2004 Yamaha Motorsports V Star 650 Custom Problems and Repair Information
Get Help and Support for Yamaha Motorsports
View All Support Options Below
Free 2004 Yamaha Motorsports V Star 650 Custom manuals!
Problems with 2004 Yamaha Motorsports V Star 650 Custom?
Ask a Question
Other Models
Free 2004 Yamaha Motorsports V Star 650 Custom manuals!
Problems with 2004 Yamaha Motorsports V Star 650 Custom?
Ask a Question
Other Models
Popular 2004 Yamaha Motorsports V Star 650 Custom Manual Pages
Owners Manual - Page 6
... check list ...4-2 OPERATION AND IMPORTANT RIDING POINTS ...5-1 Starting and warming up a cold engine ...5-1 Starting a warm engine ...5-2 Shifting ...5-3 Engine break-in ...5-4 Parking ...5-5 PERIODIC MAINTENANCE AND MINOR REPAIR ...6-1 PERIODIC MAINTENANCE ...6-1 Owner's tool kit ...6-1 Periodic maintenance chart for the emission control system ...6-3 General maintenance and lubrication chart...
Owners Manual - Page 9
... or reduction of vision which could catch on the passenger footrests. G Never touch the engine or exhaust system during operation to maintain control of the motorcycle. • The passenger ...equipment, may render the motorcycle unsafe for off-road use extreme caution when adding cargo or accessories to your legs, ankles, and feet. G Wear a face shield or goggles. Modifications may...
Owners Manual - Page 10
...vehicles. • Certain accessories can create a sudden imbalance. Accessories Genuine Yamaha accessories have been specifically designed for the proper selection, installation and use on both sides of non-Yamaha accessories. If accessories... and accessory weight should be kept as possible. Since Yamaha cannot test all other accessories that would impair the performance of your...
Owners Manual - Page 11
...motorcycle, note the following: • The engine and exhaust system may be hot, therefore, park the motorcycle in an area that the fuel cock is turned to "ON" or "...vehicle, make sure that it is kept upright and that has adequate ventilation. a kerosene heater, or near a flammable source (e.g. G Never start the engine or let it run for manual type). SAFETY INFORMATION
Gasoline and exhaust gas...
Owners Manual - Page 20
... " " Turn signal indicator light " Neutral indicator light " " Engine trouble warning light "
Engine trouble warning light " " This warning light comes on when the transmission is in the neutral position. EAU11060
NOTE: This warning light comes ...indicator light comes on when the high beam of fuel. " "
EAU11020
Turn signal indicator light " " This indicator light flashes when the turn signal ...
Owners Manual - Page 21
... throttle cable is moving, so that the turn signal lights can also be canceled manually by pushing the switch in after the vehicle has traveled both about 150 m (490 ft) and for starting instructions prior to starting the engine. ECA10050
CAUTION: See page 5-1 for approximately 15 seconds. INSTRUMENT AND CONTROL FUNCTIONS
EAU12341 EAU12400...
Owners Manual - Page 22
...
3
1. Shift pedal
The clutch lever is used in combination with the clutch lever when shifting the gears of the engine and is located at the left side of the 5-speed constant-mesh transmission equipped on this motorcycle. The lever should be pulled rapidly and released slowly for smooth clutch operation. The shift...
Owners Manual - Page 25
... lever positions are two types of a different brand or premium unleaded fuel. Gasohol containing ethanol can cause damage to the fuel system or vehicle performance problems.
EAU13550
Fuel cock
The fuel cock supplies fuel from the tank to this position when the engine is not recommended by Yamaha because it can be used if the ethanol content does not...
Owners Manual - Page 32
... circuit cut -off system according to the following functions.
G It cuts the running engine when the transmission is in gear and the clutch lever is pulled, but the clutch lever is noted...have a Yamaha dealer check the system before riding.
3-14 G It prevents starting when the transmission is in gear and the sidestand is still down . EWA10250
3
WARNING If a malfunction is ...
Owners Manual - Page 33
... ridden until checked by a Yamaha dealer. YES
With the engine still running: 6. Move the sidestand down . 2. Does the engine stall? The motorcycle should not be ridden until checked by a Yamaha dealer.
