2005 Yamaha Motorsports SXVenom Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2005 Yamaha Motorsports SXVenom manuals!
Problems with 2005 Yamaha Motorsports SXVenom?
Ask a Question
Other Models
Free 2005 Yamaha Motorsports SXVenom manuals!
Problems with 2005 Yamaha Motorsports SXVenom?
Ask a Question
Other Models
Popular 2005 Yamaha Motorsports SXVenom Manual Pages
Owners Manual - Page 3
...CZ-01E
C. A
ESU00286
1- KEY NUMBER: C
CZ-01E
Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering spare...1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, ...
Owners Manual - Page 4
... or unauthorized use without the written permission of craftsmanship and reliability that you have made Yamaha a leader in these fields. Printed in the production of a Yamaha snowmobile. INTRODUCTION
Congratulations on your snowmobile, please consult a Yamaha dealer. To maintain the high quality and performance of this snowmobile, it is important that have any...
Owners Manual - Page 5
... special precautions that must be considered a permanent part of printing, there may be minor discrepancies between your snowmobile and this manual. NOTE:
@
A NOTE provides key information to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile. If there is distinguished in product design and quality.
YOUR SAFETY IS INVOLVED!
This...
Owners Manual - Page 6
... CORPORATION, U.S.A. SNOWMOBILE LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS ...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Throttle override system (T.O.R.S.) ...5-2 Speedometer unit ...5-4 High beam indicator light ...5-5 Fuel meter and grip/thumb...
Owners Manual - Page 7
... the engine...7-11 Transporting ...7-12 PERIODIC MAINTENANCE ...8-1 Periodic maintenance chart ...8-1 Tool kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-6 Throttle cable adjustment ...8-6 Oil pump cable ...replacement...8-29 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3
WIRING DIAGRAM ...12-1
Owners Manual - Page 14
...engine. For safety and proper care of the following for your snowmobile, you could collide with another vehicle.... any of the snowmobile, always perform the pre-operation checks on public streets, ...engine.
SXV60 and SXV60ER are prohibited. Passengers are designed to the home position when it is released. 6. This may result if you do not understand. 2. Read the Owner's Manual...
Owners Manual - Page 15
... after running into your eyes, see your clothes. 10. Do not allow anyone to stand behind the snowmobile when starting the engine to the operator or bystanders. 8. G Use an approved fuel container. exhaust fumes are dangerous. 2. Stay on your skin or clothing, immediately wash your skin with soap and water, and change...
Owners Manual - Page 21
is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. Otherwise, the T.O.R.S. will not work properly. Mode A B Running On Off Run C Trouble Off Off T.O.R.S. WARNING
@
G
G
A
@
If the T.O.R.S. Be sure to use the specified spark plug ...
Owners Manual - Page 24
... of the above problems by the self-diagnosis device of the fuel meter flash pattern
1 2 0.5 s 0.5 s 8 · · · 3s
Warning indicator, warning light, and fuel meter segment flash ...possible. When the engine is started, the grip/thumb warmer levels are set to the levels saved when the engine was stopped.
@
ESU00287
Fuel level warning indicator
The fuel level warning indicator ...
Owners Manual - Page 25
... light flash continuously in the coolant reservoir. (See page 6-2.)
CAUTION:
@
Do not operate the engine if it overheats.
@
The coolant temperature warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead..., or short circuit when detected by the self-diagnosis device of the above problems by flashing continuously. (See the table below the minimum level, the oil...
Owners Manual - Page 26
...may be some problem with the electrical circuit, lead couplers, etc. (See page 5-9 for warning indicator and warning light flash pattern numbers 1-5.) Stop the engine and allow ...the snowmobile. Then, check that the wire harness couplers are connected properly in the engine compartment. ESU03970
Self-diagnosis warning indicator
The self-diagnosis warning indicator indicates a malfunctioning sensor...
Owners Manual - Page 35
... or water absorbing additives with straight gasoline as specified. G G G
@
age.
Tap water can be used temporarily in the oil tank. The fuel tank should be careful not to the engine parts. If the coolant level is below the "COLD LEVEL" mark, add soft water until it reaches the "COLD LEVEL" mark. (See...
Owners Manual - Page 43
... INFORMATION" section carefully before starting )
NOTE:
@
The starter lever (choke) is not required when the engine is applied. Warm up ) Closed (warm engine starting the engine. Make sure that the engine stop switch is returned to the closed position.
@
Manual starting ) Half-open position.
Fully open the starter lever (choke). 1 2 3 4 Starter lever (choke) Fully open...
Owners Manual - Page 44
... 10 seconds on the screwdriver handle. 1 Screwdriver handle
7-2 After the engine starts, put the starter lever (choke) in the tool kit at the factory.
@
1.
If the engine fails to the "START" position. Proceed with the "Starting the engine" section items 1 and 2 for the "Manual starting model For SXV60 If the recoil starter system should be...
Owners Manual - Page 45
... is returned to the closed position. 7. WARNING
@
Do not wind the emergency starter rope around your hand.
@
6.
3.
After the engine starts, put the starter lever (choke) in the "Starting the engine" and "Manual starting model" sections.
7-3 WARNING
@
Avoid contact with the edge of the primary sheave assembly. 1 Rope stopper 2 Primary sheave assembly edge...
Owners Manual - Page 47
...vehicle, and your riding position and your balance are the two basic factors of the snowmobile to achieve the skill necessary to enjoy riding safely. However, it is supplied with hours of time. Before operating the snowmobile, read this Owner's Manual... more reliable snowmobile. Apply the throttle slowly and smoothly.
Once the engine has warmed up, you ride, always perform the ...
Owners Manual - Page 58
... indicate an intake track air leak or carburetion problem for a snowmobile that is a medium to a Yamaha dealer for most periodic maintenance and minor repair. Consult a Yamaha dealer before changing to properly tighten nuts and bolts. 1Tool kit B È SXV60/SXV60ER É VT60
CAUTION:
@
Before starting the engine, make sure that cylinder. Do not attempt...
Owners Manual - Page 64
... operating over a high altitude of the problems found in high altitude riding. Your snowmobile can cause poor performance. Common problems are the most of 900 m (3,000...fuel ratio.
If you plan to operate your snowmobile may also require different settings for every 305 m (1,000 ft) of a gasoline engine to about 3% for the drive chain gears and V-belt clutch to avoid poor performance...
Owners Manual - Page 85
... settings for altitude or conditions ...Ask a Yamaha dealer to inspect. 2. Engine overheats 1. Engine does not upshift or downshift properly or engages harshly 1. "Hydrolock" occurs when fuel has filled the crankcase when the vehicle has been transported...Remove the spark plugs and turn the engine over several times with the ignition off to inspect. Oily or...
Owners Manual - Page 89
SPECIFICATIONS
SXV60/SXV60ER/VT60 2,780 mm (...Engine oil type Carburetor type Fuel
SXV60/SXV60ER/VT60 Liquid cooled 2-stroke, 7-port Parallel 3-cylinder 593 cm3 65.0 × 59.6 mm (2.56 × 2.35 in) 1,600 ± 100 r/min YAMALUBE 2-cycle oil MIKUNI, TM31 × 3 Unleaded gasoline R+M ; 88 or higher 2 Manual with recoil starter: SXV60 Electric and manual with recoil starter: SXV60ER/VT60 Pump...
2005 Yamaha Motorsports SXVenom Reviews
We have not received any reviews for the 2005 Yamaha Motorsports SXVenom yet.