LG KG6000R Support and Manuals
Popular LG KG6000R Manual Pages
Service Manual - Page 1
website http://www.lgservice.com
LG
LG Room
Air Conditioner
SERVICE MANUAL
MODEL: ACQ058PL KG5200ER LW5200ER WG5200ER WG6000R KG6000R M5404R WG5200R M6004R HBLG6000R HBLG5200E ACQ052PK
LW7000R WM-5031 LW050CE LWJ0515PAG LW5200R
CAUTION
• BEFORE SERVICING THE UNIT, READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
• ONLY FOR AUTHORIZED SERVICE PERSONNEL.
Service Manual - Page 3
... 6 POLES, 27W
• NOTE: Specifications are subject to shock hazards.
1. PREFACE
This service manual provides various service information, including the mechanical and electrical parts, etc. Unplug the power cord and connect a jumper between the jumpered lead and each exposed metallic part on the equipment at the factory. The refrigerant is found, replace all Mode [except POWER OFF...
Service Manual - Page 5
...This button takes priority over any other buttons. • When you push this button, when the set is operating,
timer is set as follows. {High(F2) Low(F1) High(F2) or {High(F3) Mid(F2) ... another 30 min.
- STOPPING OPERATION • Everytime you push this button, when the set is
not operating, timer is set within a range of the room. Temp
Fan Speed
Timer Mode Energy Auto Saver Swing
How...
Service Manual - Page 6
... before servicing. Pull the top of the front grille away from source of their slots. (See Figure 2) 4. 2. Figure 1 Figure 2
2.1.2 CABINET
1. Remove 9 screws that secure the control board to the
base pan and condenser. (See Figure 3) 4. Remove 2 screws that secure the cabinet to
base pan and air guide. (See Figure 4) 5. DISASSEMBLY INSTRUCTIONS
2.1 MECHANICAL PARTS
2.1.1 FRONT...
Service Manual - Page 11
...refrigerant completely,
unbraze the interconnecting tube of the pinch-off tube closed. Re-install by using a refrigerant...refrigerant by means of the charge. Discharge the refrigerant by referring...refrigerant...installed... service ...refrigerant to Section 2.1.2) 2. Turn off tube. Solder service...guide upper. (Refer to enter the system. Remove the capillary tube. 6.
When replacing the refrigerating...
Service Manual - Page 12
..., charging cylinder, manifold gauge, brazing equipment, pinch-off tool capable of making a vapor proof seal, leak detector, tubing cutter, hand tools to remove components and service valve.
COMPOUND GAUGE
MANIFOLD GAUGE
B
A
CONDENSER (HIGH PRESSURE SIDE)
COMPRESSOR
SEE INSETS BELOW
EVAPORATOR (LOW PRESSURE SIDE) CAPILLARY TUBE
LO HI CHARGING CYLINDER
A
B
EXTERNAL VACUUM...
Service Manual - Page 13
...
OUTSIDE AWNING
FENCE
HEAT RADIATION
30"-60"
Figure 21
ABOUT
/ 1 4
"
Over 20"
3.2 HOW TO INSTALL
3.2.1 WINDOW REQUIREMENTS
INNER SILL
NOTE: All supporting parts should be thick enough to allow a clear vertical opening widths of wood strip should be easily installed in a window.
3.1 SELECT THE BEST LOCATION
1. tom of 13" from the back of the...
Service Manual - Page 14
... to the window width. b. Installation Kit (Some models)
HARDWARE
TYPE A: 11EA (SHORT SCREW)
TYPE B: 5EA (WOOD SCREW)
TYPE C: 3EA (L BACKET)
DRAIN PIPE
10mm 16mm
TYPE D: 1EA (SEAL STRIP)
(Adhesive backed)
TYPE E: 1EA (SASH SEAL)
(Not adhesive backed)
TYPE F: 2EA (GUIDE PANEL)
TYPE G: 1EA (SUPPORT BACKET)
3.2.2 BEFORE INSTALLATION
1. Insert the guide panels into the open window...
Service Manual - Page 18
...Adjust refrigerant charge. Repair clogging in refrigeration circuit. The other is beyond repair. Satisfactory operation with temperature difference of air filter. Clogging of inlet & outlet air; 44~50°F (7~10°C)
-18- Unit is running but cooling is classified in the refrigeration circuit and improper application. 4.3 TROUBLESHOOTING GUIDE
In general, possible trouble is...
Service Manual - Page 21
... IC01M. YES
• Check the RY-COMP.
• Connect LEAD Wire to higher Temp.
setting set lower than Room
NO
Temp.-0.5°C?
• Set the Temp. setting to RY-COMP again.
Is the wire connection of IC01M 0V? Possible Trouble 2
• The compressor does not operate.
YES
Is the voltage No.10
NO
of IC01M...
Service Manual - Page 24
...set screw Worn bearings
Compressor will not run, fan motor runs.
Check the compressor for identification, and replace the wires. Voltage Wiring
Thermistor
Capacitor (discharge capacitor before servicing...if loose, repair or replace the terminal. If the wires are disconnected, refer to be internal while running or loose, replace the motor. Check the capacitor.
Replace if open circuit...
Owners Manual - Page 2
...to call for service at all.
° Contact the authorized Service technician for use and maintain your air conditioner properly. READ THIS MANUAL
inside you ...part can find many answers to common problems in the chart of troubleshooting tips If you review our cha_ of Troubleshooting Tips first, you may not need to locate the nearest ASC.
• The air conditioner is not intended for repair...
Owners Manual - Page 3
tions.
J
I Meanings of symbols used in the installation. [] Use Caution! Safety Pre utions
To prevent injury to assist in this manual are as shown below,
Ill
_ _.,_,
Be ...it wil_ cause electric shock.
• This _uld _ead to health problems.
® m _n_rrect operation due to ignoring instructions will cause harm or damage, The seriousness is classified by
the following...
Owners Manual - Page 12
Troubleshooting TiPs save time and money! The water may overflow and drip from the outdoor side of : the air conditioner.
• Set...first and you
for service. fore you may run even when the compressor does not. Review the chart below
• Set the mode control ...the outlet,
• Check the house Dseicircuit breaker box and replace the fuse or reset the breaker.
• When power is ...
Owners Manual - Page 39
.... 8 AM ~ 5 PM CT)
Press the appropriate me_moption, and have your product type (R(×)mAir Conditione:0, model number, serial number, and ZiP Code ready. Aii Parts
Compressor
LG Room Air Conditioner Warranty Period
1 Year 5 Years
1 Year (In-Home Service) 1 Year (h>Home Service)
No other than normal, single-family household use during the warranty period as long as...
LG KG6000R Reviews
Do you have an experience with the LG KG6000R that you would like to share?
Earn 750 points for your review!
We have not received any reviews for LG yet.
Earn 750 points for your review!