Owners Manual
Page 1
User: BEFORE using this product, read this product. User Manual Perfecto2™Series Oxygen Concentrators without SensO2®, Oxygen Concentrators with SensO2 HomeFill®Compatible Perfecto2 with SensO2 Model IRC5PO2 Model IRC5PO2W Model IRC5PO2V Perfecto2 Model IRC5P Model IRC5PW Dealer: This manual MUST be given to the end user of this manual and save for future reference. For more information regarding Invacare products, parts, and services, please visit www.invacare.com
User: BEFORE using this product, read this product. User Manual Perfecto2™Series Oxygen Concentrators without SensO2®, Oxygen Concentrators with SensO2 HomeFill®Compatible Perfecto2 with SensO2 Model IRC5PO2 Model IRC5PO2W Model IRC5PO2V Perfecto2 Model IRC5P Model IRC5PW Dealer: This manual MUST be given to the end user of this manual and save for future reference. For more information regarding Invacare products, parts, and services, please visit www.invacare.com
Owners Manual
Page 2
... PRODUCT OR OPTIONAL EQUIPMENT. NOTE: Updated versions of these devices will be found at www.invacare.com. They should contact your local home care provider for recommendations on the proper usage, maintenance, and cleaning. Perfecto2™Series 2 Part No 1143482 You should also give you . IF YOU ARE UNABLE TO UNDERSTAND THE...
... PRODUCT OR OPTIONAL EQUIPMENT. NOTE: Updated versions of these devices will be found at www.invacare.com. They should contact your local home care provider for recommendations on the proper usage, maintenance, and cleaning. Perfecto2™Series 2 Part No 1143482 You should also give you . IF YOU ARE UNABLE TO UNDERSTAND THE...
Owners Manual
Page 3
... Indicators - Units with SensO2 20 Front Panel Indicators - Units without SensO2 21 SECTION 6-MAINTENANCE 23 Routine Maintenance 23 SECTION 7-TROUBLESHOOTING GUIDE ......... 26 LIMITED WARRANTY 31 Part No 1143482 3 Perfecto2™Series
... Indicators - Units with SensO2 20 Front Panel Indicators - Units without SensO2 21 SECTION 6-MAINTENANCE 23 Routine Maintenance 23 SECTION 7-TROUBLESHOOTING GUIDE ......... 26 LIMITED WARRANTY 31 Part No 1143482 3 Perfecto2™Series
Owners Manual
Page 4
... death or serious injury. Refer to hazards or unsafe practices which , if not avoided, could result in personal injury or property damage. Perfecto2™Series 4 Part No 1143482 Failure to change without notice. Ꮨ DANGER DO NOT SMOKE while using this device. Textiles and other sources of ignition out of the...
... death or serious injury. Refer to hazards or unsafe practices which , if not avoided, could result in personal injury or property damage. Perfecto2™Series 4 Part No 1143482 Failure to change without notice. Ꮨ DANGER DO NOT SMOKE while using this device. Textiles and other sources of ignition out of the...
Owners Manual
Page 5
SPECIAL NOTES CAUTION "Caution: Federal law restricts this device." Part No 1143482 5 Perfecto2™Series Invacare recommends an alternate source of supplemental oxygen in the event of this device to sale or rental by or on order of a physician, or any ...
SPECIAL NOTES CAUTION "Caution: Federal law restricts this device." Part No 1143482 5 Perfecto2™Series Invacare recommends an alternate source of supplemental oxygen in the event of this device to sale or rental by or on order of a physician, or any ...
Owners Manual
Page 6
... assembly Specification Label is being delivered. RISK OF FIRE NO SMOKING - B Serial Number Label is located on the back near the bottom Perfecto2™Series 6 Part No 1143482 Set flowmeter at 3.0 L/min. ELECTRIC SHOCK DO NOT remove cover.
... assembly Specification Label is being delivered. RISK OF FIRE NO SMOKING - B Serial Number Label is located on the back near the bottom Perfecto2™Series 6 Part No 1143482 Set flowmeter at 3.0 L/min. ELECTRIC SHOCK DO NOT remove cover.
Owners Manual
Page 7
...; WARNING This section contains important information for the safe operation and use any lubricants unless recommended by Invacare. Refer servicing to Persons Ꮨ DANGER Risk of this product. Part No 1143482 7 Perfecto2™Series DO NOT come in contact with the concentrator while wet. Unplug ...IMMEDIATELY. DO NOT disassemble. No user serviceable parts. A spontaneous and violent ignition may occur if oil, grease or greasy substances come in another room at least 7 ft from...
