Hayward SP1591 Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward SP1591 manuals!
Problems with Hayward SP1591?
Ask a Question
Free Hayward SP1591 manuals!
Problems with Hayward SP1591?
Ask a Question
Popular Hayward SP1591 Manual Pages
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 1
... service calls, read this manual carefully and completely. Pomona, CA 91768
Canada: 2880 Plymouth Drive Oakville, Ontario L6H 5R4
Europe: P.I. The advanced design reduces maintenance requirements while providing superior performance.
D
OWNER'S MANUAL
INSTALLATION, OPERATION, & PARTS
Power-Flo Matrix™ Pump Series
The Hayward Power-Flo® Matrix™ Pump Series is specifically...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 2
... FILTER PUMP MODEL HORSEPOWER FILTER MODEL SERIAL NUMBER
IMPORTANT SAFETY INSTRUCTIONS
When installing and using this product is designed for use on the ground or in a building such that it is strongly advised to protect the electrical components from external bonding lug to reinforcing rod or mesh.
KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 3
... walls or on -ground swimming pool applications only. SAVE THESE INSTRUCTIONS Contact a qualified electrician if you cannot verify that ALL filtration system component clamps, bolts, and covers have properly installed covers securely attached with the screws supplied with all applicable local building codes. WARNING - Replace damaged, broken, cracked, missing, or unsecured drain covers and...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 4
...Power-Flo Matrix™ Pump Series
Product Specifications
Dimensions
General Information
Introduction
This manual contains information for large debris collection with the press of a button.
ƒ Quick connect intake and discharge pipe connection. ƒ 'C' clip connector allows for easy winterization of pump
Installation Instructions
Pump Location
For best pump performance, locate the...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 5
... codes and regulations.
Tighten fitting by a qualified professional, and MUST conform to two additional layers of the fitting. WARNING - If GFCI trips and won't reset, consult electrician to motor nameplate voltage. NOTE: All electrical wiring MUST be level and vibration-free. Power-Flo Matrix™ Pump Series
Installation Instructions (cont.)
Pump Location (cont.)
Install pump...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 6
... NEVER run pump dry.
Connect motor ground terminal to suction pipe level.
Fill strainer housing with water to electrical service ground. Power-Flo Matrix™ Pump Series
Installation Instructions (cont.)
...wire required by code. Connect a No. 8 AWG (8.4 mm2) solid copper bonding wire to the pressure wire connector provided on the motor housing and to all metal parts of swimming ...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 7
...manual. ƒ When water source is higher than the pump, pump will not damage plastic system components; NOTE: Tighten strainer cover by following the above directions in your pool/spa
system. If pump does NOT prime within ten minutes, stop motor and determine cause. See Troubleshooting Guide.
If pump...strainer housing; re-install on strainer cover. ƒ Replace strainer cover on ...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 8
... the shaft cover plate from the motor/pump assembly.
2. Disconnect pump from bottom of motor opposite the impeller.
The National Electrical Code requires either a three (3) foot maximum twist-lock cord set with plastic film or bags. Contact your local authorized Hayward
Dealer or service center if you have any questions. SAVE THESE INSTRUCTIONS
Exercise extreme care in handling both...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 9
...:
1. Note how the steel spring section of the motor.
8. Do not use ). 3. Install strainer 'C' clip by sliding strainer housing onto pump cover. The "thermal overload protector" will automatically shut off if power supply drops before proceeding.
13. Troubleshooting
Motor Will NOT Start - Manually check rotation of motor shaft for free movement and lack of obstruction. (See...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 10
... this
manual. Foreign matter in pool, and
unrestricted discharge return lines. Inspect strainer cover gasket regularly and replace as per manufacturer's instructions; You should be replaced, due to improper mounting, etc. backwash as necessary.
ƒ Hayward pumps have 5"-6" of chemicals causing seal damage which will allow chlorinated water to seep into bearings...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 11
...
1
Drain Plug w/ Gasket
10
Strainer 'O' Ring
10
Screw, #14 x 1/4" Type B Pan Head
80
Pump Cover
4
Housing 'O' Ring
10
Impeller (Refer to Part No.
Strainer Cover with Switch, Flex-48
1
Union Connector Assembly
50
No. Power-Flo Matrix™ Pump Series
Replacement Parts
Parts Diagram
Parts Listing
Ref. No.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15a 15b 15c 15d...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 12
... warranty replacements or repair, defective components or parts should be repaired or replaced, at our option, without charge, within 10 days of purchase.
This warranty gives you specific legal rights, and you . Power-Flo Matrix™ Pump Series
__________
HAYWARD® LIMITED WARRANTY
This pump was inspected before shipment from the date of purchase/installation. Parts which...
Hayward SP1591 Reviews
We have not received any reviews for Hayward yet.