2005 Yamaha Motorsports RS Rage Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2005 Yamaha Motorsports RS Rage manuals!
Problems with 2005 Yamaha Motorsports RS Rage?
Ask a Question
Other Models
Free 2005 Yamaha Motorsports RS Rage manuals!
Problems with 2005 Yamaha Motorsports RS Rage?
Ask a Question
Other Models
Popular 2005 Yamaha Motorsports RS Rage Manual Pages
Owners Manual - Page 3
...PRIMARY ID):
CZ-01E
C. KEY NUMBER: C
CZ-01E
Record the frame number, engine number (Primary ID), and key number in the spaces provided for assistance when ordering.... 1 The frame number is the seventeen-digit number stamped on the frame of the snowmobile. (See fig. È.) 2 The engine number is stamped in the location as shown. (See fig. É.) 3 Key number (See fig. Ê.) Also, record ...
Owners Manual - Page 4
...fine sporting and touring snowmobiles. To maintain the high quality and performance of this manual. This manual will give you an understanding of the operation, inspection, and ...-12628-02-39 RST90K OWNER'S MANUAL ©2004 by Yamaha Motor Corporation, U.S.A. 1st Edition, June 2004 All rights reserved. If you and your purchase of craftsmanship and reliability that you have made Yamaha a...
Owners Manual - Page 5
... avoid damage to the snowmobile operator, a bystander, or a person inspecting or repairing the snowmobile.
YOUR SAFETY IS INVOLVED!
WARNING
@
PLEASE READ AND UNDERSTAND THIS MANUAL COMPLETELY BEFORE OPERATING THE SNOWMOBILE.
@
NOTE:
@
G
G
Yamaha continually seeks advancements in this manual.
NOTE:
@
A NOTE provides key information to make procedures easier or clearer. Therefore...
Owners Manual - Page 6
... LIMITED WARRANTY ...1-1 YAMAHA EXTENDED SERVICE (Y.E.S.) ...1-4 LOCATION OF THE IMPORTANT LABELS...2-1 SAFETY INFORMATION ...3-1 DESCRIPTION ...4-1 CONTROL FUNCTIONS ...5-1 Main switch...5-1 Starter lever (choke) ...5-2 Throttle lever...5-2 Engine overheating prevention system ...5-2 Throttle override system (T.O.R.S.) ...5-3 Speedometer unit ...5-4 High beam indicator light ...5-4 Fuel meter...
Owners Manual - Page 7
... kit ...8-4 Spark plug inspection ...8-4 Engine idle speed adjustment ...8-6 Throttle cable adjustment ...8-6 Carburetor adjustment...8-7 High altitude adjustments ...8-9 Adjusting the valve clearance...8-9 Changing the engine oil... replacement...8-31 TROUBLESHOOTING ...9-1 STORAGE ...10-1 SPECIFICATIONS ...11-1 Dimensions...11-1 Engine ...11-1 Chassis...11-2 Electric...11-3
WIRING DIAGRAM ...12-1
Owners Manual - Page 13
NOTE:
@
The following suspension adjustment charts are included with the Owner's Manual.
@
2-2
Owners Manual - Page 14
...every time before starting the engine. Consult a Yamaha dealer ...engine. This may result if you ignore any control or function you could be dangerous to the operator or bystanders.
3-1 Never drive the snowmobile with another vehicle. 3. Severe injury or death may overheat the brake disc and reduce braking ability. 6. Read the Owner's Manual and all of the snowmobile, always perform...
Owners Manual - Page 15
G Never add fuel when the engine is running . Allow the engine to cool for operation of gasoline vapor, or get some gasoline into wires could cause an accident and injury.
3-2 G Use an approved fuel container. Never remove the fuel cap indoors. G Make sure that will permit use of your exposure to transport the snowmobile in the...
Owners Manual - Page 16
... dirt, sand, grass, rocks, or bare pavement may cause loss of time. Allow the engine to release the throttle and apply the brake gently-not suddenly. Operation under such conditions will ... Use on most surfaces is to cool off before storing the snowmobile in an enclosed space. 4. Fuel may damage the snowmobile. 4. Modifications may render your snowmobile. 6. Always refer to the "STORAGE" ...
