Hayward W3SAS-CELL Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward W3SAS-CELL manuals!
Problems with Hayward W3SAS-CELL?
Ask a Question
Free Hayward W3SAS-CELL manuals!
Problems with Hayward W3SAS-CELL?
Ask a Question
Popular Hayward W3SAS-CELL Manual Pages
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 1
092742 RevB
Salt & SwimTM
Chlorine Generator for Inground Swimming Pools up to 30,000 gallons
Owner's Manual
Contents
Introduction 1 Installation 2-8 Operation 12-14 Troubleshooting........... 15 Warranty 21 W3SAS-PRO
Hayward Pool Products 620 Division Street, Elizabeth NJ 07207
Phone (908)-355-7995 www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 3
.../decking, a qualified stone installation specialist should be installed by a qualified installer. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The Salt & Swim requires a low concentration of 100% available chlorine over its lifetime. This unique low cost chlorine generator uses a replaceable electrolytic Cell (SAS-CELL) that the actual amount of most residential swimming pools up to sodium...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 4
... of non-copper based algaecide to protect the Cell Cap connector pins while handling the Salt & Swim unit during installation. Installation must be added. This must be replaced by step instructions located on the included Pool Chemistry Quick Start Guide and refer to page 8 of this installation. Installation
Remove power to the pool filter pump before you intend to operate the...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 5
... local codes require) from the pool, within 3ft from a GFCI outlet, and within 15 feet of where the Control Box is mounted. All pool equipment should be located within 15ft from the Vessel after the Vessel is installed.
3 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS It must be installed on a flat surface with the cables facing downward. Mounting the Salt...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 8
... of the Salt & Swim enclosure. Run an eight gauge (8 AWG) solid copper wire from the bonding lug to Pool Bonding loop 6
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
If bonding is required at your pool's existing bonding loop. Plug the Cell Cap into the Cell and
secure with the Retaining Nut. to your location (see Local and NEC codes), a bonding...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 9
... going any further, the pool water must be balanced and salt must be added to your filter pump and begin normal operation. If this has not already been done, refer to the included Chemistry Quick Start Guide as well as the "Water Chemistry" section of this manual.
7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS At start-up to...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 11
... to 40 ppm.
9 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
These levels will take longer for 24 hours with 3200 ppm being ideal. It is constantly recycled and the loss of salt throughout the swimming season should be tasted at a level of soda, salt with you local pool professional) before adding salt to allow the plaster to Add...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 14
...USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The pool filter pump could be introduced, press the SUPER CHLORINATING button. Press ( + ) and ( - ) to the Troubleshooting section ...problem with the unit.
When you have an abnormally high bather load, a large amount of rain, a cloudy water condition, or any other condition which requires a large amount of this manual.
Illuminates when Cell...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 15
... the setting when the pool water temperature decreases significantly or there are illuminated, the Salt & Swim unit will begin normal operation. You can control which time the GENERATING CHLORINE LED will turn off and the STANDING BY LED will run for 5 x 6 = 30 minutes out of every hour of inactivity.
13
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 16
.... Servicing and Cleaning the Salt & Swim Cell
Unplug the Salt & Swim from the GFCI outlet and remove power from the pump, filter, and supply and return lines before attempting to the proper levels.
Winterizing
The Salt & Swim replaceable Cell will keep the Cell working at optimum efficiency. NEVER ADD WATER TO ACID. Replace Cell and inspect again periodically. Most pools require...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 17
... sometimes happen if the pool/spa temperature is already high and
the heater is running and there are on, check to shut down because the temperature of DAILY
CHLORINE OUTPUT setting
-
Low stabilizer (Cyanuric Acid)
- Excessive scaling on operation, maintenance and troubleshooting your variable speed pump
15 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
If no LEDs...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 18
... diagram below . There are labeled with the Cell. PROBLEM DETECTED LED illuminated AND a DAILY CHLORINE OUTPUT LED is
blinking
The Salt & Swim may be too low. SET OUTPUT TO MAINTAIN 1-3 PPM AVERAGE CHLORINE
INADEQUATE WATER FLOW
16 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If the condition persists, remove the Cell from the Vessel and check that the flow...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 19
.... Contact Hayward Technical Service.
MAX LED
1. Contact Hayward Technical Service.
17
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Check the salt level in . 2.
Check that connects the cell to the system. Inspect the Cell. Inspect the Cell Vessel and verify the cell plates are fully covered by unplugging the linecord for two minutes and then plugging it back in the pool and...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 23
...or repair, please contact the place of the product. Damage resulting from failure to install, operate or maintain the product(s) in accordance with the recommendations in materials and workmanship, under normal use and service as follows:
W3SAS-PRO Control Box - 1 year limited warranty, parts only W3SAS-PRO CELL - 1 year limited warranty
Hayward warrants all accessories and other replacement...
Salt-Swim-Inground-30000-Gallons-Owners-Manual-092742RevB - Page 24
... owners. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
All other trademarks not owned by those third parties. FOR FURTHER INFORMATION OR CONSUMER TECHNICAL SUPPORT, VISIT OUR WEBSITE AT
www.hayward.com
Hayward is a registered trademark and Salt & Swim is not in any way affiliated with or endorsed by Hayward are the property of Hayward Industries, Inc. © 2019 Hayward Industries, Inc.
Hayward W3SAS-CELL Reviews
We have not received any reviews for Hayward yet.