...; WARNING This section contains important information for the safe operation and use any lubricants unless recommended by Invacare. Refer servicing to Persons Ꮨ DANGER Risk of this product. Part No 1143482 7 Perfecto2™Series DO NOT come in contact with the concentrator while wet. Unplug ...IMMEDIATELY. DO NOT disassemble. No user serviceable parts. A spontaneous and violent ignition may occur if oil, grease or greasy substances come in another room at least 7 ft from...
Owners Manual
Page 8
NEVER drop or insert any object or liquid into any opening. Invacare recommends that each concentrator be on the power cord. Close supervision is necessary when this product is Off when not in . Radio ...or hot surfaces, including space heaters, stoves and similar electrical appliances. These limits are no user serviceable parts. Perfecto2™Series 8 Part No 1143482 SECTION 1-GENERAL GUIDELINES Operating Information For optimum performance, Invacare recommends that Crush‐Proof oxygen tubing be used near children or physically‐challenged individuals. There are...
NEVER drop or insert any object or liquid into any opening. Invacare recommends that each concentrator be on the power cord. Close supervision is necessary when this product is Off when not in . Radio ...or hot surfaces, including space heaters, stoves and similar electrical appliances. These limits are no user serviceable parts. Perfecto2™Series 8 Part No 1143482 SECTION 1-GENERAL GUIDELINES Operating Information For optimum performance, Invacare recommends that Crush‐Proof oxygen tubing be used near children or physically‐challenged individuals. There are...
Owners Manual
Page 9
...: • Reposition, relocate, or increase the separation between the equipment. • Connect the equipment into an outlet on a circuit different from the Perfecto2 is connected. Part No 1143482 9 Perfecto2™Series SECTION 1-GENERAL GUIDELINES Other devices may be reduced or corrected by the above standards.
...: • Reposition, relocate, or increase the separation between the equipment. • Connect the equipment into an outlet on a circuit different from the Perfecto2 is connected. Part No 1143482 9 Perfecto2™Series SECTION 1-GENERAL GUIDELINES Other devices may be reduced or corrected by the above standards.
Owners Manual
Page 10
... Switch ACCESSORIES (NOT SHOWN): PreciseRX™ Pediatric Humidifier/Flowmeter REAR VIEW Accessory - For more information about the HomeFill, contact your Invacare dealer. IRCPF16 (Perfecto2 5 Only) HomeFill home oxygen compressor - When not in use, the plug provided with the HomeFill home ...oxygen compressor. IOH200 Cabinet Filter *NOTE: This outlet fitting is to the HomeFill ownerʹs manual, part number 1100873, for filling oxygen cylinders with the concentrator should be used only for connection and operating instructions. The outlet ...
... Switch ACCESSORIES (NOT SHOWN): PreciseRX™ Pediatric Humidifier/Flowmeter REAR VIEW Accessory - For more information about the HomeFill, contact your Invacare dealer. IRCPF16 (Perfecto2 5 Only) HomeFill home oxygen compressor - When not in use, the plug provided with the HomeFill home ...oxygen compressor. IOH200 Cabinet Filter *NOTE: This outlet fitting is to the HomeFill ownerʹs manual, part number 1100873, for filling oxygen cylinders with the concentrator should be used only for connection and operating instructions. The outlet ...
Owners Manual
Page 11
...3-HANDLING The concentrator should ALWAYS be used immediately, retain containers and packing materials for storage until use of the concentrator is required. Part No 1143482 11 Perfecto2™Series Remove all components. If damage is to prevent cabinet damage while being transported. FIGURE 3.1 Unpacking ...NOTE: Unless the oxygen concentrator is to be kept in a dry area. 2. Carefully remove all the components from Invacare. Storage 1. If the concentrator is evident, notify the carrier, or your local dealer. 2. Check for any obvious damage to FIGURE 3.1. 1.
...3-HANDLING The concentrator should ALWAYS be used immediately, retain containers and packing materials for storage until use of the concentrator is required. Part No 1143482 11 Perfecto2™Series Remove all components. If damage is to prevent cabinet damage while being transported. FIGURE 3.1 Unpacking ...NOTE: Unless the oxygen concentrator is to be kept in a dry area. 2. Carefully remove all the components from Invacare. Storage 1. If the concentrator is evident, notify the carrier, or your local dealer. 2. Check for any obvious damage to FIGURE 3.1. 1.
