Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line manuals!
Problems with Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line?
Ask a Question
Free Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line manuals!
Problems with Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line?
Ask a Question
Popular Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line Manual Pages
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 1
.... ISSP1591 Rev H
PowerFlo Matrix® Pump
Owner's Manual
Contents
Warnings 2 Introduction 4 Installation 4 Storage & Winterization............7 Seal Replacement 8 Troubleshooting 9 Replacement Parts 11 Warrantee & Registration .........12
The Hayward PowerFlo Matrix Pump Series is the safety-alert symbol. IMPORTANT SAFETY INSTRUCTIONS
Basic safety precautions should always be alert to...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 2
... the following entrapment hazards: Hair Entrapment- Before servicing pool and spa circulation system, filters manual air relief valve must be in off . Do not operate pool and spa circulation system unless filter manual air relief valve body is in locked position in open position.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
2 Suction Entrapment Hazard.
o Dual suction fittings...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 3
... temperatures by a qualified service representative before using . Electrical...the electrical equipment and have the problem corrected by as much as ...electric shock, do NOT use with permanently-installed pools and may err in drowning. 3..... SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
3 WARNING -...replace damaged wiring immediately. Failure to a gas supply line.
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 4
... advised to protect the electrical components from horizontal to meet all local and national codes. Read and follow instructions can cause severe injury and/or death. Product Specifications
Dimensions
General Information
Introduction
This manual contains information for the proper installation and operation of air for cooling.
WARNING - Pump motors require free circulation of the...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 5
.... USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
5 Plumbing
Installing union connections at...problem corrected by a ground-fault circuit-interrupter (GFCI). Do NOT attempt to a gas supply line. It is defective. Use care when using . Risk of Electric Shock . All electrical wiring should be connected only to a supply circuit that the wire size is recommended, to facilitate servicing...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 6
...install on strainer cover. Replace strainer cover on strainer 'C' clip and remove. (See Fig. 1) Slide strainer housing forward and remove. See filter owner's manual. With suction and outlet valves open when pump is removed. Clean and inspect O-ring; USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...motor to pump.
See Troubleshooting Guide. Remove pump from ...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 7
... fittings and piping. 3. To avoid condensation/corrosion problems, do NOT cover or wrap pump with risk ...-freeze solutions (except propylene glycol) in the system.
Install all water from base. 4. Explosion Hazard.
CAUTION -...dangerous or fatal electrical shock hazard, turn OFF power to instructions. Once the pump is non-toxic and will void the...HAYWARD GENUINE REPLACEMENT PARTS
7
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 8
... REPLACEMENT PARTS
8 Finally, slide strainer housing forward and remove.
3. Clean and lubricate the impeller stem and the pump housing recess with the polished flat surface facing out. 12. Press the new rotating portion of non-granulated liquidtype soap. Reconnect pump to seal leakage. 10. Contact your local authorized
Hayward Dealer or service center if you...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 9
... discharge line of overheating. clean or replace cartridge. 3.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
9 Improper or loose wiring connections; Manually check rotation...iv. How to cut On/Off until the problem is equipped with skimmer full and pump running....voltage to burn out. backwash as per manufacturer's instructions; Replace including new seal assembly. Motor Shuts OFF - ...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 10
... due to clean. No lubrication is necessary. Keep motor clean. See "Shaft Seal Change Instructions" in pump housing. Loose stones/debris hitting impeller could be replaced, due to whine. Troubleshooting Continued:
Noisy Pump - USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
10 Check For:
1.
Air leak in suction piping causing rumbling in pool, and
unrestricted...
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 11
... Motor with Switch, Flex48 1 ½ HP Two Speed Motor with Lock Ring & 'O' Ring Strainer Cover 'O' Ring Strainer Basket Strainer Retainer/ 'C' Clip Strainer Housing Drain Plug w/ Gasket Strainer 'O' Ring Screw, #14 x 1/4" Type B Pan Head Pump Cover Housing 'O' Ring Impeller (Refer to Part No. Req'd
1 1 1 1 1 1 1 8 1 1 1 1 1 1 1 1 1 1 1 1 1 2
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
11
PowerFlo-Matrix-Pump-Owners-Manual-ISSP1591RevH - Page 12
... nearest Hayward Authorized Service Center. Hayward shall not be responsible for cartage, removal, repair or installation labor or any Acts of God. The Hayward Pool products warranty does not apply to complete warranty registration for :
Attn: Warranty Dept Or REGISTER YOUR WARRANTY ON-LINE AT WWW.HAYWARD.COM
In Ground
Above Ground
Spa
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
12 In...
Hayward 1-1/2 Hp Pf Mtx 2 Spd W/Sw Expert Line Reviews
We have not received any reviews for Hayward yet.