dipstick. Refill engine with API service classification SG-SL. Wipe off any oil trapped inside the snow thrower. Spark plug type and gap setting... manual).
7. For approximate capacity see "PRODUCT SPECIFICATIONS" section of your snow thrower after each use . MUFFLER
Inspect and replace ...
User Manual - Page 15
...shaft and install a new 1/4-20 x 2" shoulder/shear bolt and spacer. Install 1/4-20 ... one or both of this manual. To replace the capscrew/shear bolts:
1....replace the shear bolts:
1. CAUTION: Do not substitute. Should a foreign object or ice become lodged in the Operation section of the discharge chute, is secured to spark plug. Disengage all moving parts have sheared.
SERVICE...
User Manual - Page 16
... the Assembly / Pre-Operation section of this manual. INSTALL BELT COVER and two (2) screws.
Install clutch rod in the operating position holding the handles, remove the two (2) bolts holding the auger housing and frame together.
8. Make sure belt is important that the belt(s) be replaced by a Sears service centre/department. While separating the auger housing...
User Manual - Page 17
...problems, take your local parts dealer. If your engine does not operate properly due to a qualified service centre. ENGINE SPEED
Never tamper with clean engine oil. (See "ENGINE" in essential fuel system parts such as carburetor, fuel hose, or tank during storage.
ENGINE
See engine manual... the warranty. Replace if necessary.
...manual.
4.
IMPORTANT: When installing wheel, ...
User Manual - Page 18
... loose. 2. Stale fuel. 4. Carburetor is in manual unless directed to pull
1. Tighten all fasteners. If vibration remains, contact a qualified service centre/department. Recoil starter is flooded. 8. Clogged discharge chute. 4. Check / replace auger belt. 3. Rust and/or dirt in the Operation section of swath. 3. TROUBLESHOOTING
See appropriate section in FULL position. 2. Out...
User Manual - Page 39
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL NUMBER 96194000500
CONTROL PANEL / DISCHARGE CHUTE
KEY PART NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
39 REPAIR PARTS
SNOW THROWER - DESCRIPTION
1 414280
Knob, Lever
2 17501010 Screw #10-24 x 5/8
3 179096X428 Strap, Slotted
4 ...
User Manual - Page 40
REPAIR PARTS HANDLES
7
1
5 49
5 8
28
4
4
SNOW THROWER - MODEL NUMBER 96194000500
2
28 5
5 49
6
4 4
15
12
9
15
11 10
48
15 11 19
18
22
22
13 17
16
15
23
12
47
14 24
16 17
31
24 32
26
25 27
31 27
32
30
38 40
39 40
User Manual - Page 45
...(2-1/4) Engine, Tecumseh, Model Number LH195SP (For engine service and replacement parts, call Tecumseh Products ...replacement parts. NO.
MODEL NUMBER 96194000500
CHASSIS / ENGINE / PULLEYS
KEY PART NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
45 DESCRIPTION
27 851084
Screw, Hex Head 3/8-24 x 1-3/8
28 155452
Guide...REPAIR PARTS
SNOW THROWER -
User Manual - Page 47
... 24" Decal, Danger, Deflector Decal, Danger Decal, Poulan Decal, Instruction Decal, Traction Lever Decal, Auger Lever Decal, Speed Control Owner's Manual, English / Spanish
NOTE: All component dimensions given in U.S. MODEL NUMBER 96194000500
KEY PART NO. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous...
User Manual - Page 48
... the meaning of that this Warranty, please contact:
Poulan Customer Service Department 1030 Stevens Creek Road Augusta, GA 30907 USA
In Canada contact:
Poulan, Customer Service Department 5855 Terry Fox Way Mississauga, Ontario L5V 3E4
giving the complete mfg.
Transportation charges for any part which we will repair or replace, at our option, without charge for rental...
Poulan 96194000500 Reviews
Do you have an experience with the Poulan 96194000500 that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Poulan yet.
Earn 750 points for your review!