Owners Manual - Page 18
... _ a
Side mirror Tail/brake lights Snow flap Brake lever Parking brake lever Grip warmer adjustment switch Headlight beam switch Engine stop switch Thumb warmer adjustment switch Throttle lever Shift lever Shroud latch Main switch Auxiliary DC jack Starter lever Tachometer Low ... temperature warning indicator Fuel level warning indicator Oil level warning indicator Speedometer Grip warmer indicator ...
Owners Manual - Page 19
... is switched on.
The starter motor starts. The key can be removed only in this position. 2 "ON" The ignition circuit is switched on after the engine starts.
@
NOTE:
@
The headlights, meter lights, and taillights come on . 3 "START" The starting circuit is switched off. CAUTION:
@
Release the switch immediately after the...
Owners Manual - Page 21
... sure to idle when the lever is activated, make sure that the cause of the malfunction has been corrected and that the engine can be operated without a problem before restarting the engine. ESU04151
Throttle override system (T.O.R.S.)
If the carburetor or throttle cable should malfunction during operation, the T.O.R.S. will flash in the tripmeter/odometer...
Owners Manual - Page 24
...
The fuel level warning indicator indicates a malfunctioning sensor, disconnected coupler, broken lead, or short circuit when detected by the self-diagnosis device of the above problems by flashing continuously. ESU00377
Oil level warning indicator
The oil level warning indicator 1 and the warning light 2 come on, place the snowmobile on when the engine oil...
Owners Manual - Page 25
..., check that the wire harness couplers in the tripmeter/odometer display. When this occurs, stop the engine immediately and allow it overheats.
@
ESU04251
Self-diagnostic system This model is displayed during operation, there may be some problem with a self-diagnostic system for various electrical circuits. If any of those circuits are defective...
Owners Manual - Page 28
... the jack and close the auxiliary DC jack cap.
@
CAUTION:
@
G
G
Do not use an automotive cigarette lighter or other accessory with a plug that gets hot because the jack can be damaged. Start the engine. 2. NOTE:
@
After using the auxiliary DC jack, be used for the auxiliary DC jack. NOTE:
@
The auxiliary DC...
Owners Manual - Page 47
...engine idling, release the parking brake. 2. Avoid high speeds until you with operating your snowmobile at maximum performance until you are ready to begin decelerating early. Please read this Owner's Manual... well before attempting more reliable snowmobile. ESU01272
Riding your snowmobile Getting to know your snowmobile
A snowmobile is a rider active vehicle, and your riding position...
Owners Manual - Page 55
... these items be serviced by a Yamaha dealer.
8-1 Check operation. ∗ Repair if necessary. Check operation. ∗ Repair if necessary. ESU00139
8- Check operation. ∗ Repair if necessary.
Replace if necessary.
8-4-8-5
∗ Valve clearance Engine oil Engine oil filter cartridge Fuel ∗ Fuel filter ∗ Fuel line
Check clearance.
Replace...
Owners Manual - Page 58
...tool kit is firmly seated in the holder and is closed securely.
@
NOTE:
@
If you do not have a torque wrench available during a service operation requiring one, take the snowmobile to diagnose such problems yourself...plug inspection
The spark plug is an important engine component and is a medium to a light tan color for inspection and possible repairs. The ideal coloration at this point is ...
Owners Manual - Page 63
... with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from the ...most of the problems found in the periodic maintenance chart.
8-9 Common problems are any changes...fuel ratio too rich, which is less horsepower available, even with proper carburetion. Proper carburetion adjustments will correct the air/fuel ratio. Your snowmobile can cause poor performance...
Owners Manual - Page 90
... does not move 1. Problem with the driveline ...See H above.
9-3
WARNING
@
Be sure to pull the lead covers back over several times with the ignition off to expel excess fuel. "Hydrostatic lock" occurs when fuel has filled the cylinders when the vehicle has been transported...Remove the spark plugs and turn the engine over the terminals...
2005 Yamaha Motorsports RS Rage Reviews
We have not received any reviews for the 2005 Yamaha Motorsports RS Rage yet.