Owners Manual
Page 12
... ± 0.5 psi (34.5 kPa ± 3.45 kPa) 0.5 to 5 L/min For flowrates less than 1 L/min, we recommend the use of the Invacare Pediatric Flowmeter IRCPF16 Accessory. 0 L/min to 0.5 L/min Rapid Audible Alarm Beeping (No Accessories Connected). SECTION 4-TYPICAL PRODUCT PARAMETERS SECTION 4-TYPICAL PRODUCT PARAMETERS Electrical Requirements:...for flows ranging at : Perfecto2V Model: 325 W 35 psi ± 3.5 psi (241 kPa ± 24.1 kPa) Perfecto2™Series 12 Part No 1143482 From 8,000 ft to 13,129 (4000 meters) below 90% efficiency. 87% to 6,000 ft (1828 meters) above sea level ...
... ± 0.5 psi (34.5 kPa ± 3.45 kPa) 0.5 to 5 L/min For flowrates less than 1 L/min, we recommend the use of the Invacare Pediatric Flowmeter IRCPF16 Accessory. 0 L/min to 0.5 L/min Rapid Audible Alarm Beeping (No Accessories Connected). SECTION 4-TYPICAL PRODUCT PARAMETERS SECTION 4-TYPICAL PRODUCT PARAMETERS Electrical Requirements:...for flows ranging at : Perfecto2V Model: 325 W 35 psi ± 3.5 psi (241 kPa ± 24.1 kPa) Perfecto2™Series 12 Part No 1143482 From 8,000 ft to 13,129 (4000 meters) below 90% efficiency. 87% to 6,000 ft (1828 meters) above sea level ...
Owners Manual
Page 13
... flow when back pressure of 7kPa is applied: 0.7 L/min Filters: Cabinet, Outlet HEPA and Compressor Inlet Safety System: Width: Current overload or line surge shutdown. Part No 1143482 13 Perfecto2™Series High temperature compressor shutdown.
... flow when back pressure of 7kPa is applied: 0.7 L/min Filters: Cabinet, Outlet HEPA and Compressor Inlet Safety System: Width: Current overload or line surge shutdown. Part No 1143482 13 Perfecto2™Series High temperature compressor shutdown.
Owners Manual
Page 14
Perfecto2™Series 14 Part No 1143482 SECTION 4-TYPICAL PRODUCT PARAMETERS Placement: Tubing: Relative Humidity: Time of Operation: Recommended Storage and Shipping Temperature: No closer than three inches from any wall, furniture, draperies, or similar surfaces. 7 ft cannula with a maximum 50 ft of Crush-Proof Tubing (DO NOT pinch). 20 to 60% Up to 24 hours per day. -20°F to 150°F (-29°C to 65°C), at 15-95% relative humidity. *NOTE: Stated concentration levels achieved after initial warm‐up period (approximately 30 minutes).
Perfecto2™Series 14 Part No 1143482 SECTION 4-TYPICAL PRODUCT PARAMETERS Placement: Tubing: Relative Humidity: Time of Operation: Recommended Storage and Shipping Temperature: No closer than three inches from any wall, furniture, draperies, or similar surfaces. 7 ft cannula with a maximum 50 ft of Crush-Proof Tubing (DO NOT pinch). 20 to 60% Up to 24 hours per day. -20°F to 150°F (-29°C to 65°C), at 15-95% relative humidity. *NOTE: Stated concentration levels achieved after initial warm‐up period (approximately 30 minutes).
Owners Manual
Page 15
... the like . You may be easily rolled from room air. Your oxygen concentrator will tell you through a nasal cannula. Refer to you about your concentrator. Part No 1143482 15 Perfecto2™Series DO NOT place in the need for individual use your concentrator and will show you use indoors. It provides...
... the like . You may be easily rolled from room air. Your oxygen concentrator will tell you through a nasal cannula. Refer to you about your concentrator. Part No 1143482 15 Perfecto2™Series DO NOT place in the need for individual use your concentrator and will show you use indoors. It provides...
Owners Manual
Page 16
... with Cap Humidifier Bottle w/o Cap FIGURE 5.1 Filling the Humidifier 3. Water from bottle. 2. Pull up and remove the humidifier bottle adapter (FIGURE 5.2). Perfecto2™Series 16 Part No 1143482 Insert a flathead screwdriver in power cord to FIGURE 5.1, FIGURE 5.2 on page 17, FIGURE 5.3 on the top edge of the filter access door and...
... with Cap Humidifier Bottle w/o Cap FIGURE 5.1 Filling the Humidifier 3. Water from bottle. 2. Pull up and remove the humidifier bottle adapter (FIGURE 5.2). Perfecto2™Series 16 Part No 1143482 Insert a flathead screwdriver in power cord to FIGURE 5.1, FIGURE 5.2 on page 17, FIGURE 5.3 on the top edge of the filter access door and...
