LG MV1611ST Support and Manuals
Get Help and Manuals for this LG item
Most Recent LG MV1611ST Questions
Does This Microwave Have A Ductless Vent System?
I have this model new and unopened but doesn't say anywhere on the box if it is ductless venting or ...
I have this model new and unopened but doesn't say anywhere on the box if it is ductless venting or ...
(Posted by bcdblackknight 11 years ago)
Can This Microwave Be Mounted Over A Gas Range?
(Posted by paul44654 11 years ago)
Popular LG MV1611ST Manual Pages
Service Manual - Page 1
Internal Use Only Website: http://us.lgservice.com
MICROWAVE OVEN SERVICE MANUAL
MODEL: MV1611BB MV1611WW MV1611ST
CAUTION
BEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
P/NO : MFL08861102
August, 2010 Printed in Korea
Service Manual - Page 2
... generation and transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual before the oven is properly installed around the dome of the test procedures and safety information contained in this manual. A Microwave leakage check to verify compliance with the door open. c. CAUTION
WARNING TO SERVICE TECHNICIANS
PRECAUTIONS TO BE OBSERVED BEFORE...
Service Manual - Page 3
...the information in this Manual carefully. CHECKOUT PROCEDURES ...7-18 C. TROUBLESHOOTING ...7-21 EXPLODED VIEW ...8-1 REPLACEMENT PART LIST...9-1
TABLE OF CONTENTS
(Page) SAFETY PRECAUTIONS ...Inside front page SPECIFICATIONS ...1-1 CAUTIONS ...2-1 INSTALLATIONS ...3-1 OPERATING INSTRUCTIONS...4-1
CONTROL PANEL ...4-1 CONTROL PANEL INSTRUCTIONS...4-2 OVERALL CIRCUIT DIAGRAM ...5-1 SCHEMATIC...
Service Manual - Page 4
Accessories Owner's Manual & Cooking Guide, Installation Manual Exhaust Adapter, Exhaust Damper, Mounting Kit and Filter Glass ... diagram on page 5-1. SECONDARY INTERLOCK
SWITCH
COM NO OPEN CLOSE
INTERLOCK MONITOR SWITCH
COM NC CLOSE OPEN
1-1
SPECIFICATIONS
Rated Power Consumption 1500W maximum (Microwave oven+Cook top lamps+Ventilation fan) Microwave Output 1000W (IEC60705) Frequency...
Service Manual - Page 5
... repair.
• DO NOT ...replacing the Magnetron.
• DO NOT touch any parts of the oven, always remove the power plug from the magnetron or other appliances, the microwave oven is properly installed around the dome of the tube whenever installing the magnetron.
ANTENNA
Gasket
COOLING FIN
MAGNETRON CHASSIS GROUND
FILAMENT TERMINALS
MAGNETRON
THE OVEN IS TO BE SERVICED...
Service Manual - Page 8
... not hear any tones. POPCORN. TIME. LIGHT. Touch this pad to enter cooking times, cook powers, quantities, weights, or food categories.
11. CONTROL PANEL INSTRUCTIONS
1. POTATO. to set the amount of day.
15. TIME DEFROST. AUTO REHEAT. Touch this pad to enter the correct time of microwave energy released to cook the...
Service Manual - Page 11
... " and then "0" three times."1, 0, 0, 0" appears in this model are: (1) Primary interlock switch (2) Secondary interlock switch (3) Interlock monitor switch... foil used to cover some parts of the oven. Set cooking time for 10 minutes...FEATURES AND SPECIFICATIONS FEATURES
A. However, small pieces may shorten the life of the microprocessor.
6-1
TRIAL OPERATION
After installation, the ...
Service Manual - Page 12
... the unit that there are intact. (no detective parts in high voltage section. Never plug the unit into a power source to ground. SINCE NEARLY 4000 VOLTS EXISTS IN SOME CIRCUITS OF THIS UNIT REPAIRS SHOULD BE CARRIED OUT WITH GREAT CARE. SERVICE INFORMATION
PRECAUTIONS AND REPAIR SERVICE TIPS
PRELIMINARY
A. Extreme caution must not be operated...
Service Manual - Page 13
...servicing. NOTE: The standard is manufacturer's own voluntary standard for operating personnel from radiation leakage.
NOTE: Address on the oven.
• Set...home. while in excess of 5 mW/cm2 and should repair any certified oven unit found to have a microwave emission ....
Move probe along shaded area. The service personnel should instruct the owner not to assure safety for units...
Service Manual - Page 14
...functioning properly and genuine replacement parts which is in the ...service invoice.
(2) Should the microwave energy leakage not be more than 1 mW/cm2 after all parts...the outer case is installed and after determining that ... vessel are listed in this manual have been used.
(3) At...by its maximum microwave power setting with the door in measuring ...After adjustment and repair of any microwave...
Service Manual - Page 15
WHEN RECONNECTING THE WIRE LEADS TO ANY PART, MAKE SURE THE WIRING CONNECTIONS AND LEAD COLORS ARE CORRECTLY MATCHED ACCORDING TO THE OVERALL CIRCUIT... CONNECTOR" on the next page.
(6) Remove the circuit board from the circuit board. DISASSEMBLY INSTRUCTIONS
IMPORTANT NOTES:
UNIT MUST BE DISCONNECTED FROM ELECTRICAL OUTLET WHEN MAKING REPAIRS, REPLACEMENTS, ADJUSTMENTS AND CONTINUITY CHECKS.
Service Manual - Page 19
...install the magnetron gasket in the correct position and be sure that the gasket is in good condition.
• After replacing the magnetron, check for microwave energy leakage with a survey meter Check microwave energy leakage must be below the limit of 5 mW/cm2. (All service...replacing the magnetron, be sure to the wave guide. (4) Disconnect the leadwire. (5) Remove the magnetron VERY CAREFULLY.
Service Manual - Page 28
...
value Less than More than 400 ohms 1 mega ohm
FPC CONNECTOR Top
NOTES: • A MICROWAVE ENERGY TEST MUST ALWAYS BE PERFORMED WHEN THE UNIT IS SERVICED FOR
ANY REASON. • MAKE SURE THE WIRE LEADS ARE IN THE CORRECT POSITION. • WHEN REMOVING THE WIRE LEADS FROM THE...
Service Manual - Page 32
... (See "CHECKOUT PROCEDURES FOR FUSE BLOWING: on page 6- 1.
• "DISPLAY" Problems, "A" thru "C"
• "HELP UP" Problems, "D" thru "E"
• "BUZZER Problems, "F"
PROBLEM - C. OVEN CAVITY THERMOSTAT
7-21
PROBLEM - TROUBLE SHOOTING
Before following this troubleshooting read "TRIAL OPERATION" on page 7- 19)
3. A: "PLEASE SET TIME OF DAY" does not appear in display window when...
Service Manual - Page 43
UPPER TEMPLATE
MBM4
WALL TEMPLATE
MBM5 #EV#
INSTALLATION PARTS
6008
W109
6011
6010
6009
VINYL BAG
OWNERS MANUAL
MFL1
INSTALLATION MANUAL
MFL3
COOKING GUIDE LABEL
MEZ1
-8-10-
LG MV1611ST Reviews
We have not received any reviews for LG yet.