2004 Yamaha Motorsports V Star Classic Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2004 Yamaha Motorsports V Star Classic manuals!
Problems with 2004 Yamaha Motorsports V Star Classic?
Ask a Question
Other Models
Free 2004 Yamaha Motorsports V Star Classic manuals!
Problems with 2004 Yamaha Motorsports V Star Classic?
Ask a Question
Other Models
Popular 2004 Yamaha Motorsports V Star Classic Manual Pages
Owners Manual - Page 6
... check list ...4-2 OPERATION AND IMPORTANT RIDING POINTS ...5-1 Starting and warming up a cold engine ...5-1 Starting a warm engine ...5-2 Shifting ...5-3 Engine break-in ...5-4 Parking ...5-5 PERIODIC MAINTENANCE AND MINOR REPAIR ...6-1 PERIODIC MAINTENANCE ...6-1 Owner's tool kit ...6-1 Periodic maintenance chart for the emission control system ...6-3 General maintenance and lubrication chart...
Owners Manual - Page 9
...the motorcycle is changed. G Wear a face shield or goggles. G Never touch the engine or exhaust system during operation to your legs, ankles, and feet. Always wear protective ... on the control levers, footrests, or wheels and cause injury or an accident. Loading and accessories Adding accessories or cargo to maintain control of the motorcycle. • The passenger should always hold onto the...
Owners Manual - Page 10
...accessories that would impair the performance of the motorcycle due to aerodynamic effects. G Never install accessories or carry cargo that may also cause instability when passing or being passed by large vehicles. • Certain accessories...-Yamaha accessories. Check accessory mounts and cargo restraints frequently. Accessories Genuine Yamaha accessories have been specifically designed ...
Owners Manual - Page 11
...leak out of the carburetor or fuel tank. If you should lean over . • Do not park the motorcycle near an open flame. G Never start the engine or let it may fall ...on a slope or soft ground, otherwise it run for manual type). SAFETY INFORMATION
Gasoline and exhaust gas G GASOLINE IS HIGHLY FLAMMABLE: • Always turn the engine off when refueling. • Take care not to spill ...
Owners Manual - Page 20
... comes on when the high beam of fuel. EAU11490
Speedometer unit
3
1. 2. 3....engine is turned to plan future fuel stops.
3-2
The speedometer unit is in the neutral position.
High beam indicator light " " Turn signal indicator light " Neutral indicator light " " Engine trouble warning light "
Engine trouble warning light " " This warning light comes on when the transmission...
Owners Manual - Page 21
... turn signal lights will self-cancel after it has returned to crank the engine with a self-canceling system, the turn signal lights can also be canceled manually by pushing the switch in case of an emergency, such as when the vehicle overturns or when the throttle cable is equipped with the starter. However...
Owners Manual - Page 22
...of the engine and is located at the left side of the engine and is used in combination with the clutch lever when shifting the gears of the 5-speed constant-mesh transmission equipped ...used in combination with the clutch lever when shifting the gears of the 5-speed constant-mesh transmission equipped on this motorcycle. The lever should be pulled rapidly and released slowly for smooth ...
Owners Manual - Page 25
... does not exceed 10%.
RES
1. Gasohol containing methanol is not running.
1. Gasohol containing ethanol can cause damage to the fuel system or vehicle performance problems.
EAU13550
Fuel cock
The fuel cock supplies fuel from the tank to this position when starting the engine and riding. INSTRUMENT AND CONTROL FUNCTIONS
knocking (or pinging) occurs, use a gasoline of unleaded...
Owners Manual - Page 32
... in gear and the sidestand is still down . G It prevents starting when the transmission is in gear and the sidestand is up, but the sidestand is moved down .
G It cuts the running engine when the transmission is in gear and the clutch lever is pulled, but the clutch lever is noted, have a Yamaha...
Owners Manual - Page 33
... may be defective. Turn the key on . 3.
Shift the transmission into the neutral position. 5. The motorcycle should not be ridden.
3-15
Move the sidestand down . YES
With the engine still running: 6. Move the sidestand down . 2. Move the sidestand up . 7.