3
YES
After the engine has stalled: 10. NOTE: This check is most reliable if performed with a warmed-up . 11. YES
NO
The clutch switch...
Owners Manual - Page 37
... on and completely close the throttle. (See page 3-8.) 5. Turn the key to "ON" and make sure that the engine stop switch is in gear with the sidestand down.
5
1. G The transmission is up . Turn the fuel cock lever to the procedure described on , otherwise have a Yamaha dealer check the electrical circuit. 4. Before starting out...
Owners Manual - Page 39
The gear positions are not designed to avoid damaging the engine, transmission,
To start out and accelerate 1.
Inadequate lubrication may damage the transmission. Shift the transmission into the neutral position, press the shift pedal down repeatedly until it reaches the end of its travel, and then slightly raise it. Open the ...
Owners Manual - Page 40
... POINTS
EAU16841
NOTE: Always shift gears at the recommended shift points. EAU16700
5
To decelerate 1. If the engine is never a more important period in the engine wear and polish themselves to slow the motorcycle. 2. Shift the transmission into first gear when the motorcycle reaches 25 km/h (15.5 mi/h). The various parts in the life...
Owners Manual - Page 42
... lubrication will keep your vehicle in the performance of the emission control devices and systems may be performed by any repair establishment or individual that is located inside the storage compartment. (See page 3-11.) The service information included in this manual and the tools provided in the owner's tool kit are intended to perform certain maintenance work , have...
Owners Manual - Page 44
...*
Exhaust system
* Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service.
6-3 ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6.... • Check and adjust engine idle speed. • Check for the emission control system
INITIAL No.
PERIODIC MAINTENANCE AND MINOR REPAIR
EAU17600
Periodic maintenance chart for leakage...
Owners Manual - Page 47
...intervals starting from 8000 mi (13000 km) or 12 months.
6-6 PERIODIC MAINTENANCE AND MINOR REPAIR
INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ √ 4000...(25000 km) or 24 months. • Apply Yamaha chain and cable lube or engine oil 10W-30 thoroughly. • Check operation and free play. • Adjust the... and technical skills, have a Yamaha dealer perform the service.
Owners Manual - Page 51
... be tightened to specification. Spark plug gap
Spark plug gap: 0.8-0.9 mm (0.031-0.035 in the engine have a Yamaha dealer check the vehicle. Check that the porcelain insulator around the center electrode on each spark plug for electrode erosion and excessive carbon or other deposits, and replace it to diagnose such problems yourself. To install...
Owners Manual - Page 57
... model. PERIODIC MAINTENANCE AND MINOR REPAIR
EAU21400 EAU21520
Adjusting the valve clearance
The valve clearance changes with the total weight of rider, passenger, cargo, and accessories approved for this from occurring, the valve clearance must be checked and, if necessary, adjusted before each ride.
Tires
To maximize the performance, durability, and safe operation of...
Owners Manual - Page 83
SPECIFICATIONS
Dimensions:
Overall length: XVS650 2340 mm (92.1 in) XVS650A 2450 mm (96.5 in) ...fuel: XVS650 233.0 kg (514 lb) XVS650A 247.0 kg (545 lb) XVS650AT 247.0 kg (545 lb)
Clutch:
Clutch type: Wet, multiple-disc
Recommended engine oil grade: API service SE, SF, SG type or higher Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt) (2.29 Imp.qt) 8-1
Transmission...
Owners Manual - Page 84
SPECIFICATIONS
Primary reduction ratio: 68/38 (1.789) Secondary reduction system: Shaft drive Secondary reduction ratio: 19/18 × 32/11 (3.071) Transmission type: Constant mesh 5-speed Operation: Left foot operation Gear ratio: 1st: 38/14 ... XVS650AT 200.0 kg (441 lb) (Total weight of rider, passenger, cargo and accessories)
Front tire:
Type: With tube
Rear wheel:
Wheel type: Spoke wheel
8-2
2004 Yamaha Motorsports V Star 650 Custom Reviews
We have not received any reviews for the 2004 Yamaha Motorsports V Star 650 Custom yet.