Poulan 1994-06 Support and Manuals
Get Help and Manuals for this Poulan item
View All Support Options Below
Free Poulan 1994-06 manuals!
Problems with Poulan 1994-06?
Ask a Question
Free Poulan 1994-06 manuals!
Problems with Poulan 1994-06?
Ask a Question
Popular Poulan 1994-06 Manual Pages
User Manual - Page 1
...:
This chain saw unless you have specialized training and experience for dealing with kickback Chain saws with significantly reduced kickback potential are available. IMPORTANT MANUAL Do Not Throw Awa
fa°Wan
t
N
a...A.11-a.-dtiaa 0.)
a ja
OPERATOR'S MANUAL
MODELS: 425 & 505
GAS POWERED CHAIN SAW
Always Wear Eye Protection
POULAN PRO
Nt4sx Shreveport, Louisiana 71129 U.S.A. t.
User Manual - Page 2
...
MODEL: DISPLACEMENT:
SPARK PLUG: SPARK PLUG GAP:
IGNITION: MODULE AIR GAP:
OILER: FUEL MIX: MUFFLER:
Guide Bar
Bucking -'
Spike
Oil Cap
Fuel Cap
SPECIFICATIONS
...SPECIFICATIONS
2
WARNINGS & SAFETY INSTRUCTIONS . . . 3
KNOW YOUR UNIT
6
PREPARING YOUR SAW FOR USE
7
FUELING YOUR UNIT
10
STARTING YOUR UNIT TYPES OF CUTTING GENERAL MAINTENANCE POULAN PRO ACCESSORIES PARTS & SERVICE...
User Manual - Page 4
...the saw . 3. HANDLE FUEL WITH CAUTION 1. Wipe up all fuel purposes. 3. Contact your Service Dealer if you are fatigued, it or upset, or if you have taken alcohol, drugs, ... that can cause material to adult users who understand and can result in this manual. WARNINGS AND SAFETY INSTRUCTIONS (continued)
A WARNING.
store fuel in an area where fuel vapors cannot reach...
User Manual - Page 5
...INSTRUCTIONS (continued)
OPERATE YOUR SAW SAFELY
1. Slender material can occur and cause the flywheel to avoid turnover, fuel spillage, or damage.
3.
Inspect unit and repair or replace parts as necessary
6. Always replace the chain brake immediately if it stops.
4. and relevant state safety codes...try to the "Trouble Shooting Chart."
5. Be alert for your saw when guide bar is in...
User Manual - Page 6
... CHAIN BRAKE WILL PROTECT YOU IN THE EVENT OF A KICKBACK. Repairs on a chain brake should be equipped with a spark arrestor. Failure to follow these instructions can result in effective working order, or the engine must be made by an Authorized POULAN PRO Service Dealer. Do not use the saw properly and carefully to the...
User Manual - Page 7
... the guide bar nose. Follow "Chain Tension" instructions.
Align screw holes in the spur with a standard screwdriver until the chain is
sharp and can come off resulting in Figure 8 (inset). Install the housing screws removed in the bar. I CAUTION: I Wear protective gloves when handling or operating your saw upright on a flat surface. Set the...
User Manual - Page 9
...the bearings and other moving
parts.
seek help from oxidation and...regular unleaded
gasoline.
•
2-CYCLE AIR-COOLED OIL:
POULAN PRO 40:1, 2 -cycle engine oil is ready for ...gallon of regular unleaded gasoline to the container, then securely replace the cap. FOR ONE GALLON OF FUEL: • ... to fuel your Au-'I thorized Service Dealer. The fuel is strongly recommended. FUEL MIXTURE ...
User Manual - Page 10
... Model ...INSTRUCTIONS (Refer to make starting or operating the saw is automatically set...manual. BASIC PROCEDURE." 2.) Move the choke lever to "ON" position. BASIC PROCEDURE."
10 - Tighten, repair, or replace parts...Set the saw for about 5 seconds. Move Start/Stop switch to disen- Figure 14 . A WARNING Avoid bodily contact with an automatic
throttle advance used to the "Specifications...
User Manual - Page 11
... forward, either manually or by pulling...setting the saw down after cutting.
4 Begin cuttingwith the bottom of the guide...repair or replace parts as possible...Repairs on top of dir't and sand. IMPORTANT POINTS a. CAREFULLY PLAN YOUR SAWING OPERATION IN ADVANCE a. r. -
c. Keep the chain out of the bar is suddenly stopped by being pinched, caught, or by an Authorized POULAN PRO Service...
User Manual - Page 12
...tree. Plan to be made on the uphill side of the tree, the tree will not be poorly supported. Plan a clear retreat path to cut large trees.
Figure 19. 2. b.
Or More The notch... :
1.) Make a single felling cut on your planned retreat path.
When a tree doesn't fall completely, set the saw , put it Buttress
11 tIt
sit,
Roots First
1. If you are to stand on the ...
User Manual - Page 15
...replaced by a qualified service dealer when installing a new chain to avoid excessive wear to the chain.
• Remove burrs by filing with a flat file. C. as instructed in the maintenance section of this manual.
• See a qualified service dealer to replace...
• Replace the guide bar when: - Use only the correct fuel/oil ratio as required. -at all adjustments or repairs (except car...
User Manual - Page 16
...servicing the starter rope. Remove the four screws on the crankcase. Figure 34 k 7. push it counterclockwise.
Allow each melted end through the round starter rope hole in a counterclockwise direction. 14.Set the pulley into the housing; Figure 34 . Replace...up the spring.
18. Guide the rope inside the pulley...result.
1. Ifyou try to repair the starter rope and the recoil...
User Manual - Page 17
...to idle three (3) minutes to a qualified service dealer.
NOTE: Never set high speed mixture screw so far clockwise that ...cut . Allow the engine to meet factory performance specifications. Turn screw clockwise to idle. Allow engine ... "3. Acceleration Adjustment."
- c. Note the position. See the "Trouble Shooting Chart" before making further adjustments. Wear your saw before making...
User Manual - Page 19
... uneven.
3. Clutch slipping.
1. Reinstall chain and check tension. 2. Repair or replace. 4. Disengage chain brake.
1. See "Chain Tension." 2. Resharpen or replace chain. 4. See the chain sharpening instructions.
5. Contact your Authorized Service Dealer. 4. See the chain sharpening instructions. 2. Repair or replace guide bar. 3.
Chain cuts at - Cutters damaged on one...
User Manual - Page 24
... may be directed to rigid quality standards.
For replacement parts, have available the following information: a. b. Parts and repair service are not available directly from those described in this Operator's Manual, please contact your local Poulan/Weed Eater Dealer for Chain Saws or under "saws" for updated information and assistance. The philosophy of your unit. Shreveport...
Poulan 1994-06 Reviews
We have not received any reviews for Poulan yet.