Owners Manual
Page 17
... concentrator. SECTION 5-OPERATING INSTRUCTIONS Humidifier Bottle Adapter Insert Flat Head Screwdriver Here Cabinet Filter Filter Access Door FIGURE 5.2 Humidifer Bottle Adapter 5. See Detail "B" in FIGURE 5.3. 8. Part No 1143482 17 Perfecto2™Series See Detail "B" in FIGURE 5.3. 7. Attach oxygen tubing from the humidifier bottle/adapter assembly to the humidifier bottle outlet. After...
... concentrator. SECTION 5-OPERATING INSTRUCTIONS Humidifier Bottle Adapter Insert Flat Head Screwdriver Here Cabinet Filter Filter Access Door FIGURE 5.2 Humidifer Bottle Adapter 5. See Detail "B" in FIGURE 5.3. 8. Part No 1143482 17 Perfecto2™Series See Detail "B" in FIGURE 5.3. 7. Attach oxygen tubing from the humidifier bottle/adapter assembly to the humidifier bottle outlet. After...
Owners Manual
Page 18
On/Off (I/O) Power Switch FIGURE 5.4 Power Switch Perfecto2™Series 18 Part No 1143482 SECTION 5-OPERATING INSTRUCTIONS DETAIL "A" DETAIL "B" Humidifier Bottle Oxygen Tubing Adapter Humidifier Bottle Humidifier Outlet Bottle Humidifier Bottle Oxygen Outlet Connector Humidifier Compartment FIGURE 5.3 Humidifier Compartment Power Switch NOTE: For this procedure, refer to on for one second, indicating that the unit is functioning properly. All the panel lights and the audible alarm will come on position. Press power switch to FIGURE 5.4. 1.
On/Off (I/O) Power Switch FIGURE 5.4 Power Switch Perfecto2™Series 18 Part No 1143482 SECTION 5-OPERATING INSTRUCTIONS DETAIL "A" DETAIL "B" Humidifier Bottle Oxygen Tubing Adapter Humidifier Bottle Humidifier Outlet Bottle Humidifier Bottle Oxygen Outlet Connector Humidifier Compartment FIGURE 5.3 Humidifier Compartment Power Switch NOTE: For this procedure, refer to on for one second, indicating that the unit is functioning properly. All the panel lights and the audible alarm will come on position. Press power switch to FIGURE 5.4. 1.
Owners Manual
Page 19
... until the ball rises to FIGURE 5.5 on page 20. 1. This is restored, between 0.5 L/min and 0.75 L/min, the LOW FLOW audible alarm will be triggered. Part No 1143482 19 Perfecto2™Series NOTE: To properly read the flowmeter, locate the prescribed flowrate line on the L/min line prescribed. 2. Next, turn off...
... until the ball rises to FIGURE 5.5 on page 20. 1. This is restored, between 0.5 L/min and 0.75 L/min, the LOW FLOW audible alarm will be triggered. Part No 1143482 19 Perfecto2™Series NOTE: To properly read the flowmeter, locate the prescribed flowrate line on the L/min line prescribed. 2. Next, turn off...
Owners Manual
Page 20
If purity falls below factory preset standards, indicator lights on the control panel will illuminate. Units with SensO2 The SensO2 feature monitors the purity of oxygen generated by the oxygen concentrator. OXYGEN PURITY Auto Shut Down Use Backup RED Below Normal Call Supplier YELLOW Normal O2 GREEN FIGURE 5.6 Front Panel Indicators - SECTION 5-OPERATING INSTRUCTIONS Flow Knob Flowmeter 0.5 L/min Ball Front Panel FIGURE 5.5 Flowrate Front Panel Indicators - Units with SensO2 Perfecto2™Series 20 Part No 1143482
If purity falls below factory preset standards, indicator lights on the control panel will illuminate. Units with SensO2 The SensO2 feature monitors the purity of oxygen generated by the oxygen concentrator. OXYGEN PURITY Auto Shut Down Use Backup RED Below Normal Call Supplier YELLOW Normal O2 GREEN FIGURE 5.6 Front Panel Indicators - SECTION 5-OPERATING INSTRUCTIONS Flow Knob Flowmeter 0.5 L/min Ball Front Panel FIGURE 5.5 Flowrate Front Panel Indicators - Units with SensO2 Perfecto2™Series 20 Part No 1143482