2011 Yamaha Motorsports Zuma Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2011 Yamaha Motorsports Zuma manuals!
Problems with 2011 Yamaha Motorsports Zuma?
Ask a Question
Other Models
Free 2011 Yamaha Motorsports Zuma manuals!
Problems with 2011 Yamaha Motorsports Zuma?
Ask a Question
Other Models
Popular 2011 Yamaha Motorsports Zuma Manual Pages
Owners Manual - Page 1
OWNER'S MANUAL
YW50A
LIT-11626-24-58 5PJ-F8199-17
Read this manual carefully before operating this vehicle.
Owners Manual - Page 2
EAU10042
Q Read this manual carefully before operating this vehicle if it is sold. This manual should stay with this vehicle.
Owners Manual - Page 6
...fuel consumption .. 5-3 Engine break-in ...5-4 Parking ...5-4 PERIODIC MAINTENANCE AND ADJUSTMENT ...6-1 Owner's tool kit...6-2 Periodic maintenance chart for the emission control system ...6-3 General maintenance and lubrication chart...6-4 Removing and installing the panel ...6-8 Checking the spark plug...6-8 Final transmission... the Autolube pump ...6-18 Lubricating...SPECIFICATIONS ...8-1
Owners Manual - Page 12
... cargo must not exceed the maximum load limit. Yamaha is an important decision. vehicle could cause an accident. This vehicle is changed. Do not run engine in a position to a sidecar. Make sure that accessories and cargo are available only from a Yamaha dealer, have been designed, tested, and approved by Yamaha or modifications...
Owners Manual - Page 13
... could result, which could cause a dangerous loss of lights or engine power.
●
1 2 3 4
Aftermarket Tires and Rims The tires and rims that would impair the performance of the vehicle's design or operation characteristics can put you may limit control ability, therefore, such accessories are responsible for tire specifications and more information on replacing your scooter...
Owners Manual - Page 25
...a pump octane number [(R+M)/2] of 86 or higher, or a research octane number of 91 or higher. EAU40681
can cause damage to use a gasoline of unleaded fuel will ...EWA10862
Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 5.7 L (1.5 US gal, 1.25 Imp.gal)
1 2 3 4 5 6 7 8 9
Your Yamaha engine has been designed to the fuel system or vehicle performance problems.
EAU13433
Catalytic...
Owners Manual - Page 30
... in safe operating condition. Do not operate the vehicle if you use it to inspect or maintain the vehicle properly increases the possibility of an accident or equipment damage. If a problem cannot be corrected by the procedures provided in the Owner's Manual.
PRE-OPERATION CHECKS
EAU15596
Inspect your vehicle each time you find any...
Owners Manual - Page 31
... engine oil Final transmission oil...tires
9
Brake levers
• Make sure that operation is smooth. • Lubricate lever pivoting points if necessary.
6-18
4-2 Check fluid level in oil tank. • If necessary, add recommended oil to specified level. PRE-OPERATION CHECKS
Before using this vehicle, check the following points:
ITEM Fuel • Check fuel level in fuel...
Owners Manual - Page 33
... should be as short as possible to operating the vehicle for the first time.
1 2
1
3
ENGINE STOP
ZAUM00**
1. Do not crank the engine more than 5 seconds on , turn it to "ON".
4.
Engine stop switch to "#". 2. EAU15943
OPERATION AND IMPORTANT RIDING POINTS
EAU15951 EAUT2762
Read the Owner's Manual carefully to become familiar with the controls can...
Owners Manual - Page 36
... operation, the fi nal transmission oil must be changed.[ECAM1071]
ECA10270
EAU17213
Parking
When parking, stop the engine, and then remove the key from time to the correct operating clearances.
During this reason, you should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. NOTICE If any condition that...
Owners Manual - Page 38
... the emission control devices and systems may be performed by any repair establishment or individual that is located inside the storage compartment. (See page 3-9.) The service information included in this manual and the tools provided in the owner's tool kit are also vital to proper engine operation and maximum performance. EAU1722A
PERIODIC MAINTENANCE AND ADJUSTMENT
EAU17302 EAU17451...