NOTE: This check is OK. The system is most reliable if performed with a warmed-up...
Owners Manual - Page 37
...transmission is up . Before starting out, make sure that the engine stop switch is adequate ventilation.
G The transmission... not crank the engine more than 10 ... NOTE: When the transmission is turned to "ON",...engine...transmission into the neutral position.
Turn the starter (choke) on page 3-14. Start the engine by pushing the start switch, wait a few seconds. NOTE: If the engine...
Owners Manual - Page 39
... in the following table, close the throttle, and at the same time, release the clutch lever slowly. 4. Pull the clutch lever to avoid damaging the engine, transmission,
To start out and accelerate 1. Follow the same procedure when shifting to withstand the shock of time with the...
Owners Manual - Page 40
... the recommended shift points.
EAU17041
Recommended shift points The recommended shift points during acceleration and deceleration are shown in the engine wear and polish themselves to the correct operating clearances. Shift the transmission into first gear when the motorcycle reaches 25 km/h (15.5 mi/h). For this period, prolonged full-throttle operation or...
Owners Manual - Page 42
... lubrication will keep your vehicle in the safest and most important points of the emission control devices and systems may be performed by any repair establishment or individual that is located inside the storage compartment. (See page 3-11.) The service information included in this manual and the tools provided in the performance of the owner. THESE...
Owners Manual - Page 44
...12 months 18 months 24 months 30 months Replace
1 * 2 *
Fuel line Fuel filter
• Check fuel hose for cracks or damage. • Replace if necessary. •...8226; Check and adjust engine idle speed. • Check for the emission control system
INITIAL No.
PERIODIC MAINTENANCE AND MINOR REPAIR
EAU17600
Periodic maintenance chart for... have a Yamaha dealer perform the service.
6-3
Owners Manual - Page 47
...months 24 months 30 months
18 19
Engine oil Engine oil filter element
• Change (warm engine before draining). • Replace. .... • Apply Yamaha chain and cable lube or engine oil 10W-30 thoroughly. • Check operation and free...items require special tools, data and technical skills, have a Yamaha dealer perform the service.
NOTE: From 24000 mi (37000 km) or 36 months, repeat ...
Owners Manual - Page 51
...REPAIR
3. Instead, have the same color. However, the spark plug should be defective. Spark plug gap
Spark plug gap: 0.8-0.9 mm (0.031-0.035 in the engine have a Yamaha dealer check the vehicle... and excessive carbon or other deposits, and replace it to specification. Do not attempt to the specified torque as soon as ...engine could be tightened to diagnose such problems yourself.
Owners Manual - Page 57
... maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified tires. The tire air pressure must be adjusted by a Yamaha dealer at the intervals specified in improper air-fuel mixture and/or engine noise.
Tire air pressure (measured on cold tires (i.e., when the temperature of the tires equals the ambient temperature...
Owners Manual - Page 83
SPECIFICATIONS
Dimensions:
Overall length: XVS650 2340 mm (92.1 in) XVS650A 2450 mm (96.5 in) ...fuel: XVS650 233.0 kg (514 lb) XVS650A 247.0 kg (545 lb) XVS650AT 247.0 kg (545 lb)
Clutch:
Clutch type: Wet, multiple-disc
Recommended engine oil grade: API service SE, SF, SG type or higher Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt) (2.29 Imp.qt) 8-1
Transmission...
Owners Manual - Page 84
SPECIFICATIONS
Primary reduction ratio: 68/38 (1.789) Secondary reduction system: Shaft drive Secondary reduction ratio: 19/18 × 32/11 (3.071) Transmission type: Constant mesh 5-speed Operation: Left foot operation Gear ratio: 1st: 38/14 ... XVS650AT 200.0 kg (441 lb) (Total weight of rider, passenger, cargo and accessories)
Front tire:
Type: With tube
Rear wheel:
Wheel type: Spoke wheel
8-2
2004 Yamaha Motorsports V Star Classic Reviews
We have not received any reviews for the 2004 Yamaha Motorsports V Star Classic yet.