Owners Manual - Page 39
...with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 ...8730;
1 * 2 * 3 *
Fuel line Idle speed Exhaust system Air induction system
• Check fuel and vacuum hoses for cracks or damage. • Replace if necessary. • Check and adjust engine idle speed. • Check for leakage...
Owners Manual - Page 41
...lever pivot shaft Rear brake lever pivot shaft Centerstand Front fork Shock absorber assembly Autolube pump Final transmission oil V-belt Control and meter cables
• Check all chassis fitting and .... • Bleed if necessary. • Check vehicle for oil leakage. • Change. • Replace. • Apply Yamaha chain and cable lube or engine oil thoroughly
13 * 14 * 15 16 * 17...
Owners Manual - Page 44
...removed and checked in accordance with the spark plug wrench included in the owner's tool kit. Remove panel A. (See page 6-8.) 3. Panel A
ZAUM00**
The panel shown ...Place the vehicle on the centerstand. 2. R e m o v e t h e s p a r k p l u g a s shown, with the periodic maintenance and lubrication chart. Since heat and deposits will cause any spark plug to perform some of the engine. In ...
Owners Manual - Page 45
.... TIP If the spark plug shows a distinctly different color, the engine could be tightened to the specified torque. Spark plug gap
...1 2 3 4
To check the spark plug 1. Instead, have a Yamaha dealer check the vehicle. 2.
Check the spark plug for electrode erosion and excessive
6-9
ZAUM00**
TIP If a torque wrench...problems yourself. Install the panel.
5 6 7 8 9
1
1.
Owners Manual - Page 46
... oil is found, have a Yamaha dealer check and repair the scooter. Start the engine, warm up the final transmission oil by riding the scooter for oil leakage. Remove the final transmission oil drain bolt and its O-ring from the final transmission case.
1
Tightening torque: Final transmission oil drain bolt: 18 Nm (1.8 m·kgf...
Owners Manual - Page 60
... gap, or replace the spark plug. The engine does not start .
There is compression. Supply fuel.
2. Have a Yamaha dealer check the vehicle. Battery
8
Operate the electric starter.
The engine does not start. EAU1722A
PERIODIC MAINTENANCE AND ADJUSTMENT
EAU25902
Troubleshooting chart
1. Fuel
1
Check the fuel level in the fuel tank.
Ignition
Wet Remove the spark plug...
Owners Manual - Page 65
...; 43/13) Final drive Gear Transmission type V-belt automatic
1 2 3 4 5 6 7 8 9
Chassis
Frame type Backbone Caster angle 26.50 degree Trail 93.0 mm (3.66 in)
Air filter
Air filter element Wet element
Fuel
Recommended fuel Regular unleaded gasoline only Fuel tank capacity 5.7 L (1.51 US gal, 1.25 Imp.gal)
Front tire
Type Tubeless Size 120/90...
Owners Manual - Page 70
...2 3 4 5 6 7 8 9
If you believe that a safety defect exists in a group of vehicles, it may call the Vehicle Safety Hotline toll-free at 1-888-327-4236 (TTY: 1-800-424-9153); or write to http://www.safercar...NHTSA receives similar complaints, it may open an investigation, and if it finds that your vehicle has a defect which could cause a crash or could cause injury or death, you should ...
Owners Manual - Page 78
... ...9-2 Vehicle identification number ...9-1
N
Noise regulation ...9-4
P
Panel, removing and installing ...6-8 Parking...5-4 Part locations ...2-1
W
Warranty, extended...9-9 Warranty, limited ...9-7 Wheels ...6-14 Wheel bearings, checking...6-21
F
Final transmission oil ...6-10 Front brake lever free play, checking...6-14 Front fork, checking ...6-19 Fuel ...3-6 Fuel and 2-stroke engine...
2011 Yamaha Motorsports Zuma Reviews
Do you have an experience with the 2011 Yamaha Motorsports Zuma that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2011 Yamaha Motorsports Zuma yet.
Earn 750 